MGE UPS Systems Pulsar Evolution 1100 Tower Manual de usuario

Installation and user

manual

www.mgeups.com MGE UPS SYSTEMS

Pulsar Evolution

1500 Tower/1500 Rack

1100 Tower/1100 Rack

800 Tower/800 Rack

500 Rack

Page 2 - 3400723200/AC

MGE UPS Systems

1660 Scenic Avenue

Costa Mesa, CA 92626

(714) 557-1636

For service call

1-800-438-7373

www.mgeups.com

SAVE THESE INSTRUCTIONS. This manual contains important instructions for 89340-89346 that should be

followed during installation and maintenance of the UPS and batteries.

Thank you for selecting an MGE UPS SYSTEMS product to protect your electrical equipment.

The Pulsar Evolution range has been designed with the utmost care. We recommend that you take the time to read this man-

ual to take full advantage of the many features of your UPS.

MGE UPS SYSTEMS pays great attention to the environmental impact of its products. Measures that have made Pulsar

Evolution a reference in environmental protection include:

◗The eco-design approach used in product development,

◗recycling of Pulsar Evolution at the end of its service life.

To discover the entire range of MGE UPS SYSTEMS products and the options available for the Pulsar Evolution range, we

invite you to visit our web site at www.mgeups.com or contact your MGE UPS SYSTEMS representative.

This manual contains important instructions for Pulsar Evolution Models that must be followed during installation, operation

and maintenance of the UPS and batteries.

The Pulsar Evolution UPS Models that are covered in this manual are listed below.

Pulsar Evolution 500, 800, 1100, 1500

The normal battery voltage for all models is as follows:

Pulsar Evolution 500-12V, 800-24V, 1100-24V, 1500-36V

The Pulsar Evolution UPS is intended for installation in a temperature within 0 to 35º C (Pulsar Evolution from 500 to 1100

VA) or within 0 - 40º C for Pulsar Evolution 1500, free of conductive contaminants.

This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to Part 15 of the

FCC Rules. These limits are designed to provide reasonable protection against harmful interference when the equipment is

operated in a commercial environment. This equipment generates, uses, and can radiate radio frequency energy and, if not

installed and used in accordance with the instruction manual, may cause harmful interference to radio communications.

Operation of this equipment in a residential area is likely to cause harmful interference in which case the user will be required

to correct the interference at his own expense.

IMPORTANT SAFETY INSTRUCTIONS

Read before installing product

Note

3400723200/AC - Page 3

Introduction

CAUTION: Safety of persons

◗The UPS has its own internal power source (the battery). Consequently, the power outlets may be energized even if the UPS is

disconnected from the AC-power source.

◗Dangerous voltage levels are present within the UPS. It should be opened exclusively by qualified service personnel.

◗The UPS must be properly earthed. Measurements are required to ensure that the total leakage current of the UPS and the

protected equipment does not exceed 3.5 mA by checking their characteristics (maximum leakage current of the UPS = 2 mA).

◗The battery supplied with the UPS contains small amounts of toxic materials. To avoid accidents, the directives listed below

must be observed:

- Never burn the battery (risk of explosion).

- Do not attempt to open the battery (the electrolyte is dangerous for the eyes and skin).

- Comply with all applicable regulations for the disposal of the battery.

- Batteries constitute a danger (electrical shock, burns). The short-circuit current may be very high. Precautions must be

taken for all handling: remove watches, rings, bracelets and any other metal objects, use tools with insulated handles.

- Do not lay tools or metal parts on top of batteries.

CAUTION: Product safety

◗The UPS connection instructions and operation described in the manual must be followed in the indicated order.

◗UPS must be connected to a nearby wall outlet that is easily accessible. The UPS can be disconnected from the AC-power

source by removing the power cord.

◗Check that the indications on the rating plate correspond to your AC-power system and to the actual electrical consumption of

all the equipment to be connected to the UPS.

◗Never install the UPS near liquids or in an excessively damp environment.

◗Never let a foreign body penetrate inside the UPS.

◗Never block the ventilation grates of the UPS.

◗Never expose the UPS to direct sunlight or source of heat.

◗If the UPS must be stored prior to installation, storage must be in a dry place.

◗The admissible storage temperature range is -25ºC to +55ºC.

Special precautions

◗All handling operations will require at least two people (unpacking, installation in rack system).

◗Once installed and connected to the AC power source for the first time, the battery will start to charge. Full charging to obtain

the rated battery backup time requires at least 8 hours.

◗Before and after the installation, if the UPS remains de-energized for a long period, the UPS must be energized for a period of

24 hours, at least once every 6 months (for a normal storage temperature less than 25°C). This charges the battery, thus

avoiding possible irreversible damage. During the replacement of the battery module, it is imperative to use the same type and

number of element previously mounted in the UPS, in order to maintain an identical level of performance and safety. In case of

doubt, don’t hesitate to contact our after sales department (for more information, refer to the web site www.mgeups.com).

