Philips HTS3541/05 Manual de usuario

TABLE OF CONTENTS

Page

Service Manual

. Mechanical and Dismantling Instructions…………........................3-1

. Software Upgrades ........................................................................4-1

. Trouble Shooting Chart……………………………………………….5-1

. Wiring Diagram………………………………………..………..….….6-1

. Electrical Diagrams and Print-layouts..….…………………....….…7-1

. Set Mechanical Exploded view & Part list.…………………..….….8-1

transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise

without the prior permission of Philips.

CLASS 1

LASER PRODUCT

PHILIPS

HTS3541/05/12/51/55/78/79/93/98/X78

. DFU Instruction..............................................................................2-1

. Revision List..................................................................................9-1

Home Theater DVD Player

. Technical Specifications…………....………………………..............1-

. Safety Instruction, Warning & Notes….……………………....….....1-

. Location of PCB BdsÿVersion Variation and Repair Scenario Matrix..........1-2

Published by RY&LLL - 1130 BU AVM Printed in The Netherlands Subject to modification

3139 785 35832

Version 1.2

Service

This service manual is for HTS3541 first Generation model,

which is different from the previous generation models.

For First Generation model the serial number

begin with KX1xxxxxxxxxxx.

1-2

PCB BOARD LOCATION:

Version Variation

HTS3541

Type/Versions

Features /05 /12 /51 /55 /78 /79 /93 /98 X/78

Output Power- 300W X X X X X X X X X

Voltage(220~240V~) X X X X X

Voltage(110~240V~) X X X X

MP3 LINK X X X X X X X X

Repair Scenario Matrix

HTS3541

Type/Versions

Board in used /05 /12 /51 /55 /78 /79 /93 /98 X/78

Main Board C C C C C C C C C

Front Control Board B B C C C C C C C

Amplifier Board B B C C C C C C C

Power Board B B C C C C C C C

*Bd:Board Level Replacement

*C:Component Level Repair

Ampliﬁer

•Total output power: 300 W RMS (30%

THD)

•Frequency response: 20 Hz-20 kHz / ±3 dB

•Signal-to-noise ratio: > 65 dB (CCIR)/

(A-weighted)

•Input sensitivity:

•AUX: 2 V

•Music iLink: 1 V

Video

•Signal system: PAL/NTSC

•HDMI output: 480i/576i, 480p/576p, 720p,

1080i, 1080p, 1080p24

Audio

•S/PDIF Digital audio input:

•Coaxial: IEC 60958-3

•Optical: TOSLINK

•Sampling frequency:

•MP3: 32 kHz, 44.1 kHz, 48 kHz

•WMA: 44.1 kHz, 48 kHz

•Constant bit rate:

•MP3: 32 kbps - 320 kbps

•WMA: 48 kbps - 192 kbps

Radio

•Tuning range:

•Europe/Russia/China: FM 87.5-

108 MHz (50 kHz)

•Asia Paciﬁc/Latin America: FM 87.5-

108 MHz (50/100 kHz)

•Signal-to-noise ratio: FM 50 dB

•Frequency response: FM 200 Hz-12.5 kHz

/ ±6 dB

USB

•Compatibility: Hi-Speed USB (2.0)

•Class support: USB Mass Storage Class

(MSC)

•File system: FAT16, FAT32, NTFS

•Maximum memory support: < 160 GB

Note

•Speciﬁcations and design are subject to change

without notice.

Region codes

The type plate on the back or bottom of the

home theatre shows which regions it supports.

Media formats

•AVCHD, BD, BD-R/ BD-RE, BD-Video,

DVD-Video, DVD+R/+RW, DVD-R/-RW,

DVD+R/-R DL, CD-R/CD-RW, Audio CD,

Video CD/SVCD, Picture ﬁles, MP3 media,

WMA media, DivX Plus HD media, USB

storage device

File formats

•Audio: .aac, .mka, .mp3, .wma, .wav

•Video: .avi, .divx, .mp4, .mkv, .asf, .mpg, .mpeg

•Picture: .jpg, .jpeg, .gif, .png

Country DVD BD

Europe,

United Kingdom

Korea

Latin America

Australia,

New Zealand

Russia, India

China

Asia Pacific, Taiwan,

Product Specifications:

HTS3541/05/12/51/55/78/79/X78:

1-3

Main unit

•Power supply:

