RealFlame C1460LP Manual de usuario

C1460LP Berthoud Fire Pit NG Conversion Kit

Improper installation, adjustment,

alteration, service or maintenance

can cause property damage

personal injury, or loss of life.

Read the installation, operation

and maintenance instructions

thoroughly before installing or

servicing this equipment.

IMPORTANT WARNING

SAVE THESE INSTRUCTIONS

!DANGER

If you smell gas:

gas to the appliance.

2. Extinguish any open ﬂame.

3. If odor continues, keep away from the appliance and

immediately call your gas supplier or ﬁre department.

USC

For Technical Support Please Contact Real Flame® At: 1-800-654-1704

PARTS LIST 00023105G

NATURAL GAS CONVERSION KIT

NOTE

This conversion kit is for changing a Liqueﬁed Petroleum (LP) ﬁre table into a Natural Gas

ﬁre table.

WARNING

Natural Gas Hose and Quick Disconnect

NG Oriﬁce Spud 3.9mm

Primary Air Mixer Sleeve

Conversion Plaque

Cable Kit

• If the information in these instructions is not followed exactly, a ﬁre, explosion or

production of carbon monoxide may result causing property damage, personal injury

or loss of life.

• The qualiﬁed service agency is responsible for the proper installation of this kit. The

installation is not proper and complete until the operations of the converted appliance

is checked as speciﬁed in the manufacturer’s instructions supplied with this kit.

• This conversion kit shall be installed by a qualiﬁed service agency in accordance with

Real Flame’s instructions and all applicable codes and requirements of the authority

having jurisdiction.

#3.9mm

C1460LP

50,000 BTU/Hr. (14.65 kW)

NATURAL GAS CONVERSION

2.) Disconnect LP hose from valve.

1.) Flip the ﬁre pit upside down. Place on a soft surface to avoid damaging

the ﬁnish.

NATURAL GAS CONVERSION

3.) Disconnect bellows (Corrugated Stainless Steel Tube/CSST) from

burner base.

Bellows

NATURAL GAS CONVERSION

4.) Remove the existing LP oriﬁce spud.

LP Oriﬁce Spud

NATURAL GAS CONVERSION

5.) Locate the new NG oriﬁce spud, verify it is the correct number.

The sign 3.9 mm should be on the end of the oriﬁce spud.

6.) Slip sleeve over primary air opening. See ﬁg. 1.

Next, screw the new NG oriﬁce spud into the burner base. See ﬁg. 2.

3.9

Sleeve

Primary Air

Opening

NG Oriﬁce Spud

1 2

NATURAL GAS CONVERSION

7.) Re-attach bellows (CSST) to new spud.

Bellows

8.) Attach NG hose to the input side of the valve.

9.) Attach quick disconnect to gas supply.

NATURAL GAS CONVERSION

House Natural Gas Piping

Shut-o Valve

Quick Disconnect Socket

NG Gas Hose

To Fire Table

10.) After installing the conversion kit, verify the location of the

thermocouple and igniter Pin using the illustration below.

Installing at Altitude

For installations at elevations above 2,000 ft., contact your local dealer or gas

supplier before installing because input rating should be reduced

approximately 4% for each 1,000 ft. above sea level. Refer to the National Fuel

Gas Code. Contact Real Flame for more information at 1-800-654-1704.

11.) Note to installation technicians: Verify the manifold pressure by using a

3/8” ﬂared T-junction at the location marked by the arrow below. Then, using

a digital manometer, verify that the pressure before the oriﬁce is 7” W.C. Also

verify that the oriﬁce spud has the 3.9 mm stamp. This will allow you to verify

that the input rating of the appliance is correct.

NATURAL GAS CONVERSION

NOTE: Igniter housing removed for example only.

To Manometer

5mm

Thermocouple

Igniter

13.) Cut the existing French plaque from the control panel using wire cutters. Re-attach

French plaque and NG conversion plaque included with this kit to the ﬁre pit using

the included cable kit.

