Polar Electro GL180-A Manual de usuario

Model:

GL180-A / GL181-A

Cabinet Refrigerator/

Freezer

Instruction manual

GL180-A_GL181-A_A5_v1_20220412.indb 1GL180-A_GL181-A_A5_v1_20220412.indb 1 2022/4/12 10:242022/4/12 10:24

EN Telephone Helpline: 1300225960

Safety Instructions

• Position on a flat, stable surface.

• A service agent/qualified technician should carry out

installation and any repairs if required. Do not remove any

components or service panels on this product.

• Consult Local and National Standards to comply with the

following:

- Health and Safety at Work Legislation

- Fire Precautions

- IEE Wiring Regulations

- Building Regulations

• DO NOT use jet/pressure washers to clean the appliance.

• DO NOT use the appliance outside.

• DO NOT use this appliance to store medical supplies.

• DO NOT stand or support yourself on the base, drawers or

doors.

• DO NOT allow oil or fat to come into contact with the plastic

components or door seal. Clean immediately if contact occurs.

• Bottles that contain a high percentage of alcohol must be

sealed and placed vertically in the refrigerator.

• Always carry, store and handle the appliance in a vertical

position and move by holding the base of the appliance.

• Always switch off and disconnect the power supply to the unit

before cleaning.

• Keep all packaging away from children. Dispose of the

packaging in accordance with the regulations of local

authorities.

• If the power cord is damaged, it must be replaced by a POLAR

agent or a recommended qualified technician in order to avoid

a hazard.

GL180-A_GL181-A_A5_v1_20220412.indb 2GL180-A_GL181-A_A5_v1_20220412.indb 2 2022/4/12 10:242022/4/12 10:24

AUEN

Telephone Helpline: 1300225960

• This appliance is not intended for use by persons (including

children) with reduced physical, sensory or mental capabilities,

or lack of experience and knowledge, unless they have

been given supervision or instruction concerning use of the

appliance by a person responsible for their safety.

• POLAR recommend that this appliance should be periodically

tested (at least annually) by a Competent Person. Testing

should include, but not be limited to: Visual Inspection,

Polarity Test, Earth Continuity, Insulation Continuity and

Functional Testing.

Caution Risk of Fire

• Do not store explosive substances such as aerosol cans with a

flammable propellant in this appliance.

Warning: Keep all ventilation openings clear of

obstruction. Unit should not be boxed in without

adequate ventilation.

• Warning: Do not use mechanical devices or other means

to accelerate the defrosting process, other than those

recommended by the manufacturer.

• Warning: Do not damage the refrigerant circuit.

• Warning: Do not use electrical appliances inside the food

storage compartments of the appliance, unless they are the

type recommended by the manufacturer.

Product Description

GL180-A - Single Door Bakery Fridge

GL181-A - Single Door Bakery Freezer

Introduction

Please take a few moments to carefully read through this manual. Correct maintenance and operation of

this machine will provide the best possible performance from your POLAR product.

GL180-A_GL181-A_A5_v1_20220412.indb 3GL180-A_GL181-A_A5_v1_20220412.indb 3 2022/4/12 10:242022/4/12 10:24

EN Telephone Helpline: 1300225960

Pack Contents

The following is included:

• POLAR Refrigerator or Freezer

• Keys

• Shelf guides

• Instruction manual

POLAR prides itself on quality and service, ensuring

that at the time of unpacking the contents are

supplied fully functional and free of damage.

Should you find any damage as a result of transit,

please contact your POLAR dealer immediately.

Installation

Note: Not for use in vans or

trailers, food trucks or similar

vehicles.

Note: If the unit has not been

stored or moved in an upright

position, let it stand upright for

approximately 12 hours before

operation. If in doubt allow to

stand.

1. Remove the appliance from the packaging.

Make sure that all protective plastic film and

coatings are thoroughly removed from all

surfaces.

2. To optimize performance and longevity, ensure

a minimum clearance of 2.5cm is maintained

between the unit and walls and other objects,

with a minimum 5cm clearance on the top.

NEVER LOCATE NEXT TO A HEAT SOURCE.