Page 4 - 3400723200/AC

Foreword

Using this document

Important instructions that must always be followed.

Information, advice, help.

Visual indication.

Action.

Audio indication.

In the illustrations on the following pages, the symbols below are used:

LED off.

LED on.

LED flashing.

Information may be found in two ways, using:

◗the contents;

◗the index.

Pictograms

3400723200/AC - Page 5

Contents

1. Presentation

1.1 Overall view.................................................................................................................................. 7

Tower models ..................................................................................................................................7

Rack models ....................................................................................................................................7

1.2 Back .............................................................................................................................................. 8

1.3 Control panel..................................................................................................................................9

2. Installation

2.1 Unpacking and parts check ......................................................................................................10

Tower models ................................................................................................................................10

Rack models ..................................................................................................................................11

2.2 Installation ....................................................................................................................................12

Tower models ................................................................................................................................12

800/1100/1500 Rack models..........................................................................................................13

500 Rack model ............................................................................................................................14

2.3 Connecting the protected equipment ........................................................................................15

2.4 Connection to the RS232 or USB communications port (optional) ........................................16

2.5 Connection to the data-line protection port (optional)..............................................................16

2.6 Installation of the communications-card option ......................................................................17

3. Operation

3.1 Start-up..........................................................................................................................................18

3.2 Shift to booster or fader mode (during voltage variations in the AC-input power) ....................18

3.3 Operation on battery power (following failure of AC-input power) ............................................19

Transfer to battery power ..............................................................................................................19

Threshold for the low-battery warning............................................................................................19

3.4 Personalization (optional) ............................................................................................................20

Function..........................................................................................................................................20

ON / OFF conditions tab................................................................................................................20

Battery tab......................................................................................................................................20

Voltage-thresholds tab ..................................................................................................................21

Sensitivity tab ................................................................................................................................21

Page 6 - 3400723200/AC

Contents

4. Maintenance

4.1 Trouble-shooting..........................................................................................................................22

4.2 Replacement of the battery module ..........................................................................................23

Tower models ................................................................................................................................23

Rack models ..................................................................................................................................25

5. Environment ....................................................................................................................................27

6. Appendices

6.1 Technical data

Simplified diagram..........................................................................................................................28

Technical characteristics ................................................................................................................29

Examples of battery backup times ................................................................................................30

6.2 Glossary........................................................................................................................................31

6.3 Index..............................................................................................................................................32

3400723200/AC - Page 7

1. Presentation

1.1 Overall view

Tower models

Rack models

P U L S A R

Evolution

1 1 0 0

P U L S A R

Evolution

1500 Rack

Dimensions in inches

(W x H x D)

Evolution 800 Tower 5.9 x 9.3 x 16.3

Evolution 1100 Tower 5.9 x 9.3 x 16.3

Evolution 1500 Tower 5.9 x 9.3 x 19

Weight in lbs

Evolution 800 Tower 23

Evolution 1100 Tower 25.4

Evolution 1500 XL Tower

Dimensions in inches

(W x H x D)

Evolution 500 Rack

17.2 (19”) x 1.7 (1U) x 13.9

Evolution 800 Rack

17.2 (19”) x 1.7 (1U) x 19.6

Evolution 1100 Rack

17.2 (19”) x 1.7 (1U) x 19.6

Evolution 1500 Rack

17.2 (19”) x 1.7 (1U) x 20.5

Weight in lbs

Evolution 500 Rack 20

Evolution 800 Rack 34

Evolution 1100 Rack 35

Evolution 1500 Rack 42

Page 8 - 3400723200/AC

3.7

36Vdc,9Ah

ACOutput

ACInput Volt 120V~1O

Hertz 50/60Hz

Amps 12AMAX

Volt 120V~1O

W/VA 1000W/1440VA

U.P.S.

34Z5

Vac IN

RS232

T20A/125V~

Programmable

Data line protection

344-50248-00

SITE WIRING

FAULT

U.S. PAT. No. 6,094,363

IN OUT

Vac OUT I max 12A

1. Presentation

1.2 Back

Pulsar Evolution 500 / 800 / 1100 Rack

USB communications port.

RS232 communications port.

Data-line protection.

Slot for communications-card option.

Receptacle for direct connection of

protected equipment.

Programmable receptacles (1 and 2).

Input circuit-breaker.

Connection to the utility.

238 45

Pulsar Evolution 800 / 1100 / 1500 Tower

Hertz 50/60 Hz

W/VA 1000W/1440VA

Ausg

Hertz 50/60 Hz

Amps 12AMAX

Netz

Util

Load

Mains

Reseau

Volt 120V~1O

36Vdc,9Ah

U.S. PAT. NO. 6,094,363

Programmable

Vac OUT

I max 12A

U.P.S.

