Remington IRH22 Manual

DANGER

www.remingtonpower.co.nz

. If you need heater info; such as an

Be sure to comply with the instructions and warnings provided with this heater. Failure

INDOOR USE PERMITTED ONLY FOR: The temporary heating of adequately ventilated

READ AND UNDERSTAND ALL OF THE INSTRUCTIONS IN THIS MANUAL BEFORE ASSEMBLING, STARTING,

OR SERVICING THE HEATER.

can follow and understand these instructions should operate or service this heater

operating manual, labels, etc. Please visit our website www.remingtonpower.co.nz

NOT FOR USE IN RESIDENTIAL LIVING AREAS OR IN ENCLOSED SPACES WITHOUT ADEQUATE VENTILATION.

FOR OUTDOOR USE.

buildings or structures under construction , alteration or repair . This is an unvented portable heater that uses air

(Oxygen) from within the area in which it is used. Failure to provide adequate combustion and ventilation air will result in

asphyxiation, carbon monoxide poisoning, bodily injury or death. Refer to “Ventilation” on Page 9..

2. www.remingtonpower.co.nz

CONTENTS

Introduction....................................................................3

Environmental Protection..............................................3

Safety Information........................................................3

Specifications..........................................................6

Features............................................................................7

Adding Fuel.........................................................................8

Ventilation....................................................................9

Operation.....................................................................9

Controls..................................................................10

Airflow.......................................................................11

Ducting.....................................................................12

Maintenance................................................................13

Wiring Diagram.............................................................14

Troubleshooting.........................................................15

Warranty......................................................................17

www.remingtonpower.co.nz

air must be provided. Refer to “Ventilation”

on page 9. Bulk fuel storage should be a

minimum of 8 metres from heater.

WARNING: Do not operate this

heater until you have read and

thoroughly understand these safety

and operating instructions.

Failure to comply with the precautions

and instructions provided with this heater

can result in death, serious bodily injury,

property loss or damage from the hazards

asphyxiation or carbon monoxide poisoning.

Only persons who can read and understand

these instructions should use or service this

heater.

WARNING: Do not start the heater

when excess fuel has accumulated.

WARNING: Do not start the heater

when the chamber is hot.

INTRODUCTION

Your new Remington Heater will more than

satisfy your expectations. It has been manu-

factured under stringent quality standards to

meet superior performance criteria.You will

and, with proper care, it will give you many

years of dependable service.

CAUTION: Carefully read through

this entire Instruction Manual before

operating your new Remington

Heater. Take special care to heed the

Cautions and Warnings.

ENVIRONMENTAL

PROTECTION

Recycle unwanted materials

instead of disposing of them

as waste. All tools, hoses and

packaging should be sorted,

taken to the local recycling

centre and disposed of in an

environmentally safe way.

SAFETY INFORMATION

WARNING: Fire, burn, inhalation and

explosion hazard.

Keep combustibles such as building

materials, paper or cardboard a safe

distance away from the heater as

recommended by these instructions. Never

use the heater in spaces which contain

products such as; gasoline, solvents, paint

thinners, dust particles, volatile or airborne

combustibles or any unknown chemicals.

This is an unvented portable heater. It uses

air (Oxygen) from the area in which it is

used. Adequate combustion and ventilation

WARNING: Risk of indoor air

pollution!

WARNING: Carbon monoxide

poisoning may lead to death!

Carbon monoxide is toxic. Humans can

tolerate only small amounts of carbon mon-

oxide and so precautions should be taken to

provide proper ventilation. Failure to provide

proper ventilation in accordance with the in-

structions in this manual can result in death.

People with breathing problems should con-

sult a physician before using this heater.

4. www.remingtonpower.co.nz

ALWAYS unplug the heater when not in use.

ALWAYS install the heater so that it is not di

rectly exposed to water spray, rain, dripping

water, or wind.

WARNING:

explosion!

NEVER use fuels such as gasoline, benzine,

paint thinners or other oil compounds in this

heater.

heater is operating or still hot. This heater is

EXTREMELY HOT while in operation.

NEVER block air outlet (front).

NEVER use duct work in front of heater.

NEVER move or handle heater while still hot.

NEVER transport heater with fuel in tank.

