Panasonic NN-GS595A Manual de usuario

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

1/3

ORDERNO.PHAMOS0511035C3

MicrowaveOven

NNGS595A

CHP(HongKong)

CYP(Singapore)

CMP(Malaysia)

CTP(Thailand,Indonesia)

CYT(Others)

CKT(UAE)

CPT(Iran)

CKP(Kuwait,Doha,Qatar,Oman,Bahrain,Pakistan)

CZP(CISCountries)

©2005PanasonicHomeAppliancesMicrowaveOven(Shanghai)Co.,Ltd.

Allrightsreserved.Unauthorizedcopyinganddistributionisaviolationoflaw.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

2/3

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

3/3

10/24/2016 schemat1.png(540×753)

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/doc/…

1/1

10/24/2016 schemat2.png(540×753)

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/doc/…

1/1

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

1/3

2DESCRIPTIONOFOPERATING

SEQUENCE

2.1Variablepowercookingcontrol

HighVoltageInverterPowerSupply(U)controlsoutputpowerbythesignalfromDigitalProgrammerCircuit(DPC).Powerrelay

alwaysstaysON,butPWM(pulsewidthmodulation)signalcontrolsmicrowaveoutputpower.

NOTE:

TheON/OFFtimeratiodoesnotcorrespondwiththepercentageofmicrowavepowersinceapproximately2secondsare

requiredforheatingofmagnetronfilament.

VariablePowerCooking

POWER SETTING OUTPUTPOWER(%) APPROX. MANUALMICROWAVEDUTY

ON(SEC) OFF(SEC)

HIGH 100% 22 0

MEDIUMHIGH 70% 22 0

MEDIUM 55% 22 0

MEDIUMLOW 40% 22 0

LOW 20% 13 9

DEFROST 30% 17 5

2.2InverterpowersupplycircuitNEWH.V.

TheInverterPowerSupplycircuitpoweredfromthelinevoltage,220V50HzACinputsupplies4,000VDCtothemagnetrontube,

andfunctionsinplaceoftheH.V.transformer,theH.V.capacitorandH.V.diode.

1.TheACinputvoltage220240V50HzisrectifiedtoDCvoltageimmediately.

2.DCvoltagewillbesuppliedtotheswitchingdevicescalledIGBT.ThesedevicesareswitchedONOFFbythe20to40

KHzPWM(pulsewidthmodulation)signalfromthemicrocomputerintheDPC.

3.ThisdrivestheHighvoltagetransformertoincreasevoltageupto2,000VAC.

4.Thenthehalfwavedoublervoltagerectifiercircuit,consistingoftheH.V.diodesandcapacitors,generatesthe

necessary4,000VDCneededforthemagnetron.

5.Outputpowerofthemagnetrontubeisalwaysmonitoredbythesignaloutputfromthecurrenttransformerbuiltintothe

invertercircuit.

6.ThissignalisfedbacktothemicrocomputerintheDPCtodetermineoperatingconditionsandoutputnecessaryto

controlPWMsignaltotheInverterPowerSupplyforcontroloftheoutputpower.

2.3Steamdefrost,Autocook&Steamreheat

WhentheAutoControlfeatureisselectedandtheStartpadistapped:

1.Thedigitalprogramercircuitdeterminesthepowerlevelandcookingtimetocompletecookingandindicatesthe

operatingstateinthedisplaywindow.Tableshowsthecorrespondingcookingtimesforrespectiveservingby

categories.

SteamDefrost

SELECTEDWEIGHT COOKINGTIME

1.0kg 15min.20sec.

AutoCook(Rice)

SELECTEDWEIGHT COOKINGTIME

0.2kg 20min.00sec.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

2/3

2.Whencookingtimeinthedisplaywindowhaselapsed,theoventurnsoffautomaticallybyacontrolsignalfromthe

digitalprogrammercircuit.

2.4Oven

ThedigitalprogrammercircuitcontrolstheONOFFtimeoftheheaterinordertocontrolovencavitytemperature.

1.Afterselectingdesiredovencavitytemperatureandpressing[Start]pad,ahighlevelsignalcomesoutmicrocomputer

andappliestopowerrelays,RY4andRY5.

2.WhenRY4&RY5switchtoON,powersourcevoltageisappliedtotheupperandlowerheaters,andtheheatersturn

on.

3.Thedigitalprogrammercircuitsensestheovencavitytemperaturethroughoventempsensor(thermistor).Whenthe

oventemperaturereachesthesettemperature,DPCstopssupplyinghighlevelsignaltothepowerrelays,andthe

heatersturnoff.

