Look Solutions Orka deLuxe Manual de usuario

a Look Solutions product

Operating manual

orka

deluxe

Set of Equipment supplied

– 1OrkadeLuxe

– 1tanklidwithquickconnector,silicontubeandairvalvelter

– 1Operatingmanual

 Pleasecheckwhetheralltheproductsyouorderedaresupplied.

Originaloperatingmanual,version01/2023

Content

1. Introduction 4

2. Safety instructions 5

3. Description of the parts 6

4. Fluid 8

 4.1GeneralNotes

 4.2Rellingtheuidcontainer

5. Operating the Orka deLuxe9

 5.1Selectingthelocation 9

 5.2Puttingintooperation 9

 5.3Switchingthedeviceo 10

 5.4ControlviaDMX512 10

 5.4.1AdjustingtheDMXstartaddress

 5.4.2RDM

 5.5Standalonemode 11

 5.6Wiringofthesockets 11

6. Cleaning, Care and Maintenance12

7. Troubleshooting 13

8. Specications 14

9. Warranty Conditions 15

1. Introduction

TheOrka deLuxeisprobablythemostpowerfultouringmachineonthemarket.

Builtintoarobustightcasewithapowerfulfan,theOrka deLuxeisreadyforanyuse.

Newfeaturesmakeiteveneasiertouse-placingandfoggingwithoutwastingalotof

timesettingandpreparing.

Thenew20Lattankcanbelledconvenientlyandeasily,guaranteeingalongerope-

ratingtime.

Thecastordishesallowforeasyandsafestackingandstowingoftheequipment.

Theperformanceofthemachineallowsapplicationsfromclubstolargehalls,festivals,

stadiumsandevents,aswellasuseforairoworleaktestinginlargebuildingsandtunnels.

Theintendeduseofthedeviceistocreatearticialfog.

2. Safety instructions

• Veryhotsteamescapesfromthenozzle.Dangerofgettingburnt.

• Occasionallyveryhotdropletsofuidmayescapewheninoperation.Thusneveraimat

personsdirectlyandkeepaminimumdistanceof3mtothenozzle.

• Nevertouchthenozzlewheninoperation.Dangerofgettingburnt.

• Thelocationforthemachinemustbenon-ammable,non-combustibleandnotsensitive

toheat.Ithastobetwiceasbigasthemachine.

• Keepaminimumdistanceof60cmtoallammable,combustibleobjectsandobjects

sensitivetoheat.

• Glycolisalcoholandburnswithaslightlybluish,almostinvisibleame.Neverpointthe

fogatstrongsourcesofignitionlikereorpyrotechniceects.

• Neveropenthemachineandleavethemachineunattendedwhenconnectedtoapower

supply.

• Itisonlyallowedtoy/hangthemachinebyusingtheoriginalhangingset.

• Thevisibilityhastobemorethan2minroomswherepeoplewalkaround.

• Donotswallowthefoguid.Keepitawayfromchildren.Incaseofeyecontact,rinse

withalotofwater.Consultadoctorshouldyouhaveaccidentallyswallowedsomeuid.

• Spilleduidorsplasheduiddropletscancausesliphazard.Mopuptheuidanddispose

ofitaccordingtoregulations.

• Fogmayactivatesmokedetectors.

Articially-madefogcanbeproducedinmanydierentways.Themethodusedhereto

producefog,withadevicewhichworksaccordingtothevaporizerprinciple,isthemost

harmlessone.

Nocasehassofarbeenreportedinwhichasoundhumanbeinghasbeenharmedbecause

ofusingourdevicetoproducearticialfog.However,thiscanonlybeguaranteedifthe

professionalfoggeneratorsareusedaccordingly,i.e.atthecorrectvaporizationtemperatures

aswellaswiththecorrectlymixedfoguid.

We,however,recommend:People with health problems or problems of the respiratory

tract or with an inclination for allergies should avoid any contact with articially-made fog.

A fog machine is not a toy!

