Nokia RH-57 Series Guía de inicio rápido

Nokia Customer Care

2112 (RH-57) Series Transceivers

Issue 1 07/2004 Company Confidential ©2004 Nokia Corporation

Disassembly/Assembly

2112 (RH-57)

Disassembly/Assembly Nokia Customer Care

Page 2 ©2004 Nokia Corporation Company Confidential Issue 1 07/2004

Disassembly Instructions

Use the following instructions to disassemble the 2112. Use the reverse order to

assemble the phone.

1. Press the release button before removing the C-cover.

2. Remove the A-cover.

3. Always protect the window with a protection film to avoid dust and scratches.

4. Unscrew the six T6 screws using the order shown. For assembly, you must use

the reverse order and a Torx T6 PLUS with torque of 20Ncm.

Torque 20Ncm

for assembly

Nokia Customer Care Disassembly/Assembly

2112 (RH-57)

Issue 1 07/2004 ©2004 Nokia Corporation Company Confidential Page 3

5. Separate the module from the B-cover and unplug the display connector

carefully by removing the UI shield from system module.

6. Separate the UI shield from the system module carefully. The key dome is

attached with adhesive tape, which must not be touched.

7. Separate the LCD from the UI shield by pressing out the LCD using a clean cloth.

Prevent the key dome tape from getting dirty.

8. Always protect the LCD window with a protection foil to avoid dust and

scratches.

2112 (RH-57)

Disassembly/Assembly Nokia Customer Care

Page 4 ©2004 Nokia Corporation Company Confidential Issue 1 07/2004

9. Remove the earpiece. Note the guiding pin when re-assembling.

10. The shielding is attached with hooks at its backside. To remove the shielding from

the B-cover, first expand the B-cover, then push the shielding upwards.

11. Remove the power button key.

12. Use the SRT-6 to lift up the antenna.

Nokia Customer Care Disassembly/Assembly

2112 (RH-57)

Issue 1 07/2004 ©2004 Nokia Corporation Company Confidential Page 5

13. Remove the antenna.

14. Use tweezers to remove the vibra motor.

15. Use tweezers to pull up the microphone.

16. To remove the DC jack, place tweezers between the spring contacts and under

the jack. You need to use additional force to pull the jack upwards.

2112 (RH-57)

Disassembly/Assembly Nokia Customer Care

Page 6 ©2004 Nokia Corporation Company Confidential Issue 1 07/2004

17. Use a flathead screwdriver as a lever to remove the release spring.

18. Turn the B-cover as shown to allow the release button to fall out.

19. Open the SIM flap and turn it as shown in the picture.

20. Expand the B-cover carefully and remove the SIM flap.

Nokia Customer Care Disassembly/Assembly

2112 (RH-57)

Issue 1 07/2004 ©2004 Nokia Corporation Company Confidential Page 7

Exchange of Battery Connector X103

These are the two soldered support angles.

1. Use a side cutter to cut the support angles.

2. Push tweezers into the outside openings of the battery connector and lift up the

plastic cover.

3. Desolder all pins and clean the pads.

2112 (RH-57)

Disassembly/Assembly Nokia Customer Care

Page 8 ©2004 Nokia Corporation Company Confidential Issue 1 07/2004

You need a soldering iron with a higher temperature when cleaning or soldering

the ground pad.

Note the location markings to fit the connector precisely.

4. Tin one of the pads to fix the connector before soldering the following pins.

5. Place the connector between the markings and solder the first support angle. If

the position is exact, solder the other pins.

Otros manuales para RH-57 Series

2

Este manual sirve para los siguientes modelos

1

Tabla de contenidos

Otros manuales de Transceptor de Nokia

Nokia

Nokia NHM-4 Series Instrucciones de instalación

Nokia

Nokia NSE-6 SERIES Manual de usuario

Nokia

Nokia NSW-6 Series Guía

Nokia

Nokia NHM-1 Series Guía

Nokia

Nokia NSB-5 Series Instrucciones de instalación

Nokia

Nokia RH-10 Series Instrucciones de funcionamiento

Nokia

Nokia NSE-6 SERIES Guía

Nokia

Nokia NSB-9 Manual de usuario

Nokia

Nokia NHM-2nx Series Instrucciones de funcionamiento

Nokia

Nokia NKC-1X Series Guía

Nokia

Nokia RH-34 Series Guía de inicio rápido

Nokia

Nokia NSB-5 Series Guía

Nokia

Nokia NSM-3 Guía

Nokia

Nokia RM-11 Series Instrucciones de instalación

Nokia

Nokia NSM-1 Series Instrucciones de instalación

Nokia

Nokia NSC/W-1/3 Series Instrucciones de instalación

Nokia

Nokia NSB-9 Guía

Nokia

Nokia NPM-6 Series Guía

Nokia

Nokia RM-11 Series Instrucciones de funcionamiento

Nokia

Nokia NPD-4 Series Manual de usuario

Nokia

Nokia RH-30 Series Guía

Nokia

Nokia NSW-6 Series Guía

Nokia

Nokia NSB-1 Series Instrucciones de instalación

Nokia

Nokia RH-41 Series Guía

Manuales populares de Transceptor de otras marcas

Yaesu

Yaesu FT-7B Manual de usuario

Kenwood

Kenwood ProTalk TK-3201 Manual de usuario

Texas Instruments

Texas Instruments TLK10232 Manual de usuario

Mizuho

Mizuho MX-2 Guía del producto

Kenwood

Kenwood TK-3180 Manual de operación y mantenimiento

Blitz

Blitz MJ-398U Manual de usuario

Utilicom

Utilicom LongRanger 2050 Manual de usuario

Standart

Standart HX290UKA Manual de usuario

Altronix

Altronix Pace1PTM Manual de usuario

Kirisun

Kirisun PT2208 Manual de usuario

ELECRAFT

ELECRAFT KX2 Manual de usuario

Zodiac

Zodiac K3 Manual de usuario

Assa Abloy

Assa Abloy SecureComm HKC GSM-WIFI U Manual de usuario

Kenwood

Kenwood TK-2217 Manual de usuario

Siemens

Siemens PSO 4000 Manual de usuario

Kenwood

Kenwood TS-590SG Manual de usuario

Midland

Midland G8E-BT Manual

ComNav

ComNav Mariner X2 Manual de usuario