Kohler K-6448 Manual de usuario
Installation Guide
Preparation Sink
Mproduct numbers are for Mexico (i.e. K-12345M)
Los números de productos seguidos de
Mcorresponden a México (Ej.
K-12345M)
Français, page “Français-1”
Español, página “Español-1”
K-6448
1095326-2-A
Important Safety Instructions
CAUTION: Risk of personal injury. The use of accessory
attachments not recommended by Kohler Co. may cause
injuries.
Read all these instructions carefully before you begin this
installation.
Electrical service must be properly installed and grounded by a
qualified electrician.
Do not install outdoors.
Do not use this product if it malfunctions or has been damaged in
any manner. Contact your dealer or plumbing contractor, or call
our Customer Service Department at 1-800-4-KOHLER.
This product is intended for residential (household-type) use only.
Tools and Materials
Before You Begin
WARNING: Risk of personal injury. Metal surfaces are
sharp and can cause severe cuts. Use gloves and handle
sink edges carefully.
Observe all local plumbing and building codes.
Installation shall comply with the latest editions of the Uniform
Plumbing Code (UPC) and the National Plumbing Code of
Canada (NPC).
Shut off the water supply.
Inspect the drain and supply tubing. Replace if necessary.
Pencil
Sealant
Tape
Measure Plus:
• 3/4" water hammer
arrestor
• 3/4-14 NPSM thread
supply hose
Safety
Glasses
Adjustable
Wrench
Drill and
Bits
Screwdriver
• 3/32" drill bit
1095326-2-A 2 Kohler Co.
Before You Begin (cont.)
A cabinet with a minimum inside width of 36″(91.4 cm) is
needed to accommodate this sink. A minimum 38″(96.5 cm) base
cabinet is recommended for installing as illustrated in this guide.
Due to the nature of undercounter installations, Kohler Co.
recommends that undercounter sink installations be performed by
trained and experienced installers.
Plan the sink installation so future removal from underneath the
countertop is possible without damaging the countertop.
Anchors should be preinstalled by the countertop manufacturer at
the time of cutting. Use the hardware provided by the countertop
manufacturer and the mounting clips provided with your sink.
The 1-3/8″(3.5 cm) mounting hole for the user interface must be
drilled by the countertop manufacturer.
This system requires the use of a cord and plug electrical
connection for the garbage disposal. Check your local codes for
acceptability.
Install a cold water supply line with a 3/4″supply stop. For
existing 1/2″supply installations, use a 3/4″male x 1/2″female
threaded reducing adapter for connecting to the sink supply hose.
A minimum 1/2″supply stop and 1/2″water supply lines are
required to ensure adequate water flow. A 40 psi (2.8 bars)
dynamic supply pressure at 5.28 gpm (20.0 lpm) is recommended
for optimum performance; install a water pressure booster if
needed.
IMPORTANT! Do not exceed 80 psi (5.5 bar) static water supply
pressure. If pressure exceeds this amount or adverse effects are seen
from excessive water pressure, install a pressure regulator in the
supply line.
A switched electrical outlet located beneath the sink with the
switch mounted within sight of the sink is recommended. This
will allow for both emergency shut-off of the system and for
disabling the system during long absences or servicing.
Follow the food waste disposal manufacturer recommendations
for your disposal usage and installation.
All information in these instructions is based on the latest product
information available at the time of publication. Kohler Co.
reserves the right to make revisions in the design of products
without notice, as specified in the Price Book.
Kohler Co. 3 1095326-2-A
1. Preparation
Verify adequate clearance underneath the cabinet and decide
installation locations for the sink, garbage disposal, control
module, user interface, outlet, and outlet switch.
NOTE: If the user interface is located in direct sunlight, the indicator
lights of the interface may be difficult to see.
Locate the user interface within reach of the sink.
Route the electrical supply and install a switch-controlled
GFCI-protected outlet to the inside cabinet wall near the drain
end of the sink.
Install the outlet switch within sight of the sink (not shown).
Control
Module
User
Interface
Sink
1095326-2-A 4 Kohler Co.
2. Install the Sink
Using the hardware provided by the countertop manufacturer,
loosely attach the mounting clips to the underside of the
countertop.
Turn all the mounting clips parallel to the countertop opening.
Apply a bead of silicone sealant around the top edge of the sink
rim.
Maneuver the sink into the cabinet and lift into position.
Turn all the mounting clips to hold the sink in place.
Center the sink and secure by tightening all the mounting clips.
Wipe away any excess sealant.
12
Attach
mounting clips. Apply sealant.
3
Kohler Co. 5 1095326-2-A
3. Install the User Interface
Apply a bead of silicone sealant around the underside of the user
interface.
Thread the cable through the mounting hole and position the
interface. Press down firmly.
Wipe away any excess sealant, ensuring no sealant remains on the
sides of the user interface.
4. Install the Control Module
Mark the control module mounting hole locations.
Using a 3/32″drill bit, drill pilot holes at the marked locations.
Use care to not drill through the cabinet wall.
Thread the screws into the cabinet at the marked locations.
Screws should protrude approximately 3/16″(5 mm).
Mount the control module on the screws.
Hang module
on screws.
Countertop
Apply sealant.
User Interface
4-1/2"
(11.4 cm)
1095326-2-A 6 Kohler Co.
5. Install the Garbage Disposal
Install the garbage disposal to the sink according to the
manufacturer’s instructions.
Connect the drain to the trap.
6. Connect the Supply
Install a water hammer arrestor to the supply stop.
Connect the supply hose to the supply stop.
Water Hammer
Arrester
Supply Hose
Drain
Connection
Garbage
Disposal
Kohler Co. 7 1095326-2-A
7. Connect the Cables
IMPORTANT! Do not plug the control module power cord into the
outlet until instructed.
IMPORTANT! Route cables and secure as needed so not to interfere
with cabinet use.
NOTE: Control module can be removed from the cabinet wall to
ease cable connection.
Plug the garbage disposal power cord into port 2 of the control
module.
Insert the control module power cord into port 1 of the control
module. Do not plug the power cable into the outlet at this time.
Verify the switch for the outlet is in the OFF position.
Insert the sink cable into port 4 of the control module and the
user interface cable into port 6. Connect each cable by pressing
gently until it snaps into place.
Outlet
Disposal
Power Cord
Garbage
Disposal
Power
Module Power Cord
Sink
Cable
Sink User
Interface User
Interface
Cable
1095326-2-A 8 Kohler Co.
8. Complete the Installation
Install the baffle into the sink over the garbage disposal baffle.
Turn on the water supply.
Check connections for leaks.
Plug the control module power cord into the outlet.
Flip the outlet switch to the ON position.
Kohler Co. 9 1095326-2-A
9. Verify Operation
Press and release the open circle icon on the user interface to test
water only operation. Press either icon to turn off the water, or
water will automatically turn off after 4 seconds.
Press and release the closed circle icon on the user interface to
test water and disposal operation. Press either icon to turn off the
water/disposal, or water/disposal will automatically turn off
after the 20 second cycle is complete.
Refer to the homeowners guide for more information regarding
available cycles and operation.
Water Only
Operation
Water and Disposal
Operation
1095326-2-A 10 Kohler Co.
Otros manuales para K-6448
1
Tabla de contenidos
Idiomas:
Otros manuales de Accesorios de cocina y baño de Kohler
Kohler
Kohler K-10270 Instrucciones de montaje
Kohler
Kohler K-T10110 Manual de usuario
Kohler
Kohler Beitou 99856T-4 Manual de usuario
Kohler
Kohler K-596 Instrucciones de montaje
Kohler
Kohler MEMOIRS 22559T-4V Manual de usuario
Kohler
Kohler CANDIDE 660 Manual de usuario
Kohler
Kohler Refinia K-T5324 Instrucciones de montaje
Kohler
Kohler ELATE 13963T-B4 Manual de usuario
Kohler
Kohler K-3674 Instrucciones de montaje
Kohler
Kohler K-T10278 Manual de usuario
Kohler
Kohler KUMIN K-18655T-NW-CP Manual de usuario
Kohler
Kohler K-5810 Manual de usuario
Kohler
Kohler July II 16027X-B4 Manual de usuario
Kohler
Kohler SYMBOL 72638T-B7 Manual de usuario
Kohler
Kohler K-2381 Instrucciones de montaje
Kohler
Kohler K-3362 Manual de usuario
Kohler
Kohler K-6125 Manual de usuario
Kohler
Kohler K-14616 Instrucciones de montaje
Kohler
Kohler K-15160 Instrucciones de montaje
Kohler
Kohler Stillness K-14451 Instrucciones de montaje
Manuales populares de Accesorios de cocina y baño de otras marcas
Alpha Bidet
Alpha Bidet Alpha One Manual de usuario
InSinkErator
InSinkErator H/HC3300 Manual de instalación
Clou
Clou Xo type 1 Manual de usuario
Grohe
Grohe Bridgeford 20 158 Manual de usuario
Hans Grohe
Hans Grohe Croma Select S 180 Showerpipe EcoSmart... Manual de usuario
Wickes
Wickes MONO SINK MIXER Manual de usuario