5
5852 (supersedes 5794)-0122-P9
HTC‐8675 IILink‐Belt Cranes
Carrier
JGeneral
S8 ft 6 in (2.6m) wide
S23 ft 10 in (7.26m) wheelbase (centerline of first axle to
centerline of fourth axle)
SFrame - Box-type, torsion resistant, welded construc
tion made of high tensile steel. Equipped with front and
rear towing and tie-down lugs, tow connections, and
access ladders.
JOutriggers
Boxes - Two double box, front and rear welded to the car
rier frame
Beams and Jacks - Four dual stage beams with Confined
Area Lifting Capacities (CALC) provide selectable outrigger
extensions of full, intermediate, and retracted positions.
Jacks with integral check valves, hydraulically controlled
from the operator's cab and on both sides of carrier. A fifth
front bumper outrigger, with integral check valves is hy
draulically controlled from the operator's cab and at the
front bumper of carrier.
Pontoons
SMain - Four lightweight, stow'n go, 23.5” x 27.25” (59.7 x
69.2cm) hexagonal steel pontoons with a contact area of
485 in2(3 129cm2) can be stored for road travel in either
the storage racks on the carrier or under the outrigger
boxes
SFront Bumper - One, lightweight, self-storing, 16”
(40.6cm) diameter steel pontoon with a contact area of
201 in2(1 296cm2)
Jack Reaction
SMain - 106,000 lb (471.5kN) force and 218 psi
(1 503kPa) ground bearing pressure
SFront Bumper - 51.000 lb (226.9kN) force and 254 psi
(1 751kPa) ground bearing pressure
JSteering and Axles
SSheppard full integral master gear/slave gear steering
system provides hydraulic assisted steering with me
chanical link between steering wheel and wheels
SDrive - 8 x 4 for on/off-highway travel
SAxle 1 & 2 - Tandem steered, non-driven
SAxle 3 & 4 - Tandem non-steered, driven with reduc
tion: 5.38 to 1
SInter-Axle Differential Lock - Traction adding device
that locks axle 3 with axle 4. Operated by a switch from
the carrier cab.
JSuspension
Front - Raydan Air Link walking beam air suspension
Rear - Raydan Air Link walking beam air suspension
SAxle Lift System - Optional - Improves rear tire
ground clearance when the crane is up on outriggers.
The rear tandem axles are raised and lowered with a
switch in the carrier cab. The axle lift system can be con
trolled with a switch on both sides of the carrier.
JTires and Wheels
Front - Four (single) 445/65R22.5 tires on aluminum disc
wheels
Rear - Eight (dual) 12R22.5 tires on aluminum disc wheels
SSpare tires and wheels - optional
STire inflation kit - optional
JBrakes
Service - Full air anti-lock (ABS) brakes on all wheel
ends. Dual circuit compressed air system with air dryer.
Parking/Emergency - Spring loaded type, acting on 3rd
and 4th axles automatically apply when air pressure drops
below 40 psi (275.8kPa) in both circuits.
JElectrical
Battery - Three batteries provide 12 volt starting and operation
Lights
SFront lighting includes two main daytime running head
lights, two high beam lights, two parking/directional indi
cators, and three cab marker lights.
SSide lighting includes three parking/directional indicators
per side.
SRear lighting includes two parking/directional indicators,
two parking/brake lights, two reverse lights, three marker
lights, and a license plate light.
SOther equipment includes hazard/warning system, cab
light, instrument panel light, and signal horn.
SOne amber strobe beacon behind the cab.
JEngine
Specification Cummins X12 Cummins QSX15
Emissions Compliance
Level: EPA 2021
Tier 3/Stage IIIA
(2)
Maximum Allowable Sulfur
Content of Fuel (PPM): 15 5000
Numbers of cylinders: 6 6
Cycle: 4 4
Bore and Stroke: inch (mm)5.11 x 5.91
(130x150)
5.39 x 6.65
(137x169)
Piston Displacement: in
(L)729 (11.9)915 (15.0)
Max. Brake Horsepower:
hp (kW)
450 (336) @
1,800 rpm
414 (309) @
2,100 rpm
480 (358.8) @
1,800 rpm
450 (336) @
2,100 rpm
Peak Torque: ft lb (Nm)1,550 (2 102) @
1,200 rpm
1,550 (2 102) @
1,400 rpm
Alternator: volts - amps 12 - 145 12 - 135
Crankcase Capacity: qt (L)48 (45.4)48.0 (45.4)
SCruise control
SCummins X12 - Three stage engine compression brake
SThermostatically controlled, hydraulically driven radiator fan
S120 volt engine block heater - X12
SEther injection system - optional on X12
SGrid heater starting aid standard on QSX15
S220 volt engine block heater - QSX15
SEngine equipped with on‐board diagnostics - X12
SCummins QSX15 - Two stage compression brake
(1) Can only be sold and/or operated where EPA2021 on‐highway
emission standards are accepted
(2) Can only be sold and/or operated where Tier 3/Stage IIIA
off‐highway emission standards are accepted.
JTransmission
Automated - ZF AS-TRONIC (no clutch pedal) manual
transmission with 12 forward gears and 2 reverse gears.
Courtesy of CraneMarket.com
