Johnson Controls Tyco TY-B Series Manual de usuario

Series TY-B — 5.6 K-factor

Conventional (Old Style) Sprinklers

Standard Response

Page 1 of 4 AUGUST 2018 TFP662

IMPORTANT

Refer to Technical Data Sheet

TFP2300 for warnings pertaining to

regulatory and health information.

Always refer to Technical Data

Sheet TFP700 for the “INSTALLER

WARNING” that provides cautions

with respect to handling and instal-

lation of sprinkler systems and com-

ponents. Improper handling and

installation can permanently damage

a sprinkler system or its compo-

nents and cause the sprinkler to fail

to operate in a ﬁre situation or cause

it to operate prematurely.

Worldwide

Contacts

www.tyco-ﬁre.com

General

Description

The TYCO Series TY-B, 5.6 K-fac-

tor, Conventional Sprinklers (TY365)

described in this data sheet are stan-

dard response -standard coverage,

decorative 5 mm glass bulb type

spray sprinklers. These sprinklers are

intended to be installed either pendent

or upright, and in either position, they

produce a spherical water discharge

pattern with approximately 50% of

the discharge directed upwards and

approximately 50% of the discharge

directed downwards.

Conventional sprinklers are generally

used with Ordinary and Extra High

Hazard Class Systems, as deﬁned by

the automatic sprinkler system installa-

tion rules of the country and authority

having jurisdiction. The NFPA permits

the use of “Old Style Sprinklers” where

special construction features require a

unique water distribution; for the pro-

tection of fur vaults; or, the replace-

ment of similar sprinklers that had been

installed prior to 1955.

NOTICE

The TYCO Series TY-B 5.6 K-factor

Conventional Sprinklers described

herein must be installed and main-

tained in compliance with this docu-

ment, as well as with the applicable

standards of the NATIONAL FIRE PRO-

TECTION ASSOCIATION, in addition to

the standards of any other authorities

having jurisdiction. Failure to do so

may impair the performance of these

devices.

The owner is responsible for main-

taining their fire protection system

and devices in proper operating con-

dition. Contact the installing contrac-

tor or product manufacturer with any

questions.

Sprinkler

Identiﬁcation

Number (SIN)

TY365

TY3650 (LPCB Approved only)

Technical

Data

Approvals

Refer to Table A

Maximum Working Pressure

175 psi (12,1 bar)

Discharge Coefﬁcient

K = 5.6 GPM/psi1/2 (80,6 LPM/bar1/2)

Temperature Ratings

135°F (57°C)

155°F (68°C)

175°F (79°C)

200°F (93°C)

286°F (141°C)

360°F (182°C)

Finishes

Refer to Table B

Physical Characteristics

Frame . . . . . . . . . . . . . . . . . . . . . . . . . . . .Bronze

Button . . . . . . . . . . . . . . . . . . . . . . Brass/Copper

Sealing Assembly ...Stainless Steel w/TEFLON

Bulb . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Glass

Compression Screw . . . . . . . . . . . . . . . . .Bronze

Deﬂector . . . . . . . . . . . . . . . . . . . . . . . . . .Bronze

Operation

The glass bulb contains a ﬂuid which

expands when exposed to heat. When

the rated temperature is reached, the

ﬂuid expands sufﬁciently to shatter the

glass bulb, allowing the sprinkler to

activate and water to ﬂow.

Design

Criteria

The TYCO Series TY-B, 5.6 K-factor,

Conventional Sprinklers (TY365) are

intended for ﬁre protection systems

designed in accordance with the stan-

dard installation rules recognized by the

applicable Listing or Approval agency

(e.g., UL Listing is based on NFPA 13

requirements). The Series TY-B Con-

ventional Sprinklers are only for non-

recessed applications.

TFP662

Page 2 of 4

Installation

The TYCO Series TY-B, 5.6 K-factor,

Conventional Sprinklers (TY365) must

be installed in accordance with this

section:

General Instructions

Do not install any bulb type sprinkler

if the bulb is cracked or there is a loss

of liquid from the bulb. With the sprin-

kler held horizontally, a small air bubble

should be present. The diameter of the

air bubble is approximately 1/16 in.

(1,6 mm) for the 135°F (57°C) to 3/32 in.

(2,4 mm) for the 360°F (182°C) tempera-

ture ratings.

A leak tight 1/2 in. NPT sprinkler joint

should be obtained with a torque of 7 to

14 lb-ft (9,5 to 19,0 N∙m). Higher levels

of torque may distort the sprinkler inlet

and cause leakage or impairment of the

sprinkler.

Step 1. With pipe thread sealant

applied to the pipe threads, hand

tighten the sprinkler into the sprinkler

ﬁtting.