NEVER use with an external fuel tank.

CAUTION: Hot while in operation.

Do not touch. Keep children, animals,

clothing and combustibles away from

heater.

Early signs of carbon monoxide poisoning

ventilation / carbon monoxide poisoning are:

Headache • Dizziness • Nausea • Dry Mouth

Sore Throat • Burning of Nose and Eyes

If you experience any of these symptoms:

GET FRESH AIR AT ONCE! Have your

heater serviced and check for proper

ventilation. Some people are more affected

by carbon monoxide than others. These

include: pregnant women, those with heart

or lung problems, anemia or those under the

FOR OUTDOOR USE. INDOOR USE

PERMITTED ONLY FOR: The temporary

heating of adequately ventilated buildings or

structures under construction, alteration or

repair! Provide at least a three square foot

(2,800 sq cm) opening of outside air for

every 100,000 Btu / Hr heater rating. Refer

to “Ventilation” on page 7 for further instruc-

tions.

WARNING: Risk of electric shock!

ALWAYS use only the electrical power (volt

plate of the heater.

ALWAYS use only three-prong, grounded

outlet and extension cord.

ALWAYS locate heater on a stable and level

surface.

If your heater is equipped with a thermostat,

once it is plugged in, it can start at anytime

in accordance with the thermostat setting.

DO NOT let any child to get close to the

heater and touch or hang on the heater.

DO NOT put this heater on uneven

surfaces or on an incline. If used on

unstable surfaces the heater may experi-

ence issues or become a fire risk.

DO NOT put the heater somewhere it may

be at risk of falling. It may cause a fire or

machine failure if it falls.

DO NOT operate heater in a place with

high humidity, or likelihood of getting wet.

If wet the machine may short circuit or

cause an electric shock. This may cause a

fire or risk machine failure.

DO NOT install heater in a place with wind,

or near entrances. It may cause machine

failure or a fire if it falls.

www.remingtonpower.co.nz

ONLY STORE the heater in a dry environ-

ment out of the elements, to remove risk of

rusting or damage to machine. Avoid hot

and humid environments. If damage occurs,

there is a risk of fire and failure of machine.

When the heater is used inside a building,

please connect flue to the outside of

building, and install air ventilation opening

before usage. The flue should be stainless

steel, with a maximum of two bends, and a

total of 4m.

DO NOT touch the heater during use or

immediately after it turned off. It may cause

burns.

DO NOT let children near the heater - Install

a separate child safety barrier when a child

is present. The heater presents a danger to

children and may cause burns.

NEVER MOVE heater when in use, or

immediately after switching off. Only move

when completely cool as it could be a fire or

burning risk.

DO NOT cover heater with flammable items,

such as clothes and if heater makes unusual

sounds, or it begins to smoke, immediately

turn off the power and unplug from mains

power. Contact service agent as soon as

possible. DO NOT USE UNTIL HEATER

HAS BEEN CONFIRMED SAFE TO USE.

There could be a high risk of electric shock

and/or fire.

DO NOT place items such as kettles on the

heater. There is a fire or machine failure

risk.

Ensure the heater is in a well ventilated

area. Do not run in an enclosed area with

little, or no, ventilation to avoid carbon

monoxide poisoning.

DO NOT REPAIR, disassemble or remodel

the heater. Only use approved service

agents for repairing the machine. Contact

Remington Power for more information.

TO REDUCE THE RISK OF EXPLOSION

AND FIRE, do not place other inflammables

such as chemicals and combustible materi-

als nearby the heater. DO NOT use

hairspray, benzene and propane gas or

operate heater near combustibles such as

furniture and curtains.

If heater is being used outdoors protect the

heater from the elements. Use the brake so

it remains stationary.

Please maintain the safety distance.Install

the heater 2.5m from materials that can be

burnt easily such as curtains, wood or

plywood.

DO NOT use in a position where heater is

exposed to rain, strong winds or drizzle as It

may cause abnormal combustion or

affect insulation of electrical parts, leading to

electric shock or fire.

DO NOT install duct at the heater air outlet.

There are risks of abnormal combustion,

fire and explosion due to overheating.

Do not store heater with fuel for long

periods of time. Remove fuel from heater

completely if storing for long periods.