34Z5

Vac IN

SITE WIRING

FAULT

Data line protection

T20A/125V~

RS232

344-50254-00

INOUT

Pulsar Evolution 1500 Rack

2384 5

Pulsar Evolution:

3400723200/AC - Page 9

1.3 Control panel

Bargraph indicating percent load at output.

Group 1 programmable receptacles supplied with power.

Illuminated ON/OFF button for the receptacles.

Group 2 programmable receptacles supplied with power.

Operation on battery power.

1. Presentation

UPS fault.

Battery fault.

Overload.

Booster or fader mode.

Bargraph indicating the battery charge level.

0 to 25%.

26 to 50%.

51 to 75%.

76 to 100%.

P U L S A R

Evolution

1 1 0 0

Page 10 - 3400723200/AC

2. Installation

2.1 Unpacking and parts check

RS232 communications cable for Windows Operating Systems. For Unix/Linux Operating Systems, please order for

free the following part number: 66090

USB communications cable.

CD-ROM with the Solution-Pac and UPS Driver software.

Product documentation.

2220

Tower models

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Unión Postal Universal de MGE UPS Systems

MGE UPS Systems

MGE UPS Systems EXL 1000 Manual de usuario

MGE UPS Systems

MGE UPS Systems GALAXY PW 100 Manual de usuario

MGE UPS Systems

MGE UPS Systems PowerServices TelPac Manual de usuario

MGE UPS Systems

MGE UPS Systems Comet Series Manual de usuario

MGE UPS Systems

MGE UPS Systems Pulsar EX10Rack Manual de usuario

MGE UPS Systems

MGE UPS Systems EX 11RT Manual de usuario

MGE UPS Systems

MGE UPS Systems Comet EX RT 5 kVA Manual de usuario

MGE UPS Systems

MGE UPS Systems Comet TM 5 - 30 kVA Manual de usuario

MGE UPS Systems

MGE UPS Systems Pulsar Evolution 1500 Manual de usuario

MGE UPS Systems

MGE UPS Systems Pulsar EXtreme 2200C Manual de usuario

MGE UPS Systems

MGE UPS Systems 250A Manual de usuario

MGE UPS Systems

MGE UPS Systems Ellipse 600 Manual de usuario

MGE UPS Systems

MGE UPS Systems EX 5 Manual de usuario

MGE UPS Systems

MGE UPS Systems PULSAR EVOLUTION 2200 Manual de usuario

MGE UPS Systems

MGE UPS Systems 2000 Manual de usuario

MGE UPS Systems

MGE UPS Systems 2200 RT 2U Manual de usuario

MGE UPS Systems

MGE UPS Systems Evolution 2000 RT 2U Manual de usuario

MGE UPS Systems

MGE UPS Systems PULSAR EVOLUTION 3000 XL Manual de instrucciones

MGE UPS Systems

MGE UPS Systems Upsilon STS 800A Manual de usuario

MGE UPS Systems

MGE UPS Systems PULSAR ELLIPSE 500 Manual de usuario

MGE UPS Systems

MGE UPS Systems Pulsar Esprit 313.5 kVA Manual de usuario

MGE UPS Systems

MGE UPS Systems EPS 6000 Manual de usuario

MGE UPS Systems

MGE UPS Systems Galaxy PW 30 kVA Manual de usuario

MGE UPS Systems

MGE UPS Systems Pulsar EX20 Manual de usuario

Manuales populares de Unión Postal Universal de otras marcas

Pylontech

Pylontech Victron & Pylontech US5000 Manual de usuario

Tecnoware

Tecnoware EVO DSP PLUS MM 6.8 Manual de usuario

Mecer

Mecer ME-1000-WTU Manual de usuario

Mustek

Mustek PowerMust 530(B) Plus Manual de instalación y operación

Emerson

Emerson Liebert NXL series Manual de usuario

MAKELSAN

MAKELSAN BOXER SERIES Manual de usuario

Block

Block PC-0524-400-0 Manual de usuario

CyberPower

CyberPower CP585LCD Manual de usuario

Eaton

Eaton 3S Instrucciones de montaje

CyberPower

CyberPower Office Tower Series UPS 1000 Manual de usuario

CyberPower

CyberPower BM100 Manual de usuario

Best Power

Best Power 610 Manual de usuario

Best Power

Best Power Unity/I UT3K Manual de usuario

Mustek

Mustek PowerMust 400 Offline Manual de usuario

Xantrex

Xantrex Trace 512 UR-UPS Manual de usuario

Forza

Forza SL-1501UL Manual de usuario

LEGRAND

LEGRAND keor 310081 Manual de usuario

ABB

ABB Conceptpower DPA 500 Manual de usuario