Manitowoc BG0260 Manual de usuario
Technician’s
Handbook
This manual is updated as new information and models are released.
Visit our website for the latest manual. www.manitowocfsg.com
America’s #1 Selling Ice Machine
BG0260
Spray Cube
Part Number STH48 6/15
General Information
Model Numbers ...................................5
BG0260A .............................................5
Model/Serial Number ...........................5
Manitowoc Cleaner and Sanitizer ........5
Installation
Location of Ice Machine ......................7
Installation Requirements ....................7
Potable Water Requirements ..............8
Drain Connections ...............................8
Ice Machine Clearance Requirements 8
Electrical Service .................................9
Operation
Ice Making Sequence of Operation .........11
Thermostat settings .............................13
Maintenance
Cleaning & Sanitizing Procedure .........16
Cleaning the Condenser .....................20
Removal from Service/Winterization ...21
Troubleshooting
Electrical Flowcharts ................................23
Electrical Flowchart Ice Machine Will Not
Run ......................................................24
Will Not cycle Into Harvest ...................28
Prematurely Cycles Into Harvest .........31
Refrigeration Troubleshooting ................34
Ice Production/Quality Check ..............35
Component Specifications
Thermostat Settings ............................41
Fan Cycle Control Settings ..................41
Total System Refrigerant Charge ........41
Filter-Driers ..........................................42
Suction Cleanup Filter-Drier ................42
Charts
Cycle Times/24-Hour Ice Production/
Refrigerant Pressure Charts ....................43
BG0260A .............................................44
Diagrams
Wiring Diagram .........................................45
BG0260 ...............................................46
Refrigeration Tubing Schematics ...........47
Part Number STH48 6/15 5
General Information
MODEL NUMBERS
BG0260A
MODEL/SERIAL NUMBER
These numbers are required when requesting
information from your local Manitowoc Distributor, or
Manitowoc Ice. The model and serial number are
listed on the MODEL/SERIAL NUMBER DECAL
affixed to the ice machine.
MANITOWOC CLEANER AND SANITIZER
Manitowoc Ice Machine Cleaner and Sanitizer are
available in 16 oz. (473 ml) bottles. These are the only
cleaners and sanitizer approved for use with
Manitowoc products.
Cleaner Part Number Sanitizer Part Number
16 oz. 000000084 16 oz. 9405653
1 gal N/A 1 gal. 9405813
Part Number STH48 6/15 7
Installation
LOCATION OF ICE MACHINE
The location selected for the ice machine must meet
the following criteria. If any of these criteria are not
met, select another location.
• The location must be free of airborne and other
contaminants.
• The location must not be near heat-generating
equipment or in direct sunlight.
• The location must be capable of supporting the
weight of the ice machine and a full bin of ice.
• The location must allow enough clearance for
water, drain and electrical connections in the rear
of the ice machine.
• The location must not obstruct airflow through or
around the ice machine.
INSTALLATION REQUIREMENTS
• The air temperature must be at least 50°F (10°C),
but must not exceed 110°F (43°C).
• The water temperature must be at least 50°F
(10°C), but must not exceed 100°F (38°C).
• The ice machine and bin must be level
• Vent the ice machine and bin drains separately
• Bin drain termination must have an air gap
• A back flow preventer is required on water inlet
lines
• Routine adjustments and maintenance procedures
outlined in this manual are not covered by the
warranty.
8 Part Number STH48 6/15
POTABLE WATER REQUIREMENTS
• Plumbing must conform to local codes
• Do not connect the ice machine to a hot water
supply. Be sure all hot water restrictors installed for
other equipment are working. (Check valves on
sink faucets, dishwashers, etc.)
• If water pressure exceeds maximum pressure (6
bar) obtain a water pressure regulator from your
Manitowoc distributor.
• A union for both the ice making and condenser
water lines is required
• Water inlet lines require insulation to prevent
condensation.
DRAIN CONNECTIONS
• Drain lines must have a 1.5 inch drop per 5 feet of
run (2.5 cm per meter), and must not create traps
• The floor drain must be large enough to
accommodate drainage from all drains.
• Separate insulated bin and water-cooled
condenser drain lines are required
• The bin and ice machine drains require a vent.
ICE MACHINE CLEARANCE REQUIREMENTS
Air-Cooled Water-Cooled
Top/Sides 5" (13 cm) 5" (13 cm)
Back 8" (20 cm) 8" (20 cm)
Part Number STH48 6/15 9
ELECTRICAL SERVICE
Voltage
The maximum allowable voltage variation is ± 10% of
the rated voltage on the ice machine model/serial
number plate at compressor start-up.
Fuse/Circuit Breaker
A separate fuse/circuit breaker must be provided for
each ice machine.
Ground Fault Interrupter Circuit (GFIC)
A GFCI/GFI circuit protection is not recommended
with our equipment. If a GFCI/GFI is required by code
a GFCI/GFI breaker rather than outlet must be used to
avoid intermittent nuisance trips.
!
Warning
All wiring must conform to local and national codes.
!
Warning
The ice machine must be grounded in accordance
with national and local electrical codes.
Tabla de contenidos
Otros manuales de Máquina de hielo de Manitowoc
Manitowoc
Manitowoc NEO UR0310AE Instrucciones generales
Manitowoc
Manitowoc MAC 6 K058 Manual de usuario
Manitowoc
Manitowoc QC0700 Manual de usuario
Manitowoc
Manitowoc ICE DEFLECTOR K00382 Manual de usuario
Manitowoc
Manitowoc S model Instrucciones de uso
Manitowoc
Manitowoc CNF201 Instrucciones de instalación y funcionamiento
Manitowoc
Manitowoc QM30 Series Manual de usuario
Manitowoc
Manitowoc FEMALE COUPLING KIT K00129 Manual de usuario
Manitowoc
Manitowoc Indigo Series Manual de usuario
Manitowoc
Manitowoc UG Series Manual de usuario
Manitowoc
Manitowoc Sotto UG-40 Manual de usuario
Manitowoc
Manitowoc ArcticPure AR-Pre Manual de usuario
Manitowoc
Manitowoc S model Manual de usuario
Manitowoc
Manitowoc GR-0800A Manual de usuario
Manitowoc
Manitowoc Indigo Series Manual de usuario
Manitowoc
Manitowoc Indigo Series Manual de usuario
Manitowoc
Manitowoc NEO UD0140A Instrucciones de instalación y funcionamiento
Manitowoc
Manitowoc QC0700 Instrucciones de uso
Manitowoc
Manitowoc SM Instrucciones de uso
Manitowoc
Manitowoc S1000M Manual de instrucciones y seguridad