3. Description of the parts

Rear view

1:Fognozzle

2:Diverter

3:Fangrilleandfan

4:Carryinghandles

5:Filter

6:Castordishes

7:Automaticwheels

Control-Box

Connectorsfromlefttoright:

•DMX in (5pin)

•DMX out (5pin)

•Power in: Powersupplyforcontrolbox(connectedwhensupplied)

•Power out: 1xforfogmachineand1xforfan(alreadyconnectedwhensupplied)

•Analog out (Fog): Fogmachine(alreadyconnectedwhensupplied)

•Analog out (Fan): Fan(alreadyconnectedwhensupplied)

XXX= address · PXX = pump · FXX = fan

dmxin

active

power in

in out

dmx 512 power out power out analog out

(FOG)

analog out

(FAN)



~

~

orka



Look Solutions



    

  

 

     

    



deluxe

Front view

3. Description of the parts

13

Tank lid

Plasticspigot

Quickcoupling

Tanklid

Filter

12:

13:

14:

15:

8:Control-Box

9:Cableoutlet

10:CEE-plug

11:20L-Fluidtank

12:Velcrotapeto

 securethetank

Rear view

4. Fluid

4.2 Relling the uid tank

– Disconnectthetanklidbypressingthespringsinthengerrecessesinwardsandliftout

thecover.

– Disconnecttheuidtubefromthelidbypressingthequickcoupling[13]andremoving

theplasticspigot[12].

– LoosentheVelcroandtiltthecanisterabout45degrees.

– Torell,unscrewthelargebluecapfromthecanisterandllthetankwithuid.

– TiltthecanisterbackinanuprightpositionandtightenitwiththeVelcrostrap.

– Pushtheplasticspigot[12]intothequickcoupling[13],untilyouhearaclick.Thespigot

isnowlockedrmly.

4.1 General notes

Beforerellingtheuidcanister,makesurethattherearenoimpuritiesinsidethetank.

Ifnecessary,thecanistermustberinsedout.Thiswillpreventcloggingoftheheater.

TheOrka deLuxe hasbeendesignedtobeusedwithoriginalLookfoguids.

ThefollowingLookfoguidsareavailable:

Quick-Fog  thick,quickdisappearingfoguid

Regular-Fog  thick,longlastingfoguid

Slow-Fog  thick,extremelylonglastingfoguid

IfuidshavebeenusedotherthanLookfoguidswecan‘tgrantwarranty.

PLEASE NOTE:Thevaporizerof our machinesdoesnothavetobe cleaned! Cleaners,

availableonthemarket,candamagethevaporizer!Wecannotgrantwarrantyinthiscase.

5. Operating the Orka deLuxe

5.2 Putting into operation

Removethefrontcasecover.Therearcovercanremainonthecase.Simplyreleasethe

upperpartbypressingthespringsinthengerrecessesinwardandfoldingthecoverdown.

Thecontrolboxcanthenbeoperatedwithoutanyproblems.Theconnectionsforthefog

generatorandfanarealreadyconnectedtothecontrolbox.

XXX= address · PXX = pump · FXX = fan

dmxin

active

 Upbutton

Downbutton

Pleasenote:TheModebuttonisnotsuitablefor„scrolling“throughthemenu.Itmustbe

pressedbrieyoneatatime.

EnterbuttonModebutton

Active-LED

DMX-LED

a. Connectthe16ACEEcablewitha16ACEEfeedercable.

 InthedisplayofthecontrolboxappearseitherthelaststoredDMXaddress(ifthedevice

isconnectedviaDMX)oraPandtwonumbers(seegureabove).

5.1 Selecting the location

ThelocationinwhichtheOrka deLuxeisoperatedshould

– bedry,

– befreefromdustyorpollutedair,

– befreefromvibrations,

– beannon-ammableplaceorsurface,

– bewell-ventilatedwithfog-freeairkeepingtheambientoperatingtemperaturebetween

5°Cand45°Candtherelativeairhumiditybelow80%.

