MIMAKI JV3 Series Manual de usuario

1-2. Remove the two indicated screws and

remove the Head Cover Bracket.

1-4a. Loosen the two screws that secure the

Damper Holder Bracket, tilt up and remove.

1-5. Unplug the pair of FPC Cables from the

head you wish to replace and tuck cables

up out of the way. Using long-nose pliers as

shown, remove each of the two Dampers.

Be especially careful not to drip ink onto

FPC Cables or contacts on Head!

1-6.If replacing multiple Heads it is a good

idea to label the position of each Damper.

Newer models may already have a small

ID tag on each ink line. Take care not to

touch or damage the clear membrane on

back of Damper!

1-7. Tape ink lines and Dampers out of the

way. Lift off the plastic Damper Holder that

covers the head. Remove the hex screw

from front and rear of Head Adjusting Plate.

1-8. Wipe any ink from the damper projec-

tions. Grasp damper projection nearest to

you. Using tweezers or needle-nose pliers

to compress the spring, tip head forward

and lift to remove.

1-3. Use a coin to ensure that Head-Lock

Screws are tight then remove screws on

left and right ends of Head Lever Bracket.

Remove entire Head lever taking care not to

damage Head FPC Cables.

1. Removal of Damaged Print Head:

1-1. Ensure both power switches are off.

Move Carriage out over Platen by hand.

Remove indicated screws and remove Head

Cover.

1-4b. Left screw is accessed through this

opening in Head Bracket and Cutter Brack-

et.

Lift straight up

Important:

Water-based transportation liquid

(S-46), supplied in the head at the

time of shipment, reacts to solvent ink

and may cause clogging. Therefore,

it is necessary to wash the new head

before proceding with installation.

2-3. Insert hex screws in holes at front and

rear of Head Adjusting Plate.

2-4. Before installing new Head inspect the

area where Head will sit for any debris such

as dried ink. Clean with Solvent (SPC-0336)

if neccessary.

2-5. Grasping damper projection, place

Head in position. Install, but do not tighten

the front and rear hex screws.

2-2. Fill syringe with 6-8 cc of S-Head

Replacement Solution. Inject approx 3-4 cc

into each Damper Insertion Projection over

a period of about 30 seconds. Head can be

damaged if ﬂuid is injected too fast.

2. Installation of New Head:

2-1. Unpackage new head. Copy down the

new Head ID exactly as it appears on head.

1-9. Head and Adjusting Spring removed.

If head is covered by warranty, ﬂush, drain,

place rubber cap over nozzles and package

ready for return to Mimaki USA.

2-13. Perform a TEST DRAW to conﬁrm

that all nozzles are ﬁring correctly. Perform

additional Ink Fill Ups or Cleanings if nec-

cessary.

2-12. Perform an Ink Fill Up to ﬁll the new

Heads with ink (MAINTENANCE

 FILL

UP INK). As the printer is in Service Mode

you can choose just Pump 1 or Pump 2 if

desired.

2-8. Re-install the Dampers in their original

positions and ensure that they are prop-

erly seated. Re-install the Damper Holder

Bracket, the Head Cover Bracket and the

Height Adjustment Lever.

2.6. Grasp spring near onje end with needle-

nose pliers. Insert spring one end ﬁrst then

compress to complete installation. Lightly

tighten the front and rear hex screws.

2-7a. Thread Head FPC Cables back

through the Damper Holder. Cable HCN2

goes through the left slot and HCN1 through

the right. Blue side of cables face to the left.

2-7b. Connect the FPC cables, taking care

that they are seated correctly. A cable seat-

ed at and angle may short out, damaging

cable and head! Lower Damper Holder into

position.

2-11. Use the arrow keys to enter the new

Head ID. (#ADJUST HEAD ID). Ensure

that the correct Head is selected and all ID

values are entered correctly. Incorrect entry

will result in a error code.

2-10. Restore power to the printer and put

into Service Mode. (FUNCTION and RE-

MOTE keys are held as printer boots).

