Kia Sportage Manual de instrucciones

Sportage

Workshop Manual

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

COMPONENT

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (1 of 2)3/12/2008 5:36:49 AM

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (2 of 2)3/12/2008 5:36:49 AM

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

ENGINE COOLANT REFILLING AND BLEEDING

Never remove the radiator cap when the engine is hot. Serious scalding could be caused by hot fluid under

high pressure escaping from the radiator.

When pouring engine coolant, be sure to shut the relay box lid and not to let coolant spill on the electrical parts

or the paint. If any coolant spills, rinse it off immediately.

1. Slide the the heater temperature control lever to maximum heat. Make sure the engine and radiator are cool to

the touch.

2. Remove radiator cap.

3. Loosen the drain plug, and drain the coolant.

4. Tighten the radiator drain plug(A) securely.

5. Remove, drain and reinstall the reservoir. Fill the tank halfway to the MAX mark with water, then up to the MAX

mark with antifreeze.

6. Fill fluid mixture with coolant and water slowly through the radiator cap. Gently squeeze the upper/lower hoses

of the radiator so as to bleed air easily.

• Use only genuine antifreeze/coolant.

• For best corrosion protection, the coolant concentration must be maintained year-round at 50% minimum.

Coolant Coolant concentrations less than 50% may not provide sufficient protection against corrosion or

freezing.

• Coolant concentrations greater then 60% will impair cooling efficiency and are not recommended.

• Do not mix different brands of antifreeze/coolants.

• Do not use additional rust inhibitors or anti-rust products; they may not be compatible with the coolant.

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (1 of 3)3/12/2008 5:36:27 AM

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

7. Start tart the engine and allow coolant to circula

When the cooling fan operates and coolant circulates, refill coolant through the radiator cap.

8. Repeat 7 until the cooling fan 3 ~ 5times and bleed air sufficiently out of the cooling system.

9. Install the radiator cap and fill the reservoir tank to the "MAX" line with coolant.

10. Run the vehicle under idle until the cooling fan operates 2 ~ 3 times.

11. Stop the engine and allow coolant to cool.

12. Repeat steps 6 to 11 until the coolant level stays constant and all air is bleed out of the cooling system.

Recheck the coolant level in the reservoir tank for 2 ~ 3 days after replacing coolant.

Coolant capacity : 6.0 liters (6.34 US qt, 5.28 lmp qt)

RADIATOR CAP TESTING

1. Remove the radiator cap, wet its seal with engine coolant, then install it on pressure tester.

2. Apply a pressure of 93.16 ~ 122.58kpa (0.95 ~ 1.25kg/cm², 13.51 ~ 17.78psi).

3. Check for a drop in pressure.

4. If the pressure drops, replace the cap.

RADIATOR LEAKAGE TEST

1. Wait until engine is cool, then carefully remove the radiator cap and fill the radiator with engine coolant, then

install it on the pressure tester.

2. Apply a pressure tester to the radiator and apply a pressure of 93.16 ~ 122.58kpa (0.95 ~ 1.25kg/cm², 13.51 ~

17.78psi).

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (2 of 3)3/12/2008 5:36:27 AM

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

3. Inspect for engine coolant leaks and a drop in pressure.

4. Remove the tester and reinstall the radiator cap.

Check for engine oil in the coolant and/or coolant in the engine oil.

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (3 of 3)3/12/2008 5:36:27 AM

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

REMOVAL

WATER PUMP

1. Drain the engine coolant.

System is under high pressure when the engine is hot. To avoid danger of releasing scalding engine coolant,

remove the cap only when the engine is cool.

2. Remove the drive belts.

3. Remove the timing belt. (Refer to EMA-27)

4. Remove the timing belt idler.

5. Remove the power steering pump and use a wire to secure the pump to the vehicle so that it is out of the way.

6. Remove the bolts(B, C) and power steering pump bracket(A).

7. Remove the alternator. (See EE group - alternator)

8. Remove the water pump.

(1) Remove the 2 bolts(D) and alternator brace(A).

(2) Remove the 3 bolts(C) and remove the water pump(B) and gasket.

