OWN-ADV 01/12
1
5.4.2 Shutdown Sequence........................ 35
5.5 Digital Output Setup..................... 35 - 37
5.6 Digital Input Setup............................... 38
5.7 Battery Setup ...................................... 38
5.8 Password Setup.................................. 39
5.9 Set Maintain ........................................ 39
5.10 Set Modbus....................................... 40
5.11 Common Faults................................. 40
5.12 Set Dummy Load .............................. 40
5.13 NMEA 2000®Setup .......................... 41
GROUP 6 -
RECOMMENDED MAINTENANCE
.. 41
GROUP 7 - WAVENET REMOTE PANEL...... 42
7.1 On-Line Genset Status Mode ............. 42
7.1.1 Genset Controller’s Name................ 42
7.1.2 State.......................................... 42 - 43
7.1.3 Status Mark...................................... 43
7.2 On-Line Genset Parameter Mode....... 43
7.3 Remote Unit Settings .......................... 44
GROUP 8 - APPENDIX A: ACCESSORY LIST
8.1
WaveNet Controller Harness - Accessories
.... 45
8.2 WaveNet Programmer ........................ 45
8.3 CT’s (Current Transformers) ............... 46
8.4 WaveNet Replaceable 12/24 VDC Relays
..... 46
8.5 WaveNet Fusing.................................. 47
GROUP 9
-
APPENDIX B: MODBUS MAP
9.1 Communication Details ................ 47 - 48
9.2 Modbus Commands............................ 49
9.3 Register Map................................. 49 -65
GROUP 10
-
APPENDIX C: NMEA 2000 PGN’S..62
10.1 NL Propriety (Fast Packet).......... 63 -67
10.2 Address Claim................................... 67
10.3 ISO 17783 Request .......................... 67
10.4 Production Information...................... 67
10.5
Generator Phase A/B/C Basic AC Quantities
.. 67
10.6
Engine Parameters (Rapid Update
)......... 68
10.7
Engine Parameters (Dynamic
) ............... 68
10.8
Battery Status ..........................................
68
10.9 Fluid Level
............................................ 68
GROUP 11
-
APPENDIX D: ADDITIONAL DRAWINGS
.69
WaveNet Specifications .................................... 2
GROUP 1 - WAVENET CONTROLLER SERIES
1.1 This Manual........................................... 3
GROUP 2-
RECEIVING, HANDLING & STORAGE.3-4
GROUP 3 - INSTALLATION & WIRING
3.1 Safety Information............................ 4 - 5
3.2 12/24 VDC System Operation............... 5
3.2.1 Relays ................................................ 5
3.2.2 Relay Fuses ....................................... 5
3.3 WaveNet Terminals ........................ 5 - 10
3.3.1 Current Transformer Wiring Note..... 10
GROUP 4 -
OPERATION & BASIC USER CONFIGURATION
4.1 Power-Up ............................................ 11
4.2 Controller Alarming ............................. 11
4.3 Emergency Stop ................................. 11
4.4 Controller States .......................... 12 - 13
4.4.1
Locking the WaveNet Screen in Run Mode
. 13
4.5 WaveNet Start / Stop Behavior .... 13 - 14
4.6 Generator Starting & Stopping............ 14
4.7 Controller Sleep .................................. 14
4.8 WaveNet Menu System Operation...... 15
4.9 Basic Menu ......................................... 15
4.9.1 Clock Setup............................... 15 - 16
4.9.2 Basic Setup............................... 16 - 17
4.9.3 Event History Log...................... 17 - 19
4.10 WaveNet LED Status Indicators........ 20
4.11 Lamp Indication Meanings ......... 20 - 21
4.12 Warnings & Failures................... 21 - 22
4.13 Genset Online ................................... 22
GROUP 5 - ADVANCED SETUP.............22 - 27
5.1 Analog Inputs ............................... 28 - 29
5.1.1 Fuel Level Sender - Special Case ... 29
5.1.2 WaveNet Sender Support ......... 29 - 30
5.2 Speed Sending ................................... 30
5.2.1 Rated Speed .................................... 31
5.3
Generator (AC Voltage/Current/Freq.)Setup
..
31
5.3.1 AC Frequency .................................. 31
5.3.2 AC Voltage ................................ 31 - 32
5.3.2.1 Voltage Select Inputs ............. 32 - 33
5.3.3
AC Current
........................................ 33
5.4 Engine Logic ....................................... 34
5.4.1 Startup Sequence ............................ 34
5.4.1.1 Locked Rotor................................. 35
Proprietary Information
This publication is the sole property of Northern Lights, Inc.
It may not be reproduced in whole or part without the expressed written permission of Northern Lights, Inc.
© Northern Lights, Inc. 2010. All rights reserved. Litho U.S.A. Publication number: OWAVENET_ADVANCED 1/12.
Table of Contents
USER MANUAL
for WaveNet Generator Set Controllers