Step 2. Tighten the sprinkler into the

sprinkler ﬁtting using only the W-Type 6

Sprinkler Wrench (Figure 2), except that

an 8 in. or 10 in. adjustable Crescent

wrench is to be used for wax coated

sprinklers. With reference to Figure 1,

the W-Type 6 Sprinkler Wrench or the

Crescent wrench, as applicable, is to

be applied to the wrench ﬂats.

Care and

Maintenance

The TYCO Series TY-B, 5.6 K-fac-

tor, Conventional Sprinklers (TY365)

must be maintained and serviced in

accordance with this section.

Before closing a ﬁre protection system

main control valve for maintenance

work on the ﬁre protection system

that it controls, obtain permission to

shut down the affected ﬁre protection

systems from the proper authorities

and notify all personnel who may be

affected by this action.

Sprinklers which are found to be

leaking or exhibiting visible signs of

corrosion must be replaced.

Automatic sprinklers must never be

painted, plated, coated, or other-

wise altered after leaving the factory.

Modiﬁed sprinklers must be replaced.

Sprinklers that have been exposed to

corrosive products of combustion, but

have not operated, should be replaced

if they cannot be completely cleaned

by wiping the sprinkler with a cloth or

by brushing it with a soft bristle brush.

Care must be exercised to avoid

damage to the sprinklers before,

during, and after installation. Sprin-

klers damaged by dropping, striking,

wrench twist/slippage, or the like, must

be replaced. Also, replace any sprinkler

that has a cracked bulb or that has lost

liquid from its bulb. Refer to the Instal-

lation section for additional information.

The owner is responsible for the inspec-

tion, testing, and maintenance of their

ﬁre protection system and devices in

compliance with this document, as well

as with the applicable standards of the

NATIONAL FIRE PROTECTION ASSO-

CIATION (e.g., NFPA 25), in addition to

the standards of any other authorities

having jurisdiction. Contact the install-

ing contractor or sprinkler manufac-

turer regarding any questions.

It is recommended that automatic

sprinkler systems be inspected, tested,

and maintained by a qualiﬁed Inspec-

tion Service in accordance with local

requirements and/or national codes.

WRENCH RECESS

(USE ONLY

END "A")

CROSS SECTION

SHOWN UPRIGHT

SHOWN

PENDENT

Temperature

rating is indicated

on Deector.

Pipe thread

connections per

ISO 7-1 can be

provided on

special request.

-Deector

Compression

Screw

Bulb

Components:

Button

Sealing

Assembly

Frame

1-3/8"

(34,9 mm)

(50,8 mm)

WRENCH

FLATS

7/16" (11,1 mm)

NOMINAL

MAKE-IN

ESCUTCHEON PLATE

SEATING SURFACE

1/2"

NPT

FIGURE 2

W-T YPE 6

SPRINKLER WRENCH

FIGURE 1

SERIES TY-B CONVENTIONAL SPRINKLERS (TY365 AND TY3650)

5.6 K-FACTOR, 1/2 INCH NPT, STANDARD RESPONSE

TFP662

Page 3 of 4

P/N* 77 – XXX – X – XXX

* Use sufx “I” for ISO 7-1 connection; for example, 77-573-4-175-I

** LPCB approved Series TY-B Conventional Sprinkler assem-

blies only: Use sux “L” for LPCB Approved assemblies (e.g., 77-

573-4-175-L or 77-573-4-175-IL for LPCB Approved and ISO 7-1

connection)

***Eastern Hemisphere sales only

Limited

Warranty

For warranty terms and conditions, visit

www.tyco-ﬁre.com.

Ordering

Procedure

Contact your local distributor for avail-

ability. When placing an order, indicate

the full product name.

Sprinkler Assemblies with NPT

Thread Connections

Specify: Series TY-B Conventional

Sprinklers, SIN TY365, K=5.6, Stan-

dard Response, (specify) temperature

rating, (specify) ﬁnish, P/N (specify,

refer to Table B)

NOTES:

1. Listed by Underwriters Laboratories, Inc. (UL).

2. Approved by the Loss Prevention Certication Board (LPCB Ref. No. 094a/05 & 007k/03).

3. VdS Approved (For details contact Johnson Controls, Enschede, Netherlands, Tel. 310530428-4444/Fax 31-53-428-3377)

4. Where Polyester Coated Sprinklers are noted to be UL Listed, the sprinklers are UL Listed as Corrosion Resistant Sprinklers.

* Frame and Deector only.

