MacDon M Series Manual de usuario

The harvesting specialists.

M-Series

Self-Propelled Windrower

Unloading and Assembly Instructions (Container Shipments)

147962 Revision A

2017 Model Year

Original Instruction

Featuring the Dual Direction®and Ultra Glide®suspension on the M155 and M205.

Published in August, 2016

Introduction

This instruction manual describes the unloading, setup, and predelivery requirements for the MacDon M-Series

Self-Propelled Windrowers shipped in containers.

Carefully read all the material provided before attempting to unload, assemble, or use the machine.

Retain this instruction for future reference.

Conventions

The following conventions are used in this document: Right- and left-hand are determined from the operator’s

position. The front of the windrower is the side that faces the crop.

NOTE:

Keep your MacDon publications up-to-date. The most current version can be downloaded from our Dealer-only

site (https://portal.macdon.com) (login required).

This instruction is also available in Russian and can be downloaded from our Dealer-only site.

147962 iRevision A

EC Declaration of Conformity—Windrower Lift Sling

Figure 1: EC Declaration of Conformity – Windrower Lift Sling (Page 1 of 2)

147962 ii Revision A

Figure 2: EC Declaration of Conformity – Windrower Lift Sling (Page 2 of 2)

147962 iiiRevision A

EC Declaration of Conformity—Windrower Assembly Supports

Figure 3: EC Declaration of Conformity – Windrower Assembly Supports (Page 1 of 2)

147962 iv Revision A

Figure 4: EC Declaration of Conformity – Windrower Assembly Supports (Page 2 of 2)

147962 vRevision A

List of Revisions

The following list provides an account of major changes from the previous version of this document.

Summary of Change Location

Changed measurement format so that metric

measurements appear ﬁrst followed by imperial in

parenthesis.

Revised ﬁgure titles for clarity.

Corrected general grammar and punctuation.

Throughout the book

Added paragraph stating that this instruction is also

available in Russian. Introduction, page i

Updated declarations of conformity. •EC Declaration of Conformity—Windrower Lift Sling,

page ii

•EC Declaration of Conformity—Windrower

Assembly Supports, page iv

Added new section for battery safety. 1.3 Battery Safety, page 4

Added footnote to lift sling part number stating that it is

not sold separately. •2.2.1MovingtoAssemblyArea: CraneMethod,page

•3.2.1 Lifting Windrower onto Stand: Crane Method,

page 28

Updated illustrations to show new battery hold-down. •3.7 Removing Battery Shipping Shield, page 61

•3.13.1 Connecting Batteries on an M205 or M155,

page72

Corrected step to attach red positive cable terminals to

positive posts (C), which was erroneously referenced

as (A).

3.13.2 Connecting Batteries on an M105, page 73

Removed reference to M200 and extra hose in the

Note under Step 2. 3.6.2 Installing Hydraulics on an M155, page 43

Updated procedure to show location of fuse box. 3.8 Unpacking Ignition Keys, page 62

Updated illustration to show new safety prop handle

and decal.

Reorganized sections for clarity.

Throughout 3.21 Attaching Headers, page 97

Added Hydraulic Union kit (MD #166844) to table of

kits that may be required to attach a D-Series Header

to an M205 Self-Propelled Windrower.

3.21.2 Attaching a D-Series Header, page 98

Added note recommending 18.4 x 26 drive tires when

attaching 13-ft R85 headers to the M155 or M205. 3.21.4 Attaching an R-Series Header, page 132

147962 vi Revision A

Summary of Change Location

Added new cross-reference and section for ﬂuids,

lubricants, and system capacities. •3.22 Lubricating the Windrower, page 150

•5.2 Checking and Adding Wheel Drive Lubricant

Level, page 321

•6.4 Lubricants, Fluids, and System Capacities, page

374

Revised Note regarding cab display module and

windrower control module software to clarify software

version compatibility with different M-Series windrower

models.