Cut Cable Re-attach both plaques

NOTE: The normal manifold pressure for this converted appliance is 7” water column.

NOTE: The maximum inlet gas pressure for this unit is 10.5 in W.C. (2.61 kPa).

The minimum inlet gas pressure for this unit is 3.5 in W.C. (0.87 kPa).

NATURAL GAS CONVERSION

WARNING

Check for leaks at these locations

12. CHECKING FOR LEAKS

Make a leak check solution by mixing 1 part dishwashing soap

with 3 parts water in a spray bottle.

Make sure the re pit control knob is “OFF.” Then, turn the natural

gas on at its source.

Spray leak solution on the valve connections, paying particular

attention to the areas indicated by the arrows.

If any bubbles appear turn the natural gas o at its source,

reconnect and re-test. If you continue to see bubbles after several

attempts, disconnect the natural gas source and contact Real

Flame® at 1-800-654-1704 for assistance.

If no bubbles appear after one minute, turn the gas

source “OFF”, wipe away solution and proceed to next

step.

Before using this outdoor ﬁre pit, make sure you have read, understand and are following all

information provided in the Important Safety Information section of this manual. Failure to

follow those instructions can cause property damage, serious injury or death.

French

Conv.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Idiomas:

Otros manuales de Accesorios para chimeneas de RealFlame

RealFlame

RealFlame 561 Manual de usuario

RealFlame

RealFlame 310 Manual del producto

RealFlame

RealFlame C11801LP Manual de usuario

RealFlame

RealFlame T0026 Manual de usuario

RealFlame

RealFlame Morrison 907 Manual de usuario

RealFlame

RealFlame R0001-BK Manual de usuario

RealFlame

RealFlame Power Flue Instrucciones de instalación

RealFlame

RealFlame 4830E Manual de usuario

RealFlame

RealFlame 13055E Manual de usuario

RealFlame

RealFlame C11800LP Manual de usuario

RealFlame

RealFlame T0025 Manual de usuario

RealFlame

RealFlame 8140E Manual de usuario

RealFlame

RealFlame C1600 Manual de usuario

RealFlame

RealFlame Chateau 5950 Manual de usuario

RealFlame

RealFlame G0004-02 Manual de usuario

RealFlame

RealFlame Ledgestone T0027 Manual de usuario

RealFlame

RealFlame Sedona 11815 Manual de usuario

RealFlame

RealFlame C9640LP Manual de usuario

RealFlame

RealFlame EVO EVO750TRIM-AU Manual de usuario

RealFlame

RealFlame Crawford 8020E Manual de usuario

RealFlame

RealFlame Treviso 838 Manual de usuario

RealFlame

RealFlame 13056E Manual de usuario

RealFlame

RealFlame C1510LP Manual de usuario

RealFlame

RealFlame 400 Manual de usuario

Manuales populares de Accesorios para chimeneas de otras marcas

Valor

Valor L2 1700K Manual de usuario

Exodraft

Exodraft Xzense Manual de usuario

Whalen

Whalen Ruso MNFP62BF23-6 Manual de usuario

Lopi

Lopi Hearthview 864 Manual de usuario

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Manual de usuario

EdilKamin

EdilKamin SERBATOIO 250 Guía de inicio rápido

Bronpi

Bronpi KIT-1 Manual de usuario

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Manual de usuario

Travis Industries

Travis Industries 33 DVI Manual de usuario

Superior

Superior ASD3628-TI Manual de usuario

pleasant hearth

pleasant hearth OFP28WG Manual de usuario

IHP

IHP Astria Series Manual de usuario

Firegear

Firegear FG-H-2110SS Manual de usuario

Nibe

Nibe Contura C i31 Manual de usuario

kozy heat

kozy heat KZK-052 Manual de usuario

SimpliFire

SimpliFire SF-WM36 Manual de usuario

Bluegrass Living

Bluegrass Living BC18NR Guía de inicio rápido

pleasant hearth

pleasant hearth IRIS SCROLL Manual de usuario