Note: Before using the appliance

for the first time, clean the

shelves and interior with soapy

water.

3. Set the brakes on the castors to keep the

appliance in position.

Reversing the door

Depending on the location of the appliance, it may

be necessary to change the direction the door

opens by changing the side of the door handle.

• Polar recommends that the reversal of

the door is carried out by a competent

person(s).

• Should a product issue occur as a result

of reversing the door, any repair action

would be chargeable.

• If you require an engineer to carry out

the task please call a Polar agent.

• If you proceed yourself we recommend

you follow the steps outlined below

(Pages 9-10) once the unit has been

unplugged.

Removing the Compressor Safety

Band

• The compressor is located on the top of the

appliance, and sits on rubber washers. Under

normal operating conditions the compressor is

allowed to vibrate.

• To avoid damage through excessive motion

during transit, a stainless steel safety band is

placed over the compressor and screwed into

the top of the appliance.

• This safety band and the two screws fixing it

to the appliance must be removed before the

appliance is turned on.

Compressor

Safety Band

Compressor

Screws

GL180-A_GL181-A_A5_v1_20220412.indb 4GL180-A_GL181-A_A5_v1_20220412.indb 4 2022/4/12 10:242022/4/12 10:24

AUEN

Telephone Helpline: 1300225960

Lock/Unlock the Doors

A lock is fitted to the doors to ensure foodstuffs

are kept secure within your POLAR appliance.

Use the keys provided to lock/unlock the doors.

Fitting the Waste Water Tray

The waste water tray comes ready to fit to the

underside of the appliance.

Slide the tray into the runners situated under the

appliance.

Fitting the Shelves & Floor Guards

1. Place one set of shelf guides on either side of

the cabinet at the desired height.

2. Slide the shelf into place.

3. Repeat for the remaining shelves.

4. Place the floor guards on the floor of the

cabinet, ensuring the flat side is clear of the

floor.

Note: This is vital for ensuring correct

drainage of condensation.

Operation

Storing Food

To get the best results from your POLAR appliance,

follow these instructions:

• Only store foodstuffs in the appliance when it

has reached the correct operating temperature.

• Do not place uncovered hot food or liquid

inside the appliance.

• Wrap or cover food where possible.

• Do not obstruct the fans inside the appliance.

• Avoid opening the doors for prolonged periods

of time.

Turn On

1. Ensure the power switch is set to [O] and turn

on at the socket.

2. Switch on the Power [I]. The current

temperature within the appliance is displayed.

Control Panel

To unlock / Lock the keyboard press and

together for 3 seconds. Display will flash PON

(unlocked) / POF (locked).

Set the Operating Temperature

1. Hold the SET button for 3 seconds. The display

will flash.

2. Press the or buttons to display the

required temperature.

3. Press the SET button to store the temperature.

Manual Defrost

Press and hold the defrost button "aux" for 2

seconds to begin a manual defrost. The defrost

light illuminates.

GL180-A_GL181-A_A5_v1_20220412.indb 5GL180-A_GL181-A_A5_v1_20220412.indb 5 2022/4/12 10:242022/4/12 10:24

EN Telephone Helpline: 1300225960

Cleaning, Care & Maintenance

Defrost appliance at least every 3 months, more often if required.

Switch off and disconnect from the power supply before cleaning.

• Clean the interior of the appliance as often as possible.

• Do not use abrasive cleaning agents. These can leave harmful residues.

• Clean the door seal with warm soapy water.

• Always wipe dry after cleaning.

• Do not allow water used in cleaning to run through the drain hole into the evaporation pan.

• Take care when cleaning the rear of the appliance. Sharp edges can cut.

Condensation will form in refrigeration with frequent opening of the doors and on hot humid

days, please ensure condensation is allowed to drain properly or is wiped dry.

Stainless Steel Care

To maintain the stainless steel exterior of your Polar item, please consider the following information:

Never:

• Use abrasive Scourers or scrubbing pads etc

• Use Chlorinated or acidic detergents

• Allow anything e.g. food, dirt, cleaning chemicals to remain on the surface for longer than necessary,

clean them off right away.

