MSA FieldServer FGFD ProtoAir Manual de usuario

Operating Manual

FGFD ProtoAir

Revision: 2.E

Document No.:T18626

Print Spec: 10000005389 (F)

MSAsafety.com

MSA Safety

1000 Cranberry Woods Drive

Cranberry Township, PA 16066 USA

U.S. Support Information:

+1 408 964-4443

+1 800 727-4377

Email: [email protected]

EMEA Support Information:

+31 33 808 0590

Email:

[email protected]

For your local MSA contacts, please go to our website www.MSAsafety.com

Contents

1 Equipment Setup 5

1.1 Physical Dimensions 5

1.1.1 Covered Unit 5

1.1.2 Cover Removed 6

1.2 Inserting the SIM Card 7

2 Connecting the Serial Port 9

2.1 Wiring 9

3 Operation 10

3.1 Apply Power to the FieldServer NEMA 10

3.2 Connect the PC to the ProtoAir Over the Ethernet Port 11

4 Connecting to the ProtoAir 12

4.1 Using a Web Browser 12

4.2 Using the FieldServer Toolbox to Discover and Connect to the ProtoAir 12

5 Setup Web Server Security 13

5.1 Login to the FieldServer 13

5.2 Select the Security Mode 15

5.2.1 HTTPS with Own Trusted TLS Certificate 16

5.2.2 HTTPS with Default Untrusted Self-Signed TLS Certificate or HTTP with Built-in Payload Encryption 16

6 Setup Network 17

6.1 Navigate to the Network Settings 17

6.2 Change the ProtoAir IP Address 18

6.2.1 Routing Settings 18

6.2.2 Ethernet 1 19

6.2.3 Wi-Fi Client Settings 20

6.2.4 Wi-Fi Access Point Settings 21

6.2.5 Cellular Settings 22

7 MSA Grid - FieldSever Manager Setup 23

7.1 Choose Whether to Integrate the FieldServer Manager 23

7.2 User Setup 24

7.3 Registration Process 26

7.4 Login to the FieldServer Manager 30

8 Configure the ProtoAir 32

8.1 Navigate to the ProtoAir Web Configurator 32

8.2 Select Field Protocol and Set Configuration Parameters 33

8.3 Setting ProtoAir Active Profiles 34

8.4 Verify Device Communications 35

8.5 BACnet: Setting Node_Offset to Assign Specific Device Instances 36

8.6 How to Start the Installation Over: Clearing Profiles 37

9 Troubleshooting 38

9.1 Lost or Incorrect IP Address 38

9.2 Viewing Diagnostic Information 39

FGFD ProtoAir 3

9.3 Checking Wiring and Settings 40

9.4 LED Functions 41

9.5 Taking a FieldServer Diagnostic Capture 42

9.6 Wi-Fi Signal Strength 43

9.7 Factory Reset Instructions 43

9.8 Internet Browser Software Support 43

9.9 APN Table 43

10 Additional Information 44

10.1 Update Firmware 44

10.2 BACnet: Setting Network_Number for More Than One ProtoAir on the Subnet 44

10.3 Change Web Server Security Settings After Initial Setup 45

10.3.1 Change Security Mode 46

10.3.2 Edit the Certificate Loaded onto the FieldServer 47

10.4 Change User Management Settings 48

10.4.1 Create Users 49

10.4.2 Edit Users 50

10.4.3 Delete Users 51

10.4.4 Change FieldServer Password 52

10.5 FieldServer Manager Connection Warning Message 53

10.6 System Status Button 54

11 Vendor Information – MSA Safety 55

11.1 Chillgard_5000 Mappings to Field Protocols 55

11.2 FL500 Mappings to Field Protocols 59

11.3 IR5500 Mappings to Field Protocols 60

11.4 ELDS Mappings to Field Protocols 63

11.5 S5000 Mappings to Field Protocols 64

11.6 Suprema_MBC20_Input Mappings to Field Protocols 71

11.7 ChillGard_VRF Mappings to Field Protocols 142

11.8 MC600 Mappings to Field Protocols 142

11.9 ModCon_75 Mappings to Field Protocols 145

11.10 Gasgard_XL Mappings to Field Protocols 153

11.11 Ultima_X Mappings to Field Protocols 157

11.12 TRIGARD Mappings to Field Protocols 160

11.13 ZGARD Mappings to Field Protocols 163

11.14 FL4000H Mappings to Field Protocols 164

11.15 Sentry_Controller_01_16 Mappings to Field Protocols 165

11.16 Sentry_Controller_17_32 Mappings to Field Protocols 168

11.17 Sentry_Controller_01_32 Mappings to Field Protocols 171

11.18 X5000_4_20mA Mappings to Field Protocols 176

11.19 S5000_4_20mA Mappings to Field Protocols 176

11.20 NetSafety_Safeguard_Controller Mappings to Field Protocols 177

11.21 9010_9020_LCD Mappings to Field Protocols 182

11.22 9010_9020_SIL Mappings to Field Protocols 186

11.23 Warnings for FCC and IC 190

12 Limited 2 Year Warranty 193

4 FGFD ProtoAir

1 Equipment Setup

1.1 Physical Dimensions

1.1.1 Covered Unit

FGFD ProtoAir 5

1.1.2 Cover Removed

6 FGFD ProtoAir

1.2 Inserting the SIM Card

NOTE:A micro 4G SIM card must be purchased from an AT&T, or Verizon or Vodafone cellular provider to set

up cellular functionality and create a data plan for the ProtoAir. SIM card vendor contact information is

available at the end of the section.