4.Aftertheupperandlowerheatersturnoff,theoventemperaturewillcontinueincreasingforawhileandthendecrease

asshowninFigure.

Whentheoventemperaturedropsbelowthesettemperature,thedigitalprogrammercircuitsensesthesignaland

startssupplyingahighlevelsignaltopowerrelaysagain.

2.5Combinationcookcontrol

Combinationcookingisaccomplishedbymicrowaveandgrillcooking(upperheater)beingdonesynchronouslyduringone

combinationcookingcycle.Onecombinationcookingcycleis33seconds.

1.Duringcombinationcooking,thedigitalprogrammercircuitcontrolspowerrelayRY4&RY5ʼsONOFFtime.Inallthree

combinationcookingcategories,powerrelayRY1alwaysstayon,butRY5ʼsONOFFtimeasshowninFigure.

COMBINATION CATEGORY GRILL(RY5) MICROWAVE(RY1)

ON(sec.) OFF(sec.)

COMBINATION CATEGORY GRILL(RY5) MICROWAVE(RY1)

ON(sec.) OFF(sec.)

1 33 0 ON

2 24 9 ON

3 18 15 ON

2.6IRreheat

Thetemperatureoffoodbeingheatedisdetectedbyaninfrared(IR)sensorandyoudonothavetosettime.

2.6.1HowtoreadtemperaturebyIRsensor

IRsensorcanreadfoodtemperaturewithouttouching,IRraysareemittedfromfood.IRsensoristogeneratetemperaturerelated

electricsignaloutputandmicrocomputeristoconvertactualtemperature.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

3/3

2.6.2Operation

IRsensorismountedontoprightofovencavitythroughthehole.Itscansallovercookingshelf.IRsensorhas8eyesandcanread

ovenshelflefttorightatthetime.ThenIRsensorisdesignedtoscanfronttobacktocoverallovershelf.(19points)



2.7Steamfunction(microsteam&steamreheat)

2.7.1WaterSupply

Waterinwatertankwillbepumpedoutandsupplytothesteamgenerationheaterlocatedinsidebackbottomofovencavity.

2.7.2Operation

Whenpressing[start]pad,ovenpreheatwillstartandthenwatersupplybegins.Itwilltake1minuteforpreheating.Whenpreheatis

completed,itwillturnintoactualcookingprocess.Duringheating,thetemperaturesensor(Thermistor)locatedonsteamheaterwill

monitorsteamheatertemperatureandwhenitexceeds95°C,theadditionalwaterwillbesuppliedtomaintainmoisture/steam

withinovencavity.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

1/3

3CAUTIONSTOBEOBSERVEDWHEN

TROUBLESHOOTING

Unlikemanyotherappliances,themicrowaveovenisahighvoltage,highcurrentdevice.Itisfreefromdangerinordinaryuse,

thoughextremecareshouldbetakenduringrepair.

Caution

Servicemenshouldremovetheirwatcheswheneverworkingclosetoorreplacingthemagnetron.

3.1Checkthegrounding

Donotoperateonatwowireextensioncord.Themicrowaveovenisdesignedtobegroundedwhenused.Itisimperative,

therefore,toensuretheapplianceisproperlygroundedbeforebeginningrepairwork.

3.2Inverterwarnings

DANGER,HIGHVOLTAGEANDHIGHTEMPERATURE(HOT/LIVE)OFTHEINVERTERPOWERSUPPLY(U)

TheHighVoltageInverterPowerSupplyhandlesveryhighvoltageandcurrentforthemagnetrontube.Thoughitisfreefrom

dangerinordinaryuse,extremecareshouldbetakenduringrepair.

Thealuminumheatsinkisalsoenergizedwithhighvoltage(HOT),donottouchwhentheACinputterminalsareenergized.The

powerdeviceCollectorisdirectlyconnectedtothealuminumheatsink.

ThealuminumheatsinkmaybeHOTduetoheatenergy,therefore,extremecareshouldbetakenduringservicing.

H.V.Inverterwarning

WARNINGFORINVERTERPOWERSUPPLY(U)GROUNDING

ChecktheHighVoltageInverterPowerSupplycircuitgrounding.Thehighvoltageinverterpowersupplycircuitboardmusthavea

properchassisground.Theinvertergroundingbracketmustbeconnectedtothechassis.Iftheinverterboardisnotgroundeditwill

exposetheusertoveryhighvoltagesandcauseextremeDANGER!Besurethattheinvertercircuitisproperlygroundedviathe

invertergroundingbracket.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

2/3

Groundingoftheinvertercircuitboard

WARNING!DISCHARGETHEHIGHVOLATGECAPACITORS

Forabout30secondsaftertheovenisturnedoff,anelectricchargeremainsinthehighvoltagecapacitorsintheInverterPower

Supplycircuitboard.