• Allow the surface to remain wet.

Do:

• Clean often.

• Use soft Cloths or plastic Scourers.

• Rub with the grain of the metal, rather than across it.

• Use detergents and polish designed for cleaning Stainless Steel.

• Ensure that the cleaning products are washed off fully and that the steel is left dry.

Cleaning the Condenser

• The condenser is part of the refrigeration

system. The condenser requires monthly

cleaning.

• Always disconnect power supply before carrying

out Routine Maintenance.

• Failure to clean the condenser will reduce the

performance and life of your Polar unit and may

invalidate your warranty.

• The condenser is located above the refrigeration

cabinet. These models have a removable filter

which can be cleaned with a vacuum cleaner.

GL180-A_GL181-A_A5_v1_20220412.indb 6GL180-A_GL181-A_A5_v1_20220412.indb 6 2022/4/12 10:242022/4/12 10:24

AUEN

Telephone Helpline: 1300225960

Troubleshooting

A qualified technician must carry out repairs if required.

Fault Probable Cause Solution

The appliance is not

working

The unit is not switched on Check the unit is plugged in correctly and

switched on

Plug or lead is damaged Replace plug or lead

Mains power supply fault Check mains power supply

The appliance turns on,

but the temperature is

too high/low

Too much ice on the evaporator Defrost the appliance

Condenser blocked with dust Clean the Condenser

Doors are not shut properly Check doors are shut and seals are not

damaged

Appliance is located near a

heat source or air flow to the

condenser is being interrupted

Move the refrigerator to a more suitable

location

Ambient temperature is too high Increase ventilation or move appliance to a

cooler position

Unsuitable foodstuffs are being

stored in the appliance

Remove any excessive hot foodstuffs or

blockages to the fan

Appliance is overloaded Reduce the amount of food stored in the

appliance

The appliance is

leaking water

The appliance is not properly

levelled

Adjust the screw feet to level the appliance

(if applicable)

The discharge outlet is blocked Clear the discharge outlet

Movement of water to the drain is

obstructed

Clear the floor of the appliance (if

applicable)

The water container is damaged Call POLAR agent or qualified Technician

The drip tray is overflowing Empty the drip tray (if applicable)

The appliance is

unusually loud

The safety band has not been

removed

Remove the safety band

Loose nut/screw Check and tighten all nuts and screws

The appliance has not been

installed in a level or stable

position

Check installation position and change if

necessary

Technical Specifications

Model Voltage Power Current Temperature

Range

Capacity

(litres) Refrigerant Dimensions

H x W x D mm

Weight

(kg)

GL180-A 220-240V~

50Hz

330W 2.0A 2°C ~ 8°C 850 R290 95g 2010 x 740 x 990 161

GL181-A 700W 4.9A -22°C ~ -18°C 850 R290 90g 2010 x 740 x 990 170

GL180-A_GL181-A_A5_v1_20220412.indb 7GL180-A_GL181-A_A5_v1_20220412.indb 7 2022/4/12 10:242022/4/12 10:24

EN Telephone Helpline: 1300225960

Electrical Wiring

The plug is to be connected to a suitable mains socket.

This appliance is wired as follows:

• Live wire (coloured brown) to terminal marked L

• Neutral wire (coloured blue) to terminal marked N

• Earth wire (coloured green/yellow) to terminal marked E

The appliances must be earthed.

If in doubt consult a qualified electrician.

Electrical isolation points must be kept clear of any obstructions. In the event of any emergency

disconnection being required they must be readily accessible.

Compliance

The product must not be disposed of as household waste. To help prevent possible harm to human

health and/or the environment, the product must be disposed of in an approved and environmentally safe

recycling process. For further information on how to dispose of this product correctly, contact the product

supplier, or the local authority responsible for waste disposal in your area.

POLAR parts have undergone strict product testing in order to comply with regulatory

standards and specifications set by international, independent, and federal authorities.

POLAR products have been approved to carry the following symbol:

mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.

Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to

change specifications without notice.

