Lennox Hearth Products 36ABF Manual de usuario

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE

The ABF Series bi-fold glass door assemblies have been designed for use

with and may be easily fitted to all of Lennox's Merit Plus Series 36 and

42 inch models.

Do not alter or modify these door assemblies or a fireplace malfunction

or a fire hazard may result.

Models ABF doors have been tested and listed by Warnock Hersey Inc.

PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE.

GENERAL INFORMATION

The door assembly consists of a right and left glass panel assembly with

the door handles factory mounted. There are no additional parts that are

required to install the ABF doors. Fireplaces and gas appliances listed on

the front page of this document, have been designed to accept the ABF

doors with minimum effort.

TOOLS REQUIRED

Medium Phillips Screwdriver • ³⁄₈" Open-end wrench

INSTALLATION PROCEDURE

Step 1. Starting with the lower end of either the right or left hand door

hold the door at a slight angle to the door frame outer edge with the

top tilted toward the center.

FIREPLACE KITS

AND ACCESSORIES

INSTALLATION INSTRUCTIONS FOR ABF BI-FOLD GLASS DOORS

36ABF, 36ABF-BB, 36ABF-BS, 42ABF, 42ABF-BB, 42ABF-BS

BI-FOLD GLASS DOORS

750,000M

REV. C 01/2007

Step 2. Tilt the top of the door into place and carefully ensure that the

upper pivot pin and roller pin is in the upper door guide track.

Step 3. Continue to tilt the top of the door into place until the upper

pivot pin engages the spring clip and the pivot pin locks into place

within the hole of the spring clip (

see Figure 3

Figure 1

Figure 2

Lower

Pivot Pin

Pivot

Point

Lower

Frame

Pivot Pin Roller Pin

Lock

Swing the lower corner of the door over the hole in the lower frame

and engage the lower pivot pin into the hole on the lower frame of the

firebox opening (

Figures 1 and 2

Step 4. Repeat this procedure for the opposite door assembly.

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE

ADJUSTMENT FOR DOOR ALIGNMENT

The doors are properly adjusted when the top door trim is in a straight,

level line and the gap between the doors is even at the top and bottom. If

adjustments are required, grasp the door handle and loosen the lower

door pivot pin using a ³⁄₈" open end wrench*. Slide the door panel on the

hinge pin until the gap between the upper door trim and upper frame is

even. Retighten the lower door pivot pin*. Repeat this procedure for the

opposite door if needed.

*Note: Upper door pivot pins can also be loosened for adjustment

purposes; however, it is easier to loosen lower pins.

GENERAL OPERATING PRECAUTIONS AND INSTRUCTIONS

CAUTION: THESE GLASS DOORS ARE LISTED ONLY FOR USE WITH

THE FIREPLACE OR APPLIANCE MODELS SHOWN ON THE FRONT

PAGE. USE ON ANY OTHER FIREPLACE OR APPLIANCE MAY CONSTI-

TUTE A POTENTIAL FIRE HAZARD.

•Avoid building extremely large fires as the tempered glass could

become damaged.

•Use fireplace tools carefully to avoid striking the glass.

•Keep wire mesh screens closed during fireplace use.

•The fireplace flue damper must remain open until fire is completely out.

•Assure wood and embers are well within the confines of the grate area

and well away from the glass doors.

•Keep glass doors closed at night when retiring to minimize the loss of

heated room air up the vent.

IMPORTANT: THEFINISHOFTHESEDOORSMAYBEPROTECTEDWITH

A SELF ADHERING PLASTIC COATING THAT MUST BE REMOVED

BEFOREHEATIS GENERATEDBYA FIREINTHE FIREBOX. TOPREVENT

MELTING, ENSURE THAT ANY PLASTIC COATING PROTECTING THE

FINISH OF THESE DOORS IS REMOVED FOLLOWING INSTALLATION.

REFER TO THE FIREPLACE INSTALLATION AND HOMEOWNER'S IN-

STRUCTIONS FOR DETAILED INSTRUCTIONS REGARDING THE MAIN-

TENANCE OF THE FINISH OF THESE DOORS.

CAUTION: GLASS AND METAL FRAMES GET HOT — ALWAYS USE

HANDLES TO OPEN AND CLOSE THE DOORS.

CLEANING

NEVER CLEAN THE GLASS WHEN THE DOORS ARE HOT. DO NOT USE

AMMONIAORANYAMMONIABASEDGLASSORHOUSEHOLDCLEANER

TO CLEAN THE GLASS OR THE DOOR FRAME. AN AMMONIA BASED

CLEANER WILL DAMAGE THE FINISH.

Remove dirt and grime from the doors using a clean dampened towel

followed by wiping with a dry towel. To remove stubborn stains from the

doors, use a mild soap solution and towel to gently scrub away stain.

Take care not to scratch the glass surface. Do not use abrasive cleaners.