•Europe/China/Russia/India: 220-

240 V~, 50 Hz

•Latin America/Asia Paciﬁc: 110-240 V~,

50-60 Hz

•Power consumption: 60 W

•Standby power consumption: 0.9 W

•Dimensions (WxHxD): 360 x 58 x 325 mm

•Weight: 2.4 kg

Subwoofer

•Output power: 50 W RMS (30% THD)

•Impedance: 4 ohm

•Speaker drivers: 133 mm (5.25”) woofer

•Dimensions (W x H x D): 160 x 265 x 265 mm

•Weight: 2.5 kg

•Cable length: 3 m

Speakers

Centre speaker:

•Output power: 50 W RMS (30% THD)

•Speaker impedance: 4 ohm

•Speaker drivers: 1 x 63.5 mm (2.5”) woofer

•Dimensions (W x H x D): 159 x 84.5 x 80 mm

•Weight: 0.35 kg

•Cable length: 2 m

Front/Rear speaker:

•Output power: 4 x 50 W RMS (30% THD)

•Speaker impedance: 4 ohm

•Speaker drivers: 1 x 63.5 mm (2.5”) woofer

•Dimensions (WxHxD): 84.5 x159 x 80 mm

•Weight (front speakers): 0.35 kg/each

•Weight (rear speakers): 0.35 kg/each

•Cable length (front speakers): 3 m

•Cable length (rear speakers): 7 m

Remote control batteries

•2 x AAA-R03-1.5 V

Laser

•Laser Type (Diode): InGaN/AlGaN (BD),

AlGaInP (DVD/CD)

•Wave length: 405 +7 nm/-7 nm (BD), 655

+10 nm/-10 nm (DVD), 790 +10 nm/-20

nm (CD)

•Output power (Max. ratings): 20 mW (BD),

6 mW (DVD), 7 mW (CD)

1-4

Note

•Speciﬁcations and design are subject to change

without notice.

Region codes

The type plate on the back or bottom of the

home theater shows which regions it supports.

Media formats

•AVCHD, BD, BD-R/ BD-RE, BD-Video,

DVD-Video, DVD+R/+RW, DVD-R/-RW,

DVD+R/-R DL, CD-R/CD-RW, Audio CD,

Video CD/SVCD, Picture ﬁles, MP3 media,

WMA media, DivX Plus HD media, USB

storage device

Country DVD BD

Europe,

United Kingdom

Korea

Latin America

Australia,

New Zealand

Russia, India

China

Asia Pacific, Taiwan,

File formats

•Audio: .aac, .mka, .mp3, .wma, .wav

•Video:

•.avi, .divx, .mp4, .mkv, .asf, .wmv, .mpg,

.mpeg

•.rmvb, .rm

•Picture: .jpg, .jpeg, .gif, .png

Ampliﬁer

•Total output power: 300W RMS (30%

THD)

•Frequency response: 20 Hz-20 kHz / ±3 dB

•Signal-to-noise ratio: > 65 dB (CCIR) /

(A-weighted)

•Input sensitivity:

•AUX: 2 V

•Music iLink: 1 V

Video

•Signal system: PAL / NTSC

•HDMI output: 480i/576i, 480p/576p, 720p,

1080i, 1080p, 1080p24

Audio

•S/PDIF Digital audio input:

•Coaxial: IEC 60958-3

•Optical: TOSLINK

•Sampling frequency:

•MP3: 32 kHz, 44.1 kHz, 48 kHz

•WMA: 44.1 kHz, 48 kHz

•Constant bit rate:

•MP3: 32 kbps - 320 kbps

•WMA: 48 kbps - 192 kbps

Radio

•Tuning range:

•Europe/Russia/China: FM 87.5-108

MHz (50 kHz)

•Asia Paciﬁc/Latin America: FM 87.5-108

MHz (50/100 kHz)

•Signal-to-noise ratio: FM 50 dB

•Frequency response: FM 200 Hz-12.5 kHz

/ ±6 dB

Product Specifications:

1-5

HTS3541/93/98:

USB

•Compatibility: Hi-Speed USB (2.0)

•Class support: USB Mass Storage Class

(MSC)

•File system: FAT16, FAT32, NTFS

•Maximum memory support: < 160 GB

Main unit

•Power supply:

•Europe/China/Russia/India: 220-240

V~, 50 Hz

•Latin America/Asia Paciﬁc: 110-240 V~,

50-60 Hz

•Power consumption: 60 W

•Standby power consumption: 0.9 W

•Dimensions (WxHxD): 360 x 58 x 325 mm

•Weight: 2.40 kg

Subwoofer

•Output power: 50 W RMS (30% THD)

