Hyundai HCP6500D