Mineral Mizer Owner’s Manual (rev. 7)
DWS-SADI
Copyright
©
2016 O-SO Pure. All rights reserved.
Page 3 of 16
Definition
Within the context of this manual, we use the following
definitions:
•Deionized (DI) – water that is nearly free from ions,
the most common of which are metals (minerals)
and chlorides. DI water is roduced by filtration of
the source water.
•Mineral-free – water nearly devoid of all mineral
contamination.
•Total dissolved solids (TDS) – the mineral content of
a water sam le.
•Parts er million ( m) – the scale used to measure
mineral content of a water sam le.
•Distilled water – water that is mostly free from ions.
Distilled water is roduced by va orizing and
condensing the source water.
Warning
The DI water roduced by the Mineral Mizer is not
recommended for human consum tion. Although there
is no FDA warning concerning such consum tion, some
believe that mineral-free waters leach minerals from the
body. O-SO Pure makes no claims concerning the fitness
of the Mineral Mizer’s DI water for human consum tion.
The Mineral Mizer does not roduce bacteria-free water
nor does it attem t to sanitize or disinfect the water.
Feed water must be microbiologically safe.
Caution
The Mineral Mizer must be rotected against
•freezing tem eratures
•excessive heat
•excessive water ressure
•water hammer.
Failure to do so may result in breakage of water bearing
com onents and water leakage.
O-SO Pure recommends that feed water to the Mineral
Mizer be turned off when the office is unattended.
Introduction
Congratulations on your urchase of the Mineral Mizer autoclave water system. The Mineral Mizer roduces
deionized (DI) water from ta water, allowing you to exit
the boiled & bottled distilled water hamster wheel. When
routinely serviced, your Mineral Mizer will economically &
reliably deliver all of your DI water needs for years to
come.
The DI water roduced by the Mineral Mizer normally
registers at 000-002 arts er million ( m) on a handheld
total dissolved solids (TDS) tester.
A lications
Use the Mineral Mizer’s DI water for the following
a lications:
•Autoclave & Sterilizer – Scale formation in the boiler
is the leading cause of autoclave & sterilizer service
calls. Ta water causes film and scale that lead to
thermal inefficiency, increased maintenance and
downtime. Mineral Mizer’s DI water is even suitable
for sterilizers rogrammed to reject water when
mineral content exceeds a redetermined level.
•Iron and Steamer - Prevent scale buildu in
a liances that boil water by using DI water instead of
ta water.
•Di tilled water application - The DI water roduced
by the Mineral Mizer can be used for any a lication
calling for distilled water.
Now you can relax and enjoy the benefits of creating your
mineral-free DI water on-site. No more:
•strain & injury from carrying heavy bottles from
storage and lifting them onto dis ensers.
•tri s to the grocery store to urchase distilled water
bottles.
•waiting for the on-site distiller to dri out a gallon of
water while s inning the electric meter.
Your equi ment will benefit from the great water quality. Em loyees will love life without bottled water. You’ll
feel great about the green you save and the greening of your business by converting ta water directly into
mineral-free DI water.