•Impedance: 4 ohm

•Speaker drivers: 133 mm (5.25”) woofer

•Dimensions (WxHxD): 160 x 265 x 265

•Weight: 2.50 kg

•Cable length: 3 m

Speakers

Center speaker:

•Output power: 50 W RMS (30% THD)

•Speaker impedance: 4 ohm

•Speaker drivers: 1 x 63.5 mm (2.5”) woofer

•Dimensions (WxHxD): 159 x 84.5 x 80 mm

•Weight: 0.35 kg

•Cable length: 2 m

Front/Rear speaker:

•Output power: 4 x 50 W RMS (30% THD)

•Speaker impedance: 4 ohm

•Speaker drivers: 1 x 63.5 mm (2.5”) woofer

•Dimensions (WxHxD): 84.5 x159 x 80 mm

•Weight (front speakers): 0.35 kg/each

•Weight (rear speakers): 0.35 kg/each

•Cable length (front speakers): 3 m

•Cable length (rear speakers): 7 m

Remote control batteries

•2 x AAA-R03-1.5 V

Laser

•Laser Type (Diode): InGaN/AIGaN (BD),

AIGaInP (DVD/CD)

•Wave length: 405 +7 nm/-7 nm (BD), 655

+10 nm/-10 nm (DVD), 790 +10 nm/-20

nm (CD)

•Output power (Max. ratings): 20 mW (BD),

6 mW (DVD), 7 mW (CD)

1-6

Safety instruction

1. General safety

Safety regulations require that during a repair:

. Connect the unit to the mains via an isolation transformer.

. Replace safety components indicated by the symbol ,

only by components identical to the original ones. Any

other component substitution (other than original type)

may increase risk of fire or electrical shock hazard.

Safety regulations require that after a repair, you must

return the unit in its original condition. Pay, in particular,

attention to the following points:

. Route the wires/cables correctly, and fix them with the

mounted cable clamps.

. Check the insulation of the mains lead for external

damage.

. Check the electrical DC resistance between the mains

plug and the secondary side:

1) Unplug the mains cord, and connect a wire between

the two pins of the mains plug.

2) Set the mains switch the “on” position (keep the

mains cord unplug).

3) Measure the resistance value between the mains

plug and the front panel, controls, and chassis

bottom.

4) Repair or correct unit when the resistance

measurement is less than 1M

5) Verify this, before you return the unit to the

customer/user (ref. UL-standard no. 1492).

6) Switch the unit “off”, and remove the wire between

the two pins of the mains plug.

2.Laser safety

This unit employs a laser. Only qualified service personnel

may remove the cover, or attempt to service this device

(due to possible eye injury).

Laser device unit

Type :SemiconductorlaserGaAlAs

Wavelength : 650nm (DVD)

: 780nm (VCD/CD)

Output power : 7mW (DVD)

:10mW(DVD/CD)

Beam divergence: 60 degree

Note: Use of controls or adjustments or performance of

procedure other than those specified herein, may result in

hazardous radiation exposure. Avoid direct exposure to

beam.

Safet

instruction, Warnin

& Notes

1-7

Warning

1.General

. All ICs and many other semiconductors are susceptible to

electrostatic discharges (ESD). Careless handing during

repair can reduce life drastically. Make sure that, during

repair, you are at the same potential as the mass of the

set by a wristband with resistance. Keep components and

tools at this same potential. Available ESD protection

equipment:

1) Complete kit ESD3 (small tablemat, wristband,

connection box, extension cable and earth cable)

4822 310 10671.

2) Wristband tester 4822 344 13999.

. Be careful during measurements in the live voltage

section. The primary side of the power supply , including

the heat sink, carries live mains voltage when you

connect the player to the mains (even when the player is

“off”!). It is possible to touch copper tracks and/or

components in this unshielded primary area, when you

service the player. Service personnel must take

precautions to prevent touching this area or components

in this area. A “lighting stroke” and a stripe-marked

printing on the printed wiring board, indicate the primary

side of the power supply.

. Never replace modules, or components, while the unit is

“on”.

2. Laser

. The use of optical instruments with this product, will

increase eye hazard.

. Only qualified service personnel may remove the cover

or attempt to service this device, due to possible eye

injury.

. Repair handing should take place as much as possible

with a disc loaded inside the player.

