Modena Rapido Series Manual del propietario

User

Manual Book

Gas Instant Water Heater

Rapido Series

GI 1020 B, GI 0620 B

TABLE OF CONTENT

Part 1: Important Safety Information 3

Part 2: Name of Parts 4

Characteristic and Usage 4

Part 3: Installation 6

Installation Requirement 6

Installation Mode 9

Part 4: How to Use 13

Preparation Before Ignition 13

Ignition/Operation 14

Discontinuing the Use 15

Replacing Batteries 15

Part 5: Preventive Action 16

Prevention of Gas Accident 16

Prevention of Fire 17

Prevention of Carbon Monoxide Poisoning 18

Other Cautions 19

Treatment of Abnormalities 20

Maintenance 20

Repair Service 22

Packing List 22

Part 6: Troubleshooting 23

Part 7: Specification 25

Appendix: Wiring Diagram 26

This manual book explains everything you need to know about your

new product. Please contact our Customer Care should you need

further assistance through www.modena.com.

When the water heater is operated, gas combustion will consume a

large amount of oxygen and exhaust much carbon monoxide. To avoid

the great harm for human health or even death caused by excessive

carbon monoxide inhalation, MODENA sincerely advise all users to:

Read this manual book carefully before installing and operating the

water heater for the first time.

Do not install the water heater in the bathroom.

Fit out a good quality of gas pressure reducer and the special gas

hose

Installing and using the water heater must be in accordance with

the requirements stipulated in these usage instructions.

Install a smoke exhaust duct to vent exhaust gas out of the room.

Make sure that the room where the water heater is installed has

enough fresh air and well-ventilated.

Once the outer wrapping and the inner wrappings of the various

parts have been removed, check and make sure that the appliance

is in perfect condition. If you have any doubts regarding to the

quality and the completion of the appliance accessories, do not use

this appliance yet and contact MODENA Customer Care.

This water heater must be installed by qualified technician.

In the case of a failure and/or malfunction, all repairs or settings

must be done with maximum care and attention by qualified

technicians. For this reason, we recommend you to contact

MODENA Customer Care; explaining the trouble in details; and

mention the name of the model.

The packaging materials used (such as cardboard, bags,

polystyrene foam, nails, etc.) must not be left anywhere in easy

reach for children because the packaging materials could

potentially cause a hazard. To safeguard the environment, all

packaging materials are environment-friendly and recyclable.

If there any questions about the operation procedure & the safety

instruction of this water heater, contact MODENA Customer Care.

PART 1: IMPORTANT SAFETY INFORMATION

Characteristics and Usage

This gas instant water heater can supply hot water quickly and

continuously, so it is suitable to provide hot water for bathing, washing

and other cleaning.

This type of water heater equipped with the following features:

1. Digital Display for displaying the hot water temperature.

NOTE

All pictures displayed in this manual are based on the standard

appearance of the gas instant water heater and only for

illustration. The actual appearance of this appliance is based on

purchased model.

PART 2: NAME OF PARTS

Remark:

1. Flame Observation Window

2. Water Volume Controller Knob

3. Battery Box

4. Cold Water Inlet

5. Hot Water Outlet

6. Gas Inlet

7. Flame Controller Knob

8. Water Temperature Display

2. Water Control Automatic Ignition: by simply open the water valve

and the igniter, this feature will ignite automatically and the hot

water will immediately be available.

3. Water Temperature Controller: adjust the water temperature as

needed.

4. Flue-type Exhaust Device: vent the exhaust gas out to keep the

indoor air fresh.

5. Water Temperature Display: provided with low battery indicator

function.

6. “Low Water Pressure” Start-Up: this water heater can be turned on

with low water pressure. This feature equipped with a wide range

of application.

7. Steady Water Volume: effectively avoid the impact of the water

pressure fluctuation on the water volume and the outlet water

temperature, as well as prevent the over-hot water output due to

high water pressure.

8. Flame-Out Safety: the water heater will automatically cut off the

gas if the flame accidentally flows out during the use period.

9. Water-Gas Linkage Controller: the water heater will automatically

stop the combustion and shut down if the water supply line is

blocked or the inlet valve is closed.

10. Over Pressure Protection: when the pressure of the water supply is

too high, the safety valve can automatically relieve the pressure to

avoid any damage to the water heater.

11. Thermal Protection: the water heater will automatically cut off the

gas and stop working when the temperature of the water output

exceeds 90 °C or dry-heating occurs.

12. Auto Cut-Off: the water heater will automatically cut off the gas

and power after 20 minutes of continuous operation. It can

continue to work after re-start.

Installation Requirement

1. Do not install this gas instant water heater in the bathroom.

2. Do not install the water heater in a place where the strong wind

occurs, otherwise the flame of the water heater will be blown out

or the combustion will be incomplete.

3. Do not install the water heater outside the room (without roof).

4. Do not install the water heater in the confined room. Install the

water heater in well-ventilated room with a volume more than 7.5

m3. There should be an air inlet with a cross section more than 0.06

m2 connected to the outdoor. The smoke exhaust pipe must also be

installed.

5. Install the water heater in a place where the line of human sight

and the flame observation window are in the same height that is

1.55 m - 1.65 m above the ground. The water heater also must be

far away from flammable materials.

PART 3: INSTALLATION

6. Do not place any opened power cord, electric appliances, or gas

pipeline above the installation site of the water heater. Keep a

horizontal distance more than 40 cm between the water heater and

other electric appliances. Do not install any gas appliance such as

gas oven and gas stove underneath this water heater.

7. Keep the distance more than 150 mm between the water heater, its

surrounding walls and the ceiling. Build the installation site/location

with non-combustible materials. Otherwise, insulate it with heat

insulating panel. The distance between the insulating panel and the

surrounding wall should be more than 10 mm.

