Nibe VPB Series Guía del usuario

Installer manual

LEK

VPB/VPBS

Water heater

IHB GB 1536-6

031441

Table of Contents

21 Important information

2Safety information

52 Delivery and handling

5Transport

5Assembly

5Supplied components

6Removing the covers

73 The water heater design

94 Pipe connections

9General

9Dimensions and pipe connections

11Heat pump

11Sun

11Cold and hot water

12Installation alternative

145 Electrical installation

14Sensors

14Direct-current anode

156 Commissioning and adjusting

15Filling and venting

16Start-up and inspection

177 Service

17Service actions

188 Technical data

18Dimensions and setting-out coordinates

19Technical specifications

20Energy labelling

21Index

1Table of Contents |VPB/VPBS

Safety information

This manual describes installation and service proced-

ures for implementation by specialists.

This appliance can be used by children

aged from 8 years and above and per-

sons with reduced physical, sensory or

mental capabilities or lack of experience

and knowledge if they have been given

supervision or instruction concerning

use of the appliance in a safe way and

understand the hazards involved. Chil-

dren shall not play with the appliance.

Cleaning and user maintenance shall

not be made by children without super-

vision.

Rights to make any design or technical

modifications are reserved.

©NIBE 2015.

Symbols

NOTE

This symbol indicates danger to machine or

person.

Caution

This symbol indicates important information

about what you should observe when main-

taining your installation.

TIP

This symbol indicates tips on how to facilitate

using the product.

Marking

VPB/VPBS is CE marked and fulfils IP21.

The CE marking means that NIBE ensures that the

product meets all regulations that are placed on it

based on relevant EU directives. The CE mark is obligat-

ory for most products sold in the EU, regardless where

they are made.

IP21 means that objects with a diameter larger than

or equivalent to 12.5 mm cannot penetrate and cause

damage and that the product is protected against

vertically falling drops of water.

Serial number

The serial number can be found at the bottom right of

the front cover.

600

205

480

390

25-50 1475

80100

560 440

Serial number

600

205

480

390

25-50 1475

80100

560 440

Caution

Always give the product's serial number when

reporting a fault.

Country specific information

Installer manual

This installer manual must be left with the customer.

VPB/VPBSChapter 1 | Important information2

1 Important information

Inspection of the installation

Current regulations require the heating installation to be inspected before it is commissioned. The inspection must

be carried out by a suitably qualified person.

DateSignatureNotesDescription

✔

Heat pump (page 11)

Shut off valves

Hot water (page 11)

Shut off valves

Cold water (page 11)

Shut off valves

Non-return valve

Mixing valve

Safety valve

Electricity (page 14)

Sensors

Direct-current anode (only VPB/VPBS E)

3Chapter 1 | Important informationVPB/VPBS

Contact information

KNV Energietechnik GmbH, Gahberggasse 11, 4861 SchörflingAT

Tel: +43 (0)7662 8963-0 Fax: +43 (0)7662 8963-44 E-mail: mail@knv.at www.knv.at

NIBE Wärmetechnik c/o ait Schweiz AG, Industriepark, CH-6246 AltishofenCH

Tel: (52) 647 00 30 Fax: (52) 647 00 31 E-mail: [email protected] www.nibe.ch

Druzstevni zavody Drazice s.r.o, Drazice 69, CZ - 294 71 Benatky nad JizerouCZ

Tel: +420 326 373 801 Fax: +420 326 373 803 E-mail: [email protected] www.nibe.cz

NIBE Systemtechnik GmbH, Am Reiherpfahl 3, 29223 CelleDE

Tel: 05141/7546-0 Fax: 05141/7546-99 E-mail: [email protected] www.nibe.de

Vølund Varmeteknik A/S, Member of the Nibe Group, Brogårdsvej 7, 6920 VidebækDK

Tel: 97 17 20 33 Fax: 97 17 29 33 E-mail: [email protected] www.volundvt.dk

NIBE Energy Systems OY, Juurakkotie 3, 01510 VantaaFI

Puh: 09-274 697 0 Fax: 09-274 697 40 E-mail: inf[email protected] www.nibe.fi

NIBE Energy Systems France Sarl, Zone industrielle RD 28, Rue du Pou du Ciel, 01600 ReyrieuxFR