There is a risk of explosion or machine

damage.

If used inside, apply connecting duct to

allow exhaust gas to be channelled outside

as it may cause oxygen deficiency and

carbon monoxide poisoning.

6. www.remingtonpower.co.nz

SPECIFICATIONS

#IRH22

Kerosene/Diesel

1.9 L/Hr

22000 (Kcal/Hr)

130 - 200m3

Heating

AC 230V 〜50Hz

During Ignition: 80W

During Combustion: 65W

1235 x 320 x 1290mm

45L

75mm

22 - 24 Hours

70kg

Serial #:

Model No:

Fuel:

Fuel Consumption:

Caloric Value:

Heating Area:

Usage:

Weight: (Net)

Fuel Duration Hours:

Power:

Power

Consumption

Size: (W x D x H)

Fuel Tank Size:

Flue Diameter: (When connected)

www.remingtonpower.co.nz

FEATURES

8. www.remingtonpower.co.nz

ADDING FUEL

1. Open fuel cap located on the fuel tank.

2. Fill carefully with fuel until the flow meter

reaches “F”.

3. Check for any fuel spillage and clean up

any spilled fuel thoroughly.

WARNING! AVOID SPILLING FUEL

WHEN REFUELING. If fuel leaks

around the heater, close the fuel filler

cap and thoroughly clean any spilt

fuel before operating heater.

WARNING! ONLY USE recommend-

ed high quality kerosene or diesel fuel

for this heater. DO NOT use fuels with

high volatility such as gasoline,

benzene and thinner.

WARNING! NEVER REFUEL THE

HEATER WHEN IT IS IN USE. Only

put in the fuel when the heater is

turned off and has cooled down.

When the heater is used for the first time,

fuel that is used during the manufacturing

process and other substances can

combust. Ignite in a well ventilated area so

any fumes can be removed easily.

When the heater is used for the first time, it

might have some smell due to above

www.remingtonpower.co.nz

DANGER: Never refuel this heater

while it is hot or operating. Fire or

outdoors.

Be sure that the heater is on level

ground when fueling, and never

or crankcase drainings.

There is a risk of indoor air pollution and

Carbon monoxide poisoning. Use heater only

in well ventilated areas or duct outside. See

page...for more info

Refer to Safety Information on pages 3 - 4

for information about Carbon Monoxide

Poisoning.

Always provide a fresh air opening in the

heated space of at least 2.8m2

each 100,00 Btu / Hr. of heater output.

Provide a larger opening if more heaters are

being used.

NEVER use fuel such as, benzene, alcohol,

white glass, camp stove fuel, paint thin-

ners, or other oil compounds in this heate

THESE ARE VOLATILE FUELS THAT CAN

CAUSE A FIRE OR EXPLOSION.

NEVER store Kerosene in the living space.

Kerosene should be stored in a well venti

lated area outside the living area.

NEVER store Kerosene in direct sunlight or

near a source of heat.

NEVER use Kerosene that has been stored

from one season to the next. Kerosene dete

riorates over time. OLD Kerosene WILL

BURN PROPERLY IN THIS HEATER.

Fuel Set - Fuel Conditioner

For optimal performance, it is strongly sug

gested that Fuel Set fuel conditioner be

used in addition to fuel. Diesel contaminants

such as diesel bug and water in the fuel

may make the heater perform poorly. Add

the recommended dose of Fuel Set to every

performs at it’s peak.

reasons. As you use it for a while,the smell

will no longer be present. This can take

approximately 1-2 hours.

OPERATION

1. Plug heater into 230V power outlet. Set

temperature to higher than current

temperature.

2. Power On - Before using ensure heater

has adequate ventilation - see Ventilation

section above.

3. Select temperature or timer control mode.

See info as follows for temperature

controls.

VENTILATION

10. www.remingtonpower.co.nz

CONTROLS

Set Time/Temp Control:

Set Temp. / Time indicates the

reserved time. By pushing '+/_'

button, time is changed by an hour. It

can be set in 24 hours in total. Set

Temp. or Set Time is indicated again

after 2 seconds. Remaining time is

indicated by flickering 10 times every

5 min. eg. Off Timer is indicated when

off timer is set for 5 hours. (5 - 4 - 3hr

... 55 - 50...5min).