IMPORTANT: THESE GLASS DOORS UTILIZE TEMPERED GLASS

WHICH IS DESIGNED FOR USE WITH HIGH TEMPERATURES BUT CAN

UNEXPECTEDLY SHATTER. DO NOT SIT CLOSE TO THE GLASS.

Tempered glass will break into small particles if it should shatter

unexpectedly. If the glass breaks, particles of extremely hot glass could

be discharged into the surrounding environment, thereby creating a risk

ofpersonalinjuryorfire.Observationoftheabove operating precautions

and instructions will reduce the risk of personal injury or fire.

Extreme temperature changes can cause breakage —do not build a hot

fire and close the doors if the doors are cold.

If the tempered glass pane becomes scratched or chipped, it creates a

weakness in the glass which can cause the glass to break when heated.

Replace the pane of glass by contacting your nearest distributor or

dealer.

Figure 4

NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.

P/N 750,000M REV. C 01/2007

Pivot Pin Roller Pin

Upper Door

Guide Track

Spring Clip

Figure 3

CAUTION: THE FRONT-OPEN FIREPLACE OR APPLIANCE SHOULD

ONLY BE OPERATED WITH THE GLASS DOORS FULLY OPEN OR FULLY

CLOSED.

CAUTION: MULTI-OPEN FIREPLACES MUST BE OPERATED WITH THE

GLASS DOORS FULLY CLOSED.

Fully Open or

Fully Closed

Front-Open Systems

Fully Closed

Multi-Open Systems

WARNING: DO NOT BURN TRASH, CONSTRUCTION SCRAPS,

RAILROADTIES,OROTHER HIGHLY-FLAMMABLEMATERIAL

INTHEFIREPLACE.INTENSEHEATCANCAUSETHEGLASSTO

LOSE STRENGTH AND RESILIENCE WHICH WILL RESULT IN

GLASS BREAKAGE.

The manufacturer reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.

Consult your local distributor for fireplace code information.

LHP

1110 West Taft Avenue • Orange, CA 92865

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Accesorios para chimeneas de Lennox Hearth Products

Lennox Hearth Products

Lennox Hearth Products SV4.5CTS Series Manual de usuario

Lennox Hearth Products

Lennox Hearth Products RAVELLE 42 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products Bi-Fold Glass Doors 36BFOD-BS Manual de usuario

Lennox Hearth Products

Lennox Hearth Products Elite Series DBv-CK-LP TO NG Manual de usuario

Lennox Hearth Products

Lennox Hearth Products 506033-35 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products FBK-250 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products PI40-32ZCFK Manual de usuario

Lennox Hearth Products

Lennox Hearth Products Merit Plus Series APDL35C Manual de usuario

Lennox Hearth Products

Lennox Hearth Products MPLDV30 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products DPSS36 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products BV4000C Manual de usuario

Lennox Hearth Products

Lennox Hearth Products Gas Conversion Kit FGCK Manual de usuario

Lennox Hearth Products

Lennox Hearth Products RAVELLE 30 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products Merit Series MED-CK-LP TO NG Manual de usuario

Lennox Hearth Products

Lennox Hearth Products Decorative Style View MPB-45 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products EKITE DES-BS Manual de usuario

Lennox Hearth Products

Lennox Hearth Products 290M Manual de usuario

Lennox Hearth Products

Lennox Hearth Products ADAGIO-AG Manual de usuario

Lennox Hearth Products

Lennox Hearth Products Leveling Leg Field Fix Kit MPE-27 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products LENNOX MPE-33R Manual de usuario

Lennox Hearth Products

Lennox Hearth Products FIRESTAR Merit Series Manual de usuario

Lennox Hearth Products

Lennox Hearth Products LSO-43 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products RAD22C-2 Manual de usuario

Lennox Hearth Products

Lennox Hearth Products LBLK-100 Manual de usuario

Manuales populares de Accesorios para chimeneas de otras marcas

Valor

Valor L2 1700K Manual de usuario

Exodraft

Exodraft Xzense Manual de usuario

Whalen

Whalen Ruso MNFP62BF23-6 Manual de usuario

Lopi

Lopi Hearthview 864 Manual de usuario

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Manual de usuario

EdilKamin

EdilKamin SERBATOIO 250 Guía de inicio rápido

Bronpi

Bronpi KIT-1 Manual de usuario

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Manual de usuario

Travis Industries

Travis Industries 33 DVI Manual de usuario

Superior

Superior ASD3628-TI Manual de usuario

pleasant hearth

pleasant hearth OFP28WG Manual de usuario

IHP

IHP Astria Series Manual de usuario

Firegear

Firegear FG-H-2110SS Manual de usuario

Nibe

Nibe Contura C i31 Manual de usuario

kozy heat

kozy heat KZK-052 Manual de usuario

SimpliFire

SimpliFire SF-WM36 Manual de usuario

Bluegrass Living

Bluegrass Living BC18NR Guía de inicio rápido

pleasant hearth

pleasant hearth IRIS SCROLL Manual de usuario