Air Inlet

0.2 m

1.55 –1.65 m

0.3 m

>150 mm

8. Install an inlet valve to the water inlet pipe of the water heater.

9. Place the end of the smoke exhaust pipe outside the room.

10. For the liquefied petroleum gas (LPG) users, use the qualified gas

pressure regulating valves and hoses to ensure the water heater

could operates properly and be used safely. For pipeline gas users,

ask the gas company or the relevant management authority to

connect the gas pipe.

11. After the water heater is installed with a smoke exhaust pipe,

during the use, do not turn on any mechanical ventilation

equipment such as the smoke exhaust ventilator and the exhaust

fan in the room where the water heater is installed or to which the

water heater is connected.

Smoke Exhaust

Pipe

Water Heater

Water Outlet Pipe

Water Inlet Pipe

Air Inlet

Gas Inlet Pipe

(<2 m)

Inlet

Valve

Water Source

Outlet

Valve

Outlet

Valve

Shower

Installation Mode

a. Keep the water heater vertical and not tilt during the installation. As

shown in the below picture, drill the holes vertically on the wall for

the installation. Insert the expansion screws into the installation

holes on the top; and insert plastic plugs into the installation hole at

the bottom. After installing (mounting) the water heater, install

gaskets and nuts onto the expansion screws and screw up the

nuts. Screw on the

tapping

screw at the bottom. User can choose

A or B installation mode according to the situation.

NOTE

The connectors of the water heater in the picture shown above

would be in different order for different water heater model. Look

up to the real object for reference during installation process.

WARNING!

It is strongly forbidden to use this water heater with no smoke

exhaust pipe installed.

Expansion Screw

Tapping Screw

Plastic Plug

b. For the installation of smoke exhaust pipe, please pay attention the

following matters :

The water heater must be installed with smoke exhaust pipe

during the use. The pipe dimension refers to the ‘Specification’

section in this manual book. The smoke exhaust pipe should be

installed according to the requirements in this manual book.

Determine the length of the corrugated pipe as needed, but the

total height of the pipe should be more than 2 m, and the

horizontal length is no more than 3 m. The vertice quantity

should be no more than 2, and the angle is no less than 90° to

reduce the smoke exhaust resistance.

Fasten the corrugated pipe and the smoke vent of the water

heater with clamps to prevent exhaust gas being vented inside

the room.

Tilt the smoke exhaust pipe 3° outward and downward to

facilitate the outflow of condensate water.

Cover the smoke exhaust pipe with heat-insulating and fire-

proof materials which its thickness must be more than 20 mm.

Cover the pipe that is installed around the flammable wall.

Do not hide the smoke exhaust pipe inside the ceiling.

Otherwise, wrap up the pipe with heat-insulating material that

has more than 20 mm thickness. Make a distance more than

150 mm between the smoke exhaust pipe and flammable

materials (such as ceiling and furniture).

For maintenance, do not use cement to fill the gap between

smoke exhaust pipe and the access hole of the pipe on the

wall.

Installation Mode A

Installation Mode B

3°

Otros manuales para Rapido Series

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Calentador de agua de Modena

Modena

Modena Sano Series Manual del propietario

Modena

Modena Veloce Series Manual del propietario

Modena

Modena Tondo Series Manual del propietario

Modena

Modena Conesso Series Manual del propietario

Modena

Modena Rapido Series Manual del propietario

Modena

Modena Rapido Series Manual del propietario

Modena

Modena Rapido - GI 6 V Manual de usuario

Modena

Modena Sano Series Manual del propietario

Modena

Modena Quadra Series Manual del propietario

Modena

Modena GI 10 S Manual de usuario

Modena

Modena Tondo Series Manual del propietario

Modena

Modena EI 3D Series Manual de usuario

Modena

Modena Tondo - ES 50V Manual de usuario

Modena

Modena ES Series Manual de usuario

Modena

Modena Giorno Series Manual del propietario

Modena

Modena GI 6A V Manual de usuario

Modena

Modena Rapido Series Manual del propietario

Modena

Modena Veloce Series Manual del propietario

Modena

Modena Rapido Series Manual del propietario

Modena

Modena Sano Series Manual del propietario

Modena

Modena GI 0631 L Manual del propietario

Modena

Modena Casella Series Manual del propietario

Modena

Modena Unica Series Manual del propietario

Modena

Modena Casella Series Manual del propietario

Manuales populares de Calentador de agua de otras marcas

Kenmore

Kenmore 153.582400 Manual de usuario

Applimo

Applimo Edel AIR Manual de usuario

STIEBEL ELTRON

STIEBEL ELTRON Eltronom SHU 5 S Manual de usuario

clage

clage E-Mini Series Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-180 Manual de usuario

Bradford White

Bradford White EF Series Manual de usuario

Eccotemp

Eccotemp 40-H Manual de usuario

Dimplex

Dimplex ECSd125-580 Guía

Dux

Dux 32FCR6N Manual de usuario

Toyotomi

Toyotomi Oil Miser OM-148 (Type D) Guía de solución de problemas

Noritz

Noritz N-132M Manual de instrucciones

TESY

TESY GCV7/4S 10047 Hoja de especificaciones

A.O. Smith

A.O. Smith Gphe 50 Manual de usuario

Koryo

Koryo KWHZF15Y Manual de usuario

Pentair

Pentair PSC-14-4-02 Manual de usuario

GE 40M06AAG Instrucciones de montaje

Thermor

Thermor AEROMAX SPLIT 2 Manual de usuario

American Hometec

American Hometec AHQ-B03X Manual de usuario