Off Time Control: During the

operation if you push Off Timer

button, Off timer function is cancelled.

Select Off timer to see whether off

timer mode is operating or not. Off

timer will be lit if operating.

Time Control Light:

The timer control light is lit when

selected. Machine will work for 30

mins and then pause in timer mode.

Repetition time can be set in from

Current Temperature

Control:

Shows current temperature

Fuel Light:

If fuel light turns on, heater may stop

as it has run out of fuel. Turn off

heater and refuel once cool. See

fuel section in this booklet for more

info on refueling. In the case of fuel

leakage, heater will require servic-

ing. Clean fuel spillage and contact a

service agent.

Check Light:

If check light comes on see page 15

for more info

Air Flow Function Light:

(Applies to models with Air Flow

function)

Fan operates after power has been

on for 1 minute, it cannot be stopped

randomly.

Temp Control Light: The

temperature control light is lit when

selected. You can set the desired

temperature between "0~40°C" by

pressing "+/-" button. When setting

temperature ensure selected

temperature is higher than current

temperature (e.g. set temp at 20°C if

current temperature is 15°C). When

the room reaches the set tempera-

ture the heater will stop until

temperature drops again.

5-25 mins. (e.g. Repetition time set to

15 mins. Runs for 15 mins then 15

mins pause.) Time will be reduced by

1 min every time.

Tabla de contenidos

Otros manuales de Calentador de Remington

Remington

Remington HH-150T-DFV Manual

Remington

Remington SilentDrive REM-150T-SDR-B Manual de capacitación

Remington

Remington HH-70-SS-A Manual de capacitación

Remington

Remington HH-45-KFA Manual

Remington

Remington REM-40-GFA-B Manual de capacitación

Remington

Remington REM-03-240-GH Manual de capacitación

Remington

Remington Silent Drive REM-150T-SDR-O Manual de capacitación

Remington

Remington REM-16-TTC-B Manual de usuario

Remington

Remington REM-80TBOA-KFA-B Manual de capacitación

Remington

Remington REM-18-PCH-O Manual de capacitación

Remington

Remington REM22CEH Manual de usuario

Remington

Remington REM-45-KFA-O Manual de capacitación

Remington

Remington Silent Drive RPH75R Manual de capacitación

Remington

Remington REMJ70 Manual de usuario

Remington

Remington REM-18-PCH-B Manual de usuario

Remington

Remington HH-70-SS-A Manual de capacitación

Remington

Remington REM-221A-120 Manual de capacitación

Remington

Remington HH-400T-KFA Manual de capacitación

Remington

Remington REM-70-SS-O Manual de capacitación

Remington

Remington REM-03-240-GH Manual

Remington

Remington HH-600T-KFA Manual de capacitación

Remington

Remington REM-16-TTC-O Manual de capacitación

Remington

Remington HH- 45-KFA Manual de capacitación

Remington

Remington REM-60VBOA-GFA-B Manual de capacitación

Manuales populares de Calentador de otras marcas

oventrop

oventrop Regucor Series Manual de usuario

Blaze King

Blaze King CLARITY CL2118.IPI.1 Manual de usuario

ELMEKO

ELMEKO ML 150 Manual de usuario

BN Thermic

BN Thermic 830T Manual de usuario

KING

KING K Series Guía

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Guía de inicio rápido

Well Straler

Well Straler RC-16B Manual de usuario

EUROM

EUROM 333299 Manual de usuario

Heylo

Heylo K 170 Manual de usuario

Eterna

Eterna TR70W Manual de usuario

Clarke

Clarke GRH15 Manual de instrucciones

IRSAP

IRSAP The Radiator Company Ovali Manual de usuario

Empire Heating Systems

Empire Heating Systems WCC65 Manual de usuario

Wetekom

Wetekom 92 86 43 Manual de usuario

Desa

Desa SPC170-F Manual de usuario

Watlow

Watlow Watrod Electric Tubular Heaters Manual de usuario

Haverland

Haverland ECO-DRY GPS Series Manual de lista de piezas

Stelpro

Stelpro ASILVC2060 Series Manual de usuario