MINOURA W-3100 Manual de usuario

Repairstand "W-3100" instructions manual

Tool Tray (option)

Back Knob

Clutch Release Lever

Upper Pillar

Lower Frame

Right Side Leg

Adjusting Screw

Clamp Adjust Knob

Clamp Lever

Clamp Jaws

Gear Clutch

Upper Pillar Holding Bolt

Lock Bolt

PARTS NAME

Left Side Leg

HOW TO ASSEMBLE W-3100 Required Tools: 1 x 13mm Spanner

1 x 6mm Hex Wrench

1 x 5mm Hex Wrench

Assemble both Legs to the Lower Frame with the supplied

M8x40 bolts and M8 Nylon Nuts.

M8x40 Cap Bolt

M8 Nylon nut

Place the assembled Lower Frame on the oor,

and check if every Adjusting Screw is touching the

oor perfectly.

If not, adjust the length of the Adjusting Screw then

tighten the lock nut rmly by a 13mm spanner.

This is very important to keep enough stability

while your bike is on the stand.

13mm spanner

Assemble the clamp jaw unit to the Upper Pillar.

The Back Knob should be tightened as rmly as

possible until the clamp jaws rotates smoothly.

Insert the assembled Upper Pillar into the Lower

Frame until the bottom cut-outs catch the Upper Pillar

Holding Bolt, then tighten the Lock Bolt rmly by a

5mm hex wrench.

To install the optional Tool Tray, insert the tray into

the Upper Pillar BEFORE assembling the frames.

Fix the position, then tighten the knob bolt.

Lock Bolt

HOW TO CLAMP YOUR BIKE

Pull down the Clamp Lever

to open the jaws.

12Place the top frame or the seat pillar

onto the lower jaw, then fully pull up the

Clamp Lever to close the jaws.

3Turn the Clamp Adjust Knob clockwise to

securely hold the bike.

Turning counter-clockwise will widen the

opening.

4To rotate the clamp jaws, push down the

Clutch Release Lever then rotate the jaws.

Release your nger after conrming the

ratch is securely engaged to the gear.

ABOUT OUR WARRANTY PROGRAM

You are covered under our warranty program for maximum 5 years from the date of your purchase.

Any defects caused by the manufacturer's mistake will be solved with this program at manufacturer's

expense, but any problem caused by the user's misuse or natural worn will not be supported by this

program.

Minoura does not owe any responsibility to any extra troubles these problems may bring.

For more detail, refer the attached "MINOURA LIMITED WARRANTY POLICY" card in the package.

(Maximum Load Capacity: 40 kgs / 90 lbs)

CONTACT INFORMATION

MINOURA NORTH AMERICA MINOURA JAPAN HEADQUARTERS

(for U.S. residents only) (for all other customers)

1996 East Ave. Hayward, CA 94541 U.S.A. 1197-1 Godo, Anpachi, Gifu 503-2305 Japan

Phone: 1-510-538-8599 Fax: 81-584-27-7505

Fax: 1-510-538-5899 Email: [email protected]

Email: [email protected] Web: www.minoura.jp

MADE IN JAPAN

W-3100 / SMALL PARTS LIST

C-3

C-4

C-11

C-6 C-7

C-8

P-4 P-3

C-9

C-10

C-11

P-1

T-4 T-2

P-5

P-8

P-9

L-9

L-3 L-4

L-3

L-4

L-10

L-11

P-7

C-4

L-11

C-3: Clamp Rubber

C-4: Lock Clip

C-6: Clamp Shaft

C-7: Clutch Packing

C-8: Clamp Space Collar

C-9: M8 Flat Washer

C-10: Back Knob

C-11: Clamp Jaws Assy

P-1: Upper Pillar

P-3: Clutch Release Lever

P-4: Pivot Screw

P-5: Pillar Cap

P-7: Upper Pillar Holding Bolt & Nut

P-8: Lock Bolt

P-9: Lower Frame

L-3: Leg End Cap

L-4: Adjusting Screw

L-9: Left Side Leg

L-10: Right Side Leg

L-11: M8x40 Bolt & M8 Nylon Nut

T-2: Tray Fixing Knob Bolt

T-4: Tool Tray w/ tool slots

Otros manuales de Rack y soporte de MINOURA

MINOURA

MINOURA DS-2200 Manual de usuario

MINOURA

MINOURA BIKE PIT Manual de usuario

MINOURA

MINOURA P-700X Manual de usuario

MINOURA

MINOURA FCG-310 - MANUAL 2 Manual de usuario

MINOURA

MINOURA DS-4000 Manual de usuario

MINOURA

MINOURA GRAVITYSTAND 2 Manual de usuario

MINOURA

MINOURA VERGO EXCEL Manual de usuario

MINOURA

MINOURA T-817 Manual de usuario

MINOURA

MINOURA RS-1200 Manual de usuario

MINOURA

MINOURA RS-1100 Manual de usuario

MINOURA

MINOURA BikeTower10 Manual de usuario

MINOURA

MINOURA LEVEL-170H Manual de usuario

MINOURA

MINOURA 971-3 Manual de usuario

MINOURA

MINOURA P-700X Manual de usuario

MINOURA

MINOURA BikeTower 20D Manual de usuario

MINOURA

MINOURA P-500AL-2 Manual de usuario

MINOURA

MINOURA RS-1600 Manual de usuario

MINOURA

MINOURA DW-2 Manual de usuario

MINOURA

MINOURA DS-110 DS-100H Manual de usuario

MINOURA

MINOURA DSX-1 Manual de usuario

MINOURA

MINOURA P-600AL Manual de usuario

MINOURA

MINOURA DS-520 - ASSEMBLY Manual de usuario

MINOURA

MINOURA RS-4000 Manual de usuario

MINOURA

MINOURA PAIR STAND Manual de usuario

Manuales populares de Rack y soporte de otras marcas

Salamander

Salamander Acadia AC/W/L400/WH Manual de usuario

Fohhn

Fohhn VAT-09 Guía del usuario

ricoo

ricoo FS0522 Manual de usuario

AMSOIL

AMSOIL BMK-22 Guía rápida

Kargo Master

Kargo Master 48220 Manual de usuario

Milestone AV Technologies

Milestone AV Technologies SIMPLICITY SLF2 Manual de usuario

ricoo

ricoo S1222 Manual de usuario

Ready-Set-Mount

Ready-Set-Mount RSMCM602 Manual de usuario

VidaBox

VidaBox VB MNT FFS2 Manual de usuario

Welch Allyn

Welch Allyn 48960 Manual de usuario

Arkon

Arkon CM035-ST-2 Manual de usuario

PROEL

PROEL PLWIN60C Manual de usuario

Agilent Technologies

Agilent Technologies E2609B Manual de usuario

Mustang

Mustang MV-ARM4 Manual de usuario

Mounting Solutions

Mounting Solutions WRM-320 Manual de usuario

Pyle

Pyle PMKSPAD1 Manual de usuario

ShelterIt

ShelterIt 21208 Manual de usuario

SPL

SPL RackPack?4 1040 Manual de usuario