5. Operating the Orka deLuxe

5.3 Switching the device o

a. PresstheModebuttonuntil„OFF”appearsonthedisplay.After15secondsthemachine

willswitchoautomatically.Ontherightbottomedgeofthedisplayareddotwillappear,

indicatingthatthemachineisnotheatinganymore.

 Youcanalsoswitchothemachinewithinthese15secondsbypressingthe

 Enterbutton.

b. IftheDMXsignalislost,thedevicewillbeswitchedoautomaticallyafter15seconds

forsafetyreasons.

5.4 Operating via DMX 512

ConnecttheOrka deLuxetoaDMX-deskusingthe5pin-XLRsocket„DMXin“ofthecon-

trolbox.AssoonasthemachinereceivesacorrectDMXsignal,theyellowDMX-LEDshines.

Nowthepumpandthefancanbeadjustedviathelightingconsole.

Please note:

TheOrka deLuxe usestwochannelsatthedesk!Channel 1 = Pump, Channel 2 = Fan.

a)PresstheModebuttononthecontrolpanel,untilthreeguresappearontheLEDdisplay.

b) AdjusttherequestedstartaddressbypressingtheUp/Downbuttons.

5.4.1 Adjusting the DMX start address

b. Afteraheatingtimeofapprox.15minutesthedeviceisreadyforoperation.

c. PresstheModebuttonuntilaPandtwoguresappearinthedisplay.Setthedesired

pumpvalueusingtheUp/Downbuttons.

d. PresstheModebuttonuntilanFandtwoguresappearinthedisplay.Setthedesired

fanvaluehere.

e. PresstheEnterbuttontostarttheunit.Thegreen„Active“LEDlightsup.

Tabla de contenidos

Otros manuales de Máquina de niebla de Look Solutions

Look Solutions

Look Solutions Cobra 3.1 Manual de usuario

Look Solutions

Look Solutions Cryo-Fog Manual de usuario

Look Solutions

Look Solutions Cryo-Fog Manual de usuario

Look Solutions

Look Solutions Power-Tiny Manual de usuario

Look Solutions

Look Solutions Viper NT Manual de usuario

Look Solutions

Look Solutions UNIQUE 2 Manual de usuario

Look Solutions

Look Solutions Unique 2.1 Manual de usuario

Look Solutions

Look Solutions Tiny F07 Manual de usuario

Look Solutions

Look Solutions TINY S Manual de usuario

Look Solutions

Look Solutions Viper 2.6 Manual de usuario

Look Solutions

Look Solutions Unique 2.1 Manual de usuario

Look Solutions

Look Solutions Viper NT Manual de usuario

Look Solutions

Look Solutions Tiny CX Manual de usuario

Look Solutions

Look Solutions Tiny FX Manual de usuario

Manuales populares de Máquina de niebla de otras marcas

Antari

Antari ICE Manual de usuario

Boost

Boost BOOST-FOG400LED-BK Manual de usuario

Home Accents Holiday

Home Accents Holiday FM1000-ASH Manual de usuario

EuroLite

EuroLite ZEITGEIST FOG-1200 Manual de usuario

Dyna-Fog

Dyna-Fog CYCLONE ULTRA 2734 Manual de usuario

PROEL

PROEL DRAGO HEAVY PLFD150HY Manual de usuario

Sparklyn

Sparklyn Y846 Manual de usuario

Magicfx

Magicfx CO2 Gun Manual de usuario

Ibiza

Ibiza LSM500LAS Manual de usuario

Antari

Antari M-5 Manual de usuario

Venue Lighting Effects

Venue Lighting Effects ULTRA MINI-FOGGER Manual de usuario

High End

High End F-100 Manual de usuario

Chauvet

Chauvet ARENA 2100 FLEX Manual de usuario

Antari

Antari X FAZER Manual de usuario

Beamz

Beamz F1600 Manual de usuario

Sagitter

Sagitter SG ARS900C Manual de usuario

KISANKRAFT

KISANKRAFT KK-STF-480 Manual de usuario

Orion

Orion OT-U250PP Guía