4.2 Cab Display Options, page 156

Revised Notes speciﬁc to the M105 for clarity. •4.4.9 Setting the Header Index Mode, page 196

•4.7.3 Displaying Header Sensor Input Signals, page

260

Corrected references in Steps 7 and 8 from callouts C

and D to callouts A and B. •4.8.3 Testing the Header Tilt Activate Function Using

the Cab Display Module (CDM), page 278

•4.8.7 Testing the Reel Fore-Aft Activate Function

Using the Cab Display Module (CDM), page 288

Replaced arrows showing serial number locations with

callouts. 5.1 Recording Serial Numbers, page 319

Updated illustration to show new gearbox cover. 5.8 Checking Gearbox Lubricant Level on an

M155/M205, page 330

Corrected broken links to Table 5.5 Knife Speed

Setting, page 352.•Setting Knife Speed, page 352

•Adjusting Knife Speed, page 353

Replaced M105 Operator Console illustration to show

header drive switch. 5.11.8 Checking Operator's Presence System, page

341

Added new section for tapered pipe ﬁttings. 6.1.8 Tapered Pipe Thread Fittings, page 369

Added new terms and acronyms. 6.3 Deﬁnitions, page 371

Added new section for fuel speciﬁcations. 6.5 Fuel Speciﬁcations, page 378

147962 viiRevision A

Otros manuales para M Series

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Maquinaria agrícola de MacDon

MacDon

MacDon A30-S Manual de usuario

MacDon

MacDon DWA Guía

MacDon

MacDon A30-S Manual de usuario

MacDon

MacDon 802 Manual de usuario

MacDon

MacDon Swath Compressor Guía

MacDon

MacDon D1X Series Manual de usuario

MacDon

MacDon M155E4 Manual de usuario

MacDon

MacDon FD75 Manual de usuario

MacDon

MacDon NEW HOLLAND D2 Series Manual de usuario

MacDon

MacDon R113 Manual de usuario

MacDon

MacDon A30-S Manual de usuario

MacDon

MacDon FlexDraper FD1 Series Manual de usuario

MacDon

MacDon D65 Manual de usuario

MacDon

MacDon R80 Manual de usuario

MacDon

MacDon R2 Series Manual de usuario

MacDon

MacDon M155 Manual de usuario

MacDon

MacDon D65 Manual de usuario

MacDon

MacDon M105 Manual de usuario

MacDon

MacDon DWA Guía

MacDon

MacDon R113 Manual de usuario

MacDon

MacDon M105 Manual de usuario

MacDon

MacDon R85 Manual de usuario

MacDon

MacDon A40-D Manual de usuario

MacDon

MacDon R116 Manual de usuario

Manuales populares de Maquinaria agrícola de otras marcas

GSi

GSi PNEG-2314 Manual de usuario

Checchi & Magli

Checchi & Magli TEXDRIVE Manual de usuario

Amazone

Amazone Cenius 4003-2TX Manual de usuario

MASSEY FERGUSON

MASSEY FERGUSON MF 9313S Manual de usuario

Cima

Cima BLITZ Instrucciones de funcionamiento y mantenimiento

Amazone

Amazone CombiDisc 3000 Instrucciones de instalación

HE-VA

HE-VA Disc-Roller XL Contour Manual de usuario

AGT

AGT AGT-SSFM Manual de usuario

Milestone

Milestone 72-84 Manual de usuario

KUHN

KUHN Hector 3000 Manual de usuario

Krone

Krone X-Disc 6200 Manual de usuario

Eliet

Eliet DZC450 Manual de usuario

Taarup

Taarup BIO+ B4000 Manual de usuario

Garland

Garland SHAKER 310 DPG Manual de usuario

stable comfort

stable comfort StableWall System Manual de usuario

Raven

Raven AccuBoom Manual de usuario

International

International 710 Manual de usuario

Ashland

Ashland HDW-3217-14 Manual de usuario