Insert the SIM card into the Micro SIM card slot with the chip on the SIM card facing away from the cellular antenna as

shown below.

See Section 6.2.5 Cellular Settings to complete cellular setting configuration.

The table below shows cellular usage examples to forecast data usage on the chosen cellular plan.

Number of Data Points Logging Frequency Data Usage per Hour Data Usage per Month

10 40 sec 0.75 Mb 547 Mb

10 900 sec 0.55 Mb 400 Mb

50 40 sec 1.24 Mb 900 Mb

50 900 sec 0.90 Mb 657 Mb

100 40 sec 3.00 Mb 2.2 Gb

100 900 sec 1.26 Mb 900 Mb

500 40 sec 10.86 Mb 7.8 Gb

500 900 sec 0.55 Mb 1.5 Gb

FGFD ProtoAir 7

SIM Card Vendor Contact Information:

Verizon

A business contract is required to purchase a Verizon SIM card. The IMEI of the ProtoAir is required to purchase the Verizon

SIM card.

AT&T

Please call AT&T Customer Service at 800.331.0500 or find the nearest AT&T store.

Vodafone

Please contact the nearest Vodafone store.

8 FGFD ProtoAir

2 Connecting the Serial Port

Locate the ProtoAir inside the unit and connect to the 3-pin connector as shown below.

The following baud rates are supported on the P1 Port:

9600, 19200, 38400, 57600, 76800, 115000

NOTE:Not all baud rates listed are supported by all protocols. Check the specific protocol driver manual for a

list of the supported baud rates.

2.1 Wiring

RS-485 RS-232

OEM Device or BMS

RS-485 Wiring ProtoAir Pin Assignment OEM Device or BMS RS-232 Wiring ProtoAir Pin Assignment

RS-485 + TX + RS-232 - TX +

RS-485 - RX - RS-232 + RX -

GND GND GND GND

NOTE:Use standard grounding principles for GND.

FGFD ProtoAir 9

3 Operation

3.1 Apply Power to the FieldServer NEMA

Apply power to the terminal block. Ensure that the power supply used complies with the specifications provided. Ensure that

the cable is grounded using the terminal block on the right side of the image below labeled “G”.

24VDC 110VAC Ground

Gray Terminal Block Power

Label

Power

Connection

White Terminal Block Power

Label

Power

Connection

Gray Terminal Block

Label

1 + F2 G

2 - F3

3 -

10 FGFD ProtoAir

Tabla de contenidos

Otros manuales de Puerta de MSA

MSA

MSA fieldserver EZ Gateway M-Bus to Modbus &... Guía del usuario

MSA

MSA fieldserver ProtoNode FPC-N64 Guía del usuario

MSA

MSA fieldserver EZ Series Manual de usuario

MSA

MSA MultiGard 5000 Manual de usuario

MSA

MSA fieldserver ProtoCarrier Manual de usuario

MSA

MSA FieldServer ProtoCarrier FPC-C34 Guía del usuario

MSA

MSA FieldServer FS-B35 Series Guía del usuario

MSA

MSA FS-EZX-KNX-BAC Guía del usuario

MSA

MSA fieldserver ProtoNode Manual de usuario

MSA

MSA fieldserver QuickServer FS-QS-2 0 Series Guía del usuario

MSA

MSA FieldServer QuickServer FS-QS-1011 Guía del usuario

MSA

MSA fieldserver ProtoNode FPC-N54 Guía del usuario

MSA

MSA QuickServer FS-QS-2XX0 Manual de usuario

MSA

MSA FieldServer ProtoNode FPC-N34 Guía del usuario

MSA

MSA HUB Manual de usuario

MSA

MSA fieldserver ProtoAir FPA-C41 Manual de usuario

MSA

MSA ProtoAir FPA-C4X Guía del usuario

Manuales populares de Puerta de otras marcas

LST

LST M500RFE-AS Manual de usuario

Kinnex

Kinnex Media Gateway Manual de usuario

2N Telekomunikace

2N Telekomunikace 2N StarGate Manual de usuario

Mitsubishi Heavy Industries

Mitsubishi Heavy Industries Superlink SC-WBGW256 Manual de usuario

ZyXEL Communications

ZyXEL Communications ZYWALL2 ET 2WE Manual de usuario

Telsey

Telsey CPVA 500 - SIP Manual de usuario

RTA

RTA 460A-NNA4 Hoja de especificaciones

Shaw

Shaw Gateway HDPVR Manual de usuario

ABB

ABB VSN900 Guía de inicio rápido

Commander

Commander Pulse Manual de usuario

2N Telekomunikace

2N Telekomunikace ATEUS EasyGate 501309E Manual de usuario

NETGEAR

NETGEAR C6300BD Manual de usuario

Amit

Amit CDW531AM Manual de usuario

HMS

HMS Netbiter EasyConnect EC150 Manual de usuario

Huawei

Huawei EchoLife HG620 Manual de usuario

AT&T

AT&T U-verse 3801 Manual de uso y cuidado

Logic IO

Logic IO RTCU MX2 turbo Manual de usuario

Suttle

Suttle MediaMAX MXM-521 Manual de usuario