 



    

    

 

       



 





  





  



 







 







  



  

    

     

    

     





      

   

  

   

  



  

    

   



   

   



                   

                

                  

   

                  

      

              

                    

                 

                

         

        

                   

   

   

 

  



 

 

     









     

    

       

 

  

   



    

    







 

  

      

      

  





 

     

 

 

  

  



    

   

I 







   

 

  

 

    

    





 



 

  

    

   

   

           

                

                      

    

                 

   

                 

                  



           

    

 

 

 

















   

  

 







      

   

 



 

  

   













     













 

   

   

  













 

  

   

                               











           

                

                       

  

               

          

          

    

         

 

    

    



 

 

         

    

 

 

         

        

  

 

   

 

 

    

  



 

   





          

                

                      

    

                 

  

   

                 

 

 

 

 

 

  

   

      

       

Otros manuales para JV3 Series

Tabla de contenidos

Otros manuales de Impresora de MIMAKI

MIMAKI

MIMAKI UJF-7151 plus Manual de usuario

MIMAKI

MIMAKI JV33-260 Instrucciones de montaje

MIMAKI

MIMAKI JV400-130SUV Manual de usuario

MIMAKI

MIMAKI JFX 200-2513 Manual de usuario

MIMAKI

MIMAKI JV5-130S Manual de usuario

MIMAKI

MIMAKI TS55 Manual de usuario

MIMAKI

MIMAKI TX300P-1800 Manual de mantenimiento

MIMAKI

MIMAKI UJF-706 Manual de usuario

MIMAKI

MIMAKI CJV150-75/107 Manual de usuario

MIMAKI

MIMAKI JV300-130 A Manual de mantenimiento

MIMAKI

MIMAKI UJF-605R II Manual de usuario

MIMAKI

MIMAKI JFX500-2131 Manual de usuario

MIMAKI

MIMAKI UCJV300 Manual de usuario

MIMAKI

MIMAKI JV33-130BS Instrucciones de montaje

MIMAKI

MIMAKI UJF-A3MkII Series Manual de usuario

MIMAKI

MIMAKI UJV55-320 CMYK Manual de usuario

MIMAKI

MIMAKI JV400-130LX Guía de inicio rápido

MIMAKI

MIMAKI CJV300-130 Manual de mantenimiento

MIMAKI

MIMAKI T 300P-1800 Series Manual de mantenimiento

MIMAKI

MIMAKI JV400-LX Manual de usuario

MIMAKI

MIMAKI JF-1631 Manual de usuario

MIMAKI

MIMAKI JV330 Series Manual de mantenimiento

MIMAKI

MIMAKI Kebab MKII Manual de usuario

MIMAKI

MIMAKI JV400-SUV Series Manual de usuario

Manuales populares de Impresora de otras marcas

Lexmark

Lexmark 1400 Series Manual

Canon

Canon i70 Series Manual de usuario

Evolis

Evolis Elypso Manual de usuario

Kyocera

Kyocera FS-9530DN Manual de usuario

Canon

Canon LASER SHOT LBP-1210 Manual de usuario

Samsung

Samsung BIXOLON SRP-350plusF Manual de usuario

Canon

Canon PIXMA PRO-1 Series Manual de usuario

Canon

Canon PIXMA G3560 Guía de configuración

Dell

Dell Color Laser Printer 2130cn Manual de usuario

Tektronix

Tektronix Phaser 840 Manual de usuario

Epson

Epson ET-7750 Instrucciones de funcionamiento

Canon

Canon CLBR 460ps Manual de usuario

Eltron

Eltron P210 Guide Manual de usuario

Ricoh

Ricoh MD-P1 Manual de usuario

Epson

Epson SC-F7100 series Manual de usuario

Epson

Epson Stylus C40UX Manual de usuario

Canon

Canon imagePASS-A2 Manual de usuario

Canon

Canon S820D Manual de usuario