Sprinkler Wrench

Specify: W-Type 6 Sprinkler Wrench,

P/N 56-000-6-387

SPRINKLER

FINISH

1NATURAL BRASS

3PURE WHITE (RAL9010)***

POLYESTER

4SIGNAL WHITE (RAL9003)

POLYESTER

9CHROME PLATED

TEMPERATURE

RATINGS

135 135°F (57°C)

155 155°F (68°C)

175 175°F (79°C)

200 200°F (93°C)

286 286°F (141°C)

360 360°F (182°C)

SIN

573 5.6K CONVENTIONAL (1/2 in. NPT) TY365

573 5.6K CONVENTIONAL TY3650**

SPRINKLER FINISH (See Note 4)

TYPE TEMP. RATING BULB

LIQUID NATURAL

BRASS CHROME

PLATED POLYESTER*

5.6K

Conventional

(TY365)

135°F (57°C) Orange

1, 3, 4

155°F (68°C) Red

175°F (79°C) Yellow

200°F (93°C) Green

286°F (141°C) Blue

360°F (182°C) Mauve

5.6K

Conventional

(TY3650)

135°F (57°C) Orange

155°F (68°C) Red

175°F (79°C) Yellow

200°F (93°C) Green

286°F (141°C) Blue

360°F (182°C) Mauve

TABLE B

PART NUMBER SELECTION

SERIES TY-B CONVENTIONAL SPRINKLERS

TABLE A

LABORATORY LISTINGS AND APPROVALS

TFP662

Page 4 of 4

NATIONAL FIRE PROTECTION ASSOCIATION and NFPA are registered trademarks of National Fire Protection Association;

TEFLON is a registered trademark of DuPont

1400 Pennbrook Parkway, Lansdale, PA 19446 | Telephone +1-215-362-0700

Otros manuales para tyco TY-B Series

Este manual sirve para los siguientes modelos

Otros manuales de Sistema de riego de Johnson Controls

Johnson Controls

Johnson Controls tyco TY-FRL Series Manual de usuario

Johnson Controls

Johnson Controls Tyco ULF AM6 Manual de usuario

Johnson Controls

Johnson Controls tyco CWS Manual de usuario

Johnson Controls

Johnson Controls Tyco EC-8 Series Manual de usuario

Johnson Controls

Johnson Controls tyco TY1234 Manual de usuario

Johnson Controls

Johnson Controls tyco RAPID RESPONSE LFII Series Manual de usuario

Johnson Controls

Johnson Controls tyco TY2234 Manual de usuario

Johnson Controls

Johnson Controls tyco TY-FRB Series Manual de usuario

Johnson Controls

Johnson Controls tyco ESFR-25 Manual de usuario

Johnson Controls

Johnson Controls tyco LD Manual de usuario

Johnson Controls

Johnson Controls tyco EC-25 Manual de usuario

Johnson Controls

Johnson Controls tyco RFII Series Manual de usuario

Johnson Controls

Johnson Controls tyco TY-B Series Manual de usuario

Johnson Controls

Johnson Controls MS1 Manual

Johnson Controls

Johnson Controls tyco TY-FRB Series Manual de usuario

Johnson Controls

Johnson Controls SABROE NS-HPAC Manual de usuario

Johnson Controls

Johnson Controls tyco EC-8 Series Manual de usuario

Johnson Controls

Johnson Controls tyco RAPID RESPONSE LFII Series Manual de usuario

Johnson Controls

Johnson Controls tyco TY-FRL Series Manual de usuario

Johnson Controls

Johnson Controls tyco ESFR-17 Manual de usuario

Johnson Controls

Johnson Controls tyco AQUAMIST IFP Manual de usuario

Johnson Controls

Johnson Controls tyco TFP PH2 Manual de usuario

Johnson Controls

Johnson Controls tyco ESFR-25 Manual de usuario

Johnson Controls

Johnson Controls tyco TY-FRL Series Manual de usuario

Manuales populares de Sistema de riego de otras marcas

Hunter

Hunter Institutional Series Manual de usuario

Cellfast

Cellfast 52-305 Manual de usuario

Tyco Fire Product

Tyco Fire Product Star Galaxy SGQR Manual de usuario

Tyco Fire Product

Tyco Fire Product CENTRAL A Manual de usuario

Oral Care Technologies

Oral Care Technologies Hydro Floss Manual de usuario

Reliable

Reliable F1-300 Manual de usuario

Tyco Fire Product

Tyco Fire Product Gem F892 Manual de usuario

Netafim

Netafim NETBEAT Manual de usuario

Irrigation-Mart

Irrigation-Mart KIT-GK100-RV-B Manual de usuario

Tyco

Tyco CC3 Manual de usuario

Reliable

Reliable F4FR Manual de usuario

OpenSprinkler

OpenSprinkler OSPi Manual de usuario

EINHELL

EINHELL GE-WW 5537 E Manual de usuario

Valley

Valley Bender160 Manual de usuario

Reliable

Reliable F1FR42 Series Manual de usuario

Reliable

Reliable F1FR-300 Manual de usuario

Toro

Toro 730 Series Guía rápida

Eden

Eden 97063-EDAMZ Manual de usuario