. Text below is placed inside the unit, on the laser cover

shield:

Notes: Manufactured under licence from Dolby

Laboratories. The double-D symbol is trademarks of Dolby

CAUTION: VISIBLE AND INVISIBLE LASER

RADIATION WHEN OPEN, AVOID EXPOSURE

TO BEAM.

1-8

Service Hints

CAUTION:

CHARGED CAPACITORS ON THE SERVO BOARD MAY DAMAGE THE DRIVE

ELECTRONICS WHEN CONNECTING A NEW DRIVE. THAT`S WHY, BESIDES THE SAFETY

MEASURES LIKE

· SWITCH OFF POWER SUPPLY

· ESD PROTECTION

ADDITIONAL ACTIONS MUST BE TAKEN BY THE PERAIR TECHNICAN

1. How to replace a defective loader?

Step1: Dismantling the loader to access the ESD protection point;

Step2: Remove the solder joint on the ESD protection point;

（NOTICE: REMOVE THE SOLDER JOINT AS THE WHITE ARROW DIRECTION

IN ABOVE PICTURE）

Step3: Connect the 4PIN cable with the base. (Figure 2/3)

Step4: Take a label (can be reused) to cover the pane to prevent dust and touching the

protection point (Figure 4)

1.Loader 2.4pinbase 3.Insert4pincable

1-9

Note: The ESD protection point needs to be soldered if:

1). it is still under good condition;

2). It is defective but need to sent back for failure analysis to support back charging

evidence.

This is also applicable to all partnership workshops.

2. Reference about the loader:

DESCRIPTION POSITION

BLU-RAY LOADER L9829+414H08 OPU

LOADER LABEL LABEL

4PIN CONNECTOR L=260MM 4P

1). The ASSY-loader includes three components, as below picture:

2). top and bottom pictures :

TOP Bottom

The ASSY-loader

The cable

Theloader The label

1-10

Otros manuales para HTS3541/05

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Sistema de cine en casa de Philips

Philips

Philips 5 DVD-CD CHANGER HOME THEATER CLASS D AMPLIFIER... Manual de funcionamiento

Philips

Philips MX6050D Manual de instrucciones

Philips

Philips HTS3164/12 Manual de usuario

Philips

Philips MCD183/55 Manual de usuario

Philips

Philips HTS3220/12/98 Manual de usuario

Philips

Philips HTD3510 Manual de usuario

Philips

Philips HTB5260G/12 Manual de usuario

Philips

Philips HTS3155/78 Manual de usuario

Philips

Philips HTS3152/98 Manual de usuario

Philips

Philips HTS3400 Manual de usuario

Philips

Philips HTS3115/12 Manual de usuario

Philips

Philips FTS6000/12 Manual de usuario

Philips

Philips HTB9225D/12 Manual de usuario

Philips

Philips MCD139B/58 Manual de usuario

Philips

Philips HTS9800W/37B Manual de usuario

Philips

Philips HTS6510 Manual de usuario

Philips

Philips HTS6100/93 Manual de usuario

Philips

Philips HTS3500K/51 Manual de usuario

Philips

Philips HTS3276 Manual de usuario

Philips

Philips HTS3011 Manual de usuario

Philips

Philips HTB3560 Manual de usuario

Philips

Philips HTS3440 Manual de usuario

Philips

Philips HTR5000/01 Manual de funcionamiento

Philips

Philips PDCC-ZYL-0906 Manual de usuario

Manuales populares de Sistema de cine en casa de otras marcas

Samsung

Samsung HT-ES4200K Manual de usuario

Harman Kardon

Harman Kardon HS 100 Manual de usuario

Samsung

Samsung HT-P10 Manual de usuario

Goodmans

Goodmans GDVD19SWS Manual de usuario

Moxi

Moxi media center Manual de usuario

Samsung

Samsung HT-EM35 Manual de usuario

LG HE903PAW Manual de usuario

Bose

Bose SoundTouch 520 Manual de usuario

Sony

Sony BDV-N990W Manual de usuario

Manta

Manta GK-500 Manual de usuario

Sharp

Sharp SBW800 Manual de usuario

LG LHT799 Manual de usuario

Samsung

Samsung HT-TWZ415 Manual de usuario

Loewe

Loewe REFERENCE 52 SL FHD+ 200 NMP Manual de usuario

Samsung

Samsung AH68-02166R Manual de usuario

RCA

RCA 600-Watt Manual de usuario

Sony

Sony HT-7100DH Manual de usuario

Samsung

Samsung HT-DS630T Manual de usuario