Pentair Raychem PMKG-LE Manual de usuario

1 / 2

PMKG-LE

Low-ProfiLe end SeaL Kit inStaLLation inStructionS

THERMAL MANAGEMENT SOLUTIONS EN-RaychemPMKGLE-IM-H5407501/13

DESCRIPTION

The PMKG-LE is a NEMA Type 4X rated end seal kit designed for

use with Raychem BTV-CR, BTV-CT, QTVR-CT, LBTV2-CT, and

KHP-CR parallel heating cables. It is designed to be placed on the

pipe under the insulation and cladding.

For additional information contact your Pentair Thermal

Management representative or call (800)545-6258.

TOOLS REQUIRED

• Screwdriver • Wirecutters

• Utilityknife

ADDITIONAL MATERIALS REQUIRED

• Onegrommet:(1)

PMK-GK-10 P/N 222724-000 (Package of ten grommets)

• Glassclothtape

– GT-66 Installation temperature above 40°F (4°C)

 –GS-54 Installationtemperatureabove–40°F(–40°C)

(1) Required for LBTV2 (see step 1)

This component is an electrical device that must be installed

correctly to ensure proper operation and to prevent shock or fire.

Read these important warnings and carefully follow all of the

installation instructions.

• Tominimizethedangeroffirefromsustainedelectricalarcing

if the heating cable is damaged or improperly installed, and to

comply with the requirements of Pentair Thermal Management,

agency certifications, and National Electrical Codes, ground-

fault equipment protection must be used. Arcing may not be

stopped by conventional circuit breakers.

• Componentapprovalsandperformancearebasedontheuseof

Pentair Thermal Management-specified parts only. Do not use

substitute parts or vinyl electrical tape.

• Theblackheatingcablecoreisconductiveandcanshort.It

must be properly insulated and kept dry.

• Damagedbuswirescanoverheatorshort.Donotbreakbuswire

strands when scoring the jacket or core.

• Keepcomponentsandheatingcableendsdrybeforeandduring

installation.

• Buswireswillshortiftheycontacteachother.Keepbuswires

separated.

• Useonlyfire-resistantinsulationmaterials,suchasfiberglass

wrap or flame-retardant foam.

WARNING:

KIT CONTENTS

Item Qty Description

A 1 Pressure plate

B 1 End seal body with stainless steel screws

C 1 Red grommet (not for use with LBTV2)

D 1 End seal label

APPROVALS

-W

Class I, Div. 2, Groups A, B, C, D

Class II, Div. 2, Groups F, G

Class III

KHP-CR heating cables only

Hazardous Locations

Nonhazardous Locations

BTV-CR, BTV-CT, QTVR-CT and LBTV2-CT heating cables only

2 / 2THERMAL MANAGEMENT SOLUTIONS EN-RaychemPMKGLE-IM-H5407501/13

WWW.THERMAL.PENTAIR.COM

NORTH AMERICA

Tel: +1.800.545.6258

Fax: +1.800.527.5703

Tel: +1.650.216.1526

Fax: +1.650.474.7711

thermal.info@pentair.com

EuROPE, MIddLE EAsT, AfRICA

Tel: +32.16.213.511

Fax: +32.16.213.603

thermal.info@pentair.com

AsIA PACIfIC

Tel: +86.21.2412.1688

Fax: +86.21.5426.2917

cn.thermal.info@pentair.com

LATIN AMERICA

Tel: +55.11.2588.1400

Fax: +55.11.2588.1410

thermal.info@pentair.com

Pentair, BTV, QTVR, LBTV2 and KHP are owned by Pentair or its global affiliates. All other trademarks are the property of their respective owners. Pentair

reserves the right to change specifications without prior notice.

BTV-CR, BTV-CT, QTVR-CT, LBTV2-CT, KHP-CR

Bus wire

Conductive core

Inner jacket

Braid

Outer

jacket

3/4 in

(20 mm)

• Slidepartsontoheatingcable.