Whenreplacingorcheckingparts,removethepowerplugfromtheoutletandshorttheinverteroutputterminalofthemagnetron

filamentterminalstothechassisgroundwithaninsulatedhandlescrewdrivertodischarge.Pleasebesuretotouchthechassis

groundsidefirstandthenshorttotheoutputterminals.

Dischargingthehighvoltagecapacitors

WARNING

Thereishighvoltagepresentwithhighcurrentcapabilitiesinthecircuitsoftheprimaryandsecondarywindings,chokecoiland

heatsinkoftheinverter.Itisextremelydangeroustoworkonornearthesecircuitswiththeovenenergized.DONOTmeasurethe

voltageinthehighvoltagecircuitincludingthefilamentvoltageofthemagnetron.

WARNING

Nevertouchanycircuitwiringwithyourhandorwithaninsulatedtoolduringoperation.

3.3Partreplacement

Whenanypartorcomponentistobereplaced,alwaysensurethatthepowercordisremovedfromthewalloutlet.

3.4Whenthe10Afuseisblownduetotheoperationof

theshortswitch

WARNING

Whenthe10A220Vfuseisblownduetotheoperationoftheinterlockmonitorswitch,replaceallofthecomponents(primarylatch

switch,shortswitchandpowerrelayB(RY1)).

1.Thisismandatory.Referto“adjustmentsandmeasurements”forthelocationoftheseswitches.

2.Whenreplacingthefuse,confirmthatithastheappropriateratingforthesemodels.

Tabla de contenidos

Otros manuales de Microondas de Panasonic

Panasonic

Panasonic NN-GD34HW Manual de usuario

Panasonic

Panasonic Inverter NN-TK621SS Manual de usuario

Panasonic

Panasonic NN-ST25JW Manual de usuario

Panasonic

Panasonic NN-SD377 Manual de usuario

Panasonic

Panasonic NN-DS59NB Manual de usuario

Panasonic

Panasonic NN-CF873S Manual de usuario

Panasonic

Panasonic NE1021 - COMMERCIAL MICROWAVE Manual de usuario

Panasonic

Panasonic NN-SD978S Manual de usuario

Panasonic

Panasonic NN-SB65NS Manual de usuario

Panasonic

Panasonic H645 Manual de usuario

Panasonic

Panasonic NN-GF574M Manual de usuario

Panasonic

Panasonic NN9804 - MICROWAVE CONV. OVEN Manual de usuario

Panasonic

Panasonic NNH504WF - MICROWAVE -1.1 CUFT Manual de usuario

Panasonic

Panasonic NN-SD987 Manual de instrucciones

Panasonic

Panasonic Inverter NN-CD757W Guía del producto

Panasonic

Panasonic NN-SE992S Manual de usuario

Panasonic

Panasonic NE-1477 Manual de usuario

Panasonic

Panasonic NN-S758BA Manual de usuario

Panasonic

Panasonic NN-A880WB Manual de usuario

Panasonic

Panasonic NN-GF560M Manual de usuario

Panasonic

Panasonic NN-CS597S APH Manual de usuario

Panasonic

Panasonic NN-V359WB Manual de usuario

Panasonic

Panasonic NN-SD351M Manual de usuario

Panasonic

Panasonic NE-691 Manual de usuario

Manuales populares de Microondas de otras marcas

Daewoo

Daewoo KOG-574R0S Manual de usuario

LG MH7040SS Manual de usuario

Sharp

Sharp R-895(AL)M Manual de usuario

Dometic

Dometic DOTRM13W Manual de usuario

Sanyo

Sanyo EM-X680 Manual de usuario

Sharp

Sharp R-393M Manual de usuario

KitchenAid

KitchenAid KMCX4510 Instrucciones de instalación

Smeg

Smeg S45MCX1 Manual de usuario

Russell Hobbs

Russell Hobbs RHM2044 Manual de usuario

Sunbeam

Sunbeam SMW759 Manual de usuario

Gallet

Gallet FMOE230S Manual de usuario

Bosch

Bosch CEG732X.1B Manual de usuario

Dometic

Dometic Roadmate 230 Manual de usuario

Samsung

Samsung SJ0396W Manual de usuario

Sanyo

Sanyo EM-P494WS Manual de usuario

Sharp

Sharp R-240 Manual de usuario

Electrolux

Electrolux EMS2840 Manual de usuario

Daewoo

Daewoo KOC-984T2S13 Manual de usuario