GL180-A_GL181-A_A5_v1_20220412.indb 8GL180-A_GL181-A_A5_v1_20220412.indb 8 2022/4/12 10:242022/4/12 10:24

The door originally opens from the left side. To reverse the door:

1. Remove the 2 screws fixing the control panel, then open the panel.

2. Remove the right upper hinge and left upper hinge. (Tool: socket spanner)

3. Remove the spring hinge on the right top.

4. Remove the door from the right lower hinge . Now remove the auxiliary hinge.

GL180-A_GL181-A_A5_v1_20220412.indb 9GL180-A_GL181-A_A5_v1_20220412.indb 9 2022/4/12 10:242022/4/12 10:24

5. Reverse the door. Install the previously removed spring hinge on the left top and auxiliary hinge on

the left bottom.

6. Remove the castor support board, right front castor, and left front castor consecutively. Then install

back the right castor. (Tool: socket spanner)

7. For the hinge axis on the castor support board,

remove it from the right and install on the left .

8. Install the castor support board and left front

castor on the left bottom.

9. Install the previously removed left top hinge on the right top. (Tool: socket spanner)

10. Install back the font panel and fix with the screws. Now the door opens from the right side.

GL180-A_GL181-A_A5_v1_20220412.indb 10GL180-A_GL181-A_A5_v1_20220412.indb 10 2022/4/12 10:242022/4/12 10:24

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Refrigerador de Polar Electro

Polar Electro

Polar Electro DL893-A Manual de usuario

Polar Electro

Polar Electro CG841 Manual de usuario

Polar Electro

Polar Electro CD080-A Manual de usuario

Polar Electro

Polar Electro CD610 Manual de usuario

Polar Electro

Polar Electro CD080-A Manual de usuario

Polar Electro

Polar Electro GL178-A Manual de usuario

Polar Electro

Polar Electro G590/G591/G592/G593/G594/G595/U632/U633/U634/U635/CC663/CD616/GD879/GD880/ Manual de usuario

Polar Electro

Polar Electro DA546 Manual de usuario

Polar Electro

Polar Electro U636-A Manual de usuario

Polar Electro

Polar Electro GE819 Manual de usuario

Polar Electro

Polar Electro Deli CG841-A Manual de usuario

Polar Electro

Polar Electro DM075 Manual de usuario

Polar Electro

Polar Electro G Series Manual de usuario

Polar Electro

Polar Electro CE322-A Manual de usuario

Polar Electro

Polar Electro CC066 Manual de usuario

Polar Electro

Polar Electro CP728-A Manual de usuario

Polar Electro

Polar Electro G596-A Manual de usuario

Polar Electro

Polar Electro CR711 Manual de usuario

Polar Electro

Polar Electro CD610 Manual de usuario

Polar Electro

Polar Electro CD610 Manual de usuario

Polar Electro

Polar Electro Tapas Manual de usuario

Polar Electro

Polar Electro CN267 Manual de usuario

Polar Electro

Polar Electro G609 Manual de usuario

Polar Electro

Polar Electro GD881 Manual de usuario

Manuales populares de Refrigerador de otras marcas

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Manual de usuario

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Manual de usuario

Sharp

Sharp SJ-BA31IEXW2-EU Manual de usuario

CORBERO

CORBERO CC2300MCW Manual de usuario

KitchenAid

KitchenAid 2205264 Manual de usuario

Stengel

Stengel KU 1101 A++ Manual de usuario

NEFF

NEFF KI181 Series Manual de usuario

Hoshizaki

Hoshizaki Reach-In Manual de usuario

Amana

Amana ASD2524VES00 Manual de usuario

BOMANN

BOMANN KGC 213 Manual de usuario

Danby

Danby DAR044A1SLDD Instrucciones de montaje

Samsung

Samsung RF323TE Manual de usuario

Beko

Beko CSA31022 Manual de usuario

IKEA

IKEA FROSTIG C 185 E Manual de usuario

Electrolux

Electrolux ER 6821 D Manual de usuario

True

True TS-28 Manual de usuario

Frigidaire

Frigidaire FSC23R5DW9 Manual de usuario

Beko

Beko LSP4579W Manual de usuario