• Removeexposedbraid.

• Secureendsealtopipeusingcorrect

tape(GT-66orGS-54).

• Applyinsulationandcladding.

• Installlabelonoutsideofcladding.

• Leavetheseinstructionswiththeend

user for future reference.

• Lightlyscoreouterjacket.

• Bendheatingcabletobreakjacket

at score, then peel off jacket.

• Pushheatingcable

completely into end

seal body.

• Seatgrommetand

tighten screws.

WARNING: Use of the

wrong grommet can

result in leaks, cracked

components, shock or

dielectric failure, and

will invalidate

approvals and

certifications

• Identifyheatingcabletype.

• Selectcorrectgrommetfromtablebelow.

Heating Cable Type Grommet

BTV, QTVR -CR or -CT RED

LBTV2 -CT K *

KHP -CR RED

*Orderseparately

Identify Heating Cable Type

Otros manuales de Unidad de control de Pentair

Pentair

Pentair F251 Instrucciones de instalación y funcionamiento

Pentair

Pentair TRACETEK TTDM-128 Manual de usuario

Pentair

Pentair FLECK 5810 XTR2 Manual de usuario

Pentair

Pentair KEYSTONE OM3 Manual de usuario

Pentair

Pentair JUNG PUMPEN HIGHLOGO 1-25 LC Manual de usuario

Pentair

Pentair FLECK 9000 SXT Guía del usuario

Pentair

Pentair E-Box INTELLIPOOL Instrucciones de funcionamiento

Pentair

Pentair JUNG PUMPEN BASICLOGO AD 00 E Manual de usuario

Pentair

Pentair Fleck 2850 Manual de usuario

Pentair

Pentair FLECK 5812 XTR2 Manual de usuario

Pentair

Pentair FLECK 5000 Manual de usuario

Pentair

Pentair FLECK 9000 Manual de usuario

Pentair

Pentair Keystone Figure 952 NPS 2 Instrucciones de instalación

Pentair

Pentair AUTOTROL368 Guía del usuario

Pentair

Pentair FLECK 5800 Manual de usuario

Pentair

Pentair Anderson Greenwood 93 Series Manual de usuario

Pentair

Pentair AURORA CBV-S5 Manual de usuario

Pentair

Pentair Fleck 2510 ECONOMINDER Manual de usuario

Pentair

Pentair Autotrol 255 Series Guía del usuario

Pentair

Pentair Fleck 5600-MECH Manual de usuario

Pentair

Pentair Fleck 9000-SXT Manual de usuario

Pentair

Pentair E-Box SOLEO Connect Instrucciones de funcionamiento

Pentair

Pentair Fleck7000SXT Manual de usuario

Pentair

Pentair SUDMO P740 Manual de usuario

Manuales populares de Unidad de control de otras marcas

Festo

Festo Compact Performance CP-FB6-E Manual de lista de piezas

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manual de usuario

JS Automation

JS Automation MPC3034A Manual de usuario

JAUDT

JAUDT SW GII 6406 Series Guía rápida

Spektrum

Spektrum Air Module System Manual de usuario

BOC Edwards

BOC Edwards Q Series Manual de usuario

KHADAS

KHADAS BT Magic Manual de usuario

Etherma

Etherma eNEXHO-IL Manual de usuario

PMFoundations

PMFoundations Attenuverter Manual de usuario

GEA

GEA VARIVENT Manual de usuario

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manual de usuario

Altronix

Altronix LINQ8PD Instrucciones de montaje

Eaton

Eaton Powerware Series Manual de usuario

WAGO

WAGO 750-407/040-000 Manual de usuario

Sony

Sony CCU-590 Manual de usuario

Graco

Graco 25D614 Manual de usuario

Task Force Tips

Task Force Tips YE-RF-900 Manual de programación

Shini

Shini SPV-U Series Manual de usuario