Tel : 04 74 00 92 92 Fax : 04 74 00 42 00 E-mail: [email protected] www.nibe.fr

NIBE Energy Systems Ltd, 3C Broom Business Park, Bridge Way, Chesterfield S41 9QGGB

Tel: 0845 095 1200 Fax: 0845 095 1201 E-mail: [email protected].uk www.nibe.co.uk

NIBE Energietechniek B.V., Postbus 634, NL 4900 AP OosterhoutNL

Tel: 0168 477722 Fax: 0168 476998 E-mail: [email protected] www.nibenl.nl

ABK AS, Brobekkveien 80, 0582 Oslo, Postadresse: Postboks 64 Vollebekk, 0516 OsloNO

Tel. sentralbord: +47 23 17 05 20 E-mail: [email protected] www.nibeenergysystems.no

NIBE-BIAWAR Sp. z o. o. Aleja Jana Pawła II 57, 15-703 BIAŁYSTOKPL

Tel: 085 662 84 90 Fax: 085 662 84 14 E-mail: sekretariat@biawar.com.pl www.biawar.com.pl

Tel./fax +7 831 419 57 06 E-mail: [email protected] www.nibe-evan.ru

NIBE AB Sweden, Box 14, Hannabadsvägen 5, SE-285 21 MarkarydSE

Tel: +46-(0)433-73 000 Fax: +46-(0)433-73 190 E-mail: [email protected] www.nibe.se

For countries not mention in this list, please contact Nibe Sweden or check www.nibe.eu for more information.

VPB/VPBSChapter 1 | Important information4

Transport

However. the VPB/VPBS may be carefully laid on its

back when being moved into a building. The centre of

gravity is in the upper part.

VPB/VPBS should be transported and stored vertically

in a dry place. However, the VPB/VPBS may be carefully

laid on its back when being moved into a building.

-2

HMflow

49(50)°C

Hotwater

51°C

-2

HMflow

49(50)°C

Hotwater

51°C

Assembly

■The water heater is only designed for upright install-

ation.

■Position VPB/VPBS on a firm base that can take the

weight, preferably on a concrete floor or foundation.

Use the water heater's adjustable feet to obtain a

horizontal and stable set-up.

30 - 50 mm

15 - 40 mm

■The area where VPB/VPBS is located must be

equipped with floor drainage.

■The water heater's installation area should always

have a temperature of at least 10 °C and max 30 °C.

Supplied components

VPB/VPBS Enamel

Potentiostat

Location

The kit of supplied items is placed on top of the

product.

LEK

5Chapter 2 | Delivery and handlingVPB/VPBS

2 Delivery and handling

Removing the covers

Front cover

LEK

1. Remove the screws from the lower edge of the

front cover.

2. Lift the cover out at the bottom edge and up.

Side covers

LEK

The side covers can be removed to facilitate the install-

ation.

1. Remove the screws from the upper and lower

edges.

2. Twist the cover slightly outward.

3. Move the hatch backwards and slightly to the side.

4. Pull the cover to one side.

5. Pull the hatch forwards.

VPB/VPBSChapter 2 | Delivery and handling6

LEK

XL8 XL4 XL3 XL9 XL5

UA1

FR1

UA2

PF1

XL8 XL4 XL3 XL9

UA1

Sv PDB

UA2

Givarkabeldragning

Denna bild används för ?

LEK

XL8 XL4 XL3 XL9 XL5

UA1

FR1

UA2

PF1

XL8 XL4 XL3 XL9

UA1

Sv PDB

UA2

Givarkabeldragning

Denna bild används för ?

XL9

UA1

UA2

QM22

XL5

PF3

XL8 XL4 XL3

FR1

Sv PBD

Givarkabeldragning

LEK

XL4

XL13XL8 XL3 XL9

UA1

UA2

UA3

XL14

VPB 200 VPB 300/VPBS 300

XL9XL8 XL4 XL3

QM22

UA1

UA2

XL5

FR1

PF1

XL13 XL14

UA3

7Chapter 3 | The water heater designVPB/VPBS

3 The water heater design

Pipe connections

Connection, cold waterXL3

Connection, hot waterXL4

Connection, hot water circulation

(Not VPB/VPBS Cu)

XL5

Docking connection, supply line (from heat

pump*)

XL8

Docking connection, return line (to heat pump*)XL9

Connection, supply line (from solar heating sys-

tem) (Only VPBS 300)

XL13

Connection, return line (to solar heating system)

(Only VPBS 300)

XL14

HVAC components

Venting, charge coilQM22

Submerged tube for hot water sensor (display)UA1

Submerged tube for hot water sensor (control)UA2

Submerged tube for solar sensor (control)UA3

Electrical components

Direct-current anode (VPB/VPBS E)FR1

Cable to direct-current anode (VPB/VPBS E)W1

Miscellaneous

Rating platePF1

Serial number platePF3

Adjustable feetUL

Designations in component locations according to

standard IEC 81346-1 and 81346-2.

*or another external heat source

VPB/VPBSChapter 3 | The water heater design8

Otros manuales para VPB Series

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Calentador de agua de Nibe

Nibe

Nibe AP-WH7 Manual de usuario

Nibe

Nibe VPB Series Guía del usuario

Nibe

Nibe PCU-R 80 Manual de usuario

Nibe

Nibe UKV 40 Manual de uso y cuidado

Nibe

Nibe EMINENT-E/CU/R 35 Manual de usuario

Nibe

Nibe UKV 102 Manual de usuario

Nibe

Nibe UKV 200 Kyla Manual de uso y cuidado

Nibe

Nibe EKS 500 L Manual de uso y cuidado

Nibe

Nibe ES -160 Manual de usuario

Nibe

Nibe VPD 150 Manual de uso y cuidado

Nibe

Nibe UKV 20-40 Manual de usuario

Nibe

Nibe VPD 300 Guía del usuario

Nibe

Nibe EKS 500 Manual de usuario

Nibe

Nibe EL Series Manual de uso y cuidado

Nibe

Nibe PUB2 Series Manual de usuario

Nibe

Nibe VVM 320 Manual de usuario

Nibe

Nibe Compact Sol 300 Manual de uso y cuidado

Nibe

Nibe VPB 500 UK Manual de usuario

Nibe

Nibe VVM 310 Manual de usuario

Nibe

Nibe VPB Series Manual de uso y cuidado

Nibe

Nibe VPA 300 Manual de uso y cuidado

Nibe

Nibe EL 150 Manual de uso y cuidado

Nibe

Nibe AHPS 10-300 Guía del usuario

Nibe

Nibe Eminent 35 Manual de usuario

Manuales populares de Calentador de agua de otras marcas

Kenmore

Kenmore 153.582400 Manual de usuario

Applimo

Applimo Edel AIR Manual de usuario

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manual de usuario

clage

clage E-Mini Series Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-180 Manual de usuario

Bradford White

Bradford White EF Series Manual de usuario

Eccotemp

Eccotemp 40-H Manual de usuario

Dimplex

Dimplex ECSd125-580 Guía

Dux

Dux 32FCR6N Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guía de solución de problemas

Noritz

Noritz N-132M Manual de instrucciones

TESY

TESY GCV7/4S 10047 Hoja de especificaciones

A.O. Smith

A.O. Smith Gphe 50 Manual de usuario

Koryo

Koryo KWHZF15Y Manual de usuario

Pentair

Pentair PSC-14-4-02 Manual de usuario

GE 40M06AAG Instrucciones de montaje

Thermor

Thermor AEROMAX SPLIT 2 Manual de usuario

American Hometec

American Hometec AHQ-B03X Manual de usuario