THERMOSTAT

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (1 of 9)3/12/2008 5:37:06 AM

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

Disassembly of the thermostat would have an adverse effect, causing a lowering of cooling efficiency.

1. Drain the engine coolant so its level is below thermostat.

2. Remove the water inlet fitting(A), gasket and thermostat.

RADIATOR

1. Remove the under cover(A).

2. Drain the engine coolant. Remove the radiator cap to speed draining.

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (2 of 9)3/12/2008 5:37:06 AM

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

3. Remove the air duct(A).

4. Remove the battery and tray.

5. Remove the coolant reservoir tank(A).

6. Remove the radiator upper hose(B).

7. Remove the radiator lower hose(A).

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (3 of 9)3/12/2008 5:37:06 AM

cardiagn.com

http://www.kiatechinfo.com/viewer/content.asp?vehicletype=PA...KM%5EKM13%5E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24

8. Remove the ATF oil cooler hose(B).

9. Remove the cooling fan motor connector(A).

10. Remove the cooling fan motor assembly mounting bolt(B).

11. Remove the ATF oil cooler pipe(C).

12. Remove the cooling fan motor assembly with pulling it from the radiator.

13. Remove the radiator bracket(A, B).

http://www.kiatechinfo.com/viewer/content.asp?veh...E2005%5Een%5E25%5Enone%5Enone%5Enone%5Eshop%5E%24 (4 of 9)3/12/2008 5:37:06 AM

cardiagn.com

Otros manuales para Sportage

Tabla de contenidos

Otros manuales de Automóvil de Kia

Kia

Kia K5 2021 Manual de usuario

Kia

Kia niro 2023 Manual de usuario

Kia

Kia Spectra Manual de usuario

Kia

Kia 2020 Telluride Instrucciones de montaje

Kia

Kia Sorento 2011 Manual de usuario

Kia

Kia OPTIA hybrid 2020 Manual de lista de piezas

Kia

Kia 2020 Telluride Manual de usuario

Kia

Kia 2002 Rio Manual de usuario

Kia

Kia 2016 forte Manual de lista de piezas

Kia

Kia SORENTO 2016 Manual de usuario

Kia

Kia Sorento Manual de usuario

Kia

Kia Spotage Manual de lista de piezas

Kia

Kia Soul 2010 Manual de usuario

Kia

Kia Soul 2013 Manual de usuario

Kia

Kia Amanti Manual de usuario

Kia

Kia stinger 2022 Manual de lista de piezas

Kia

Kia Cerato 2021 Manual de usuario

Kia

Kia Soul 2020 Manual de usuario

Kia

Kia 2014 Optima Hybrid Manual de usuario

Kia

Kia Forte 2014 Manual de usuario

Kia

Kia 2016 Optima Manual de lista de piezas

Kia

Kia 2015 Cadenza Manual de usuario

Kia

Kia SELTOS Manual de usuario

Kia

Kia Magentis 2002 Manual de usuario

Manuales populares de Automóvil de otras marcas

Toyota

Toyota 2000 Tundra Manual de usuario

CITROËN

CITROËN DS4 DSign Manual de usuario

Lexus

Lexus 2015 CT 200h Manual de usuario

Cadillac

Cadillac CTS 2008 Manual de usuario

Mercedes-Benz

Mercedes-Benz M-class ML 55 AMG Manual de usuario

Porsche

Porsche Boxster S Manual de usuario

GMC

GMC 2010 Savana 1500 Cargo Manual de usuario

KIAM

KIAM SPORTAGE 2014 Manual de lista de piezas

GMC

GMC 2013 Terrain Instrucciones de montaje

GMC

GMC T-Series 1999 Manual de usuario

Mercury

Mercury 1998 Mystique Manual de usuario

Mercury

Mercury 2007 Mariner Manual de usuario

Mazda

Mazda 2007 Mazdaspeed 3 Guía

Mazda

Mazda 2014 CX-5 Manual de usuario

GMC

GMC Chevrolet Express 2022 Manual de usuario

GMC

GMC 1997 Jimmy Manual de usuario

Chevrolet

Chevrolet 2012 Malibu Manual de usuario

Cadillac

Cadillac 2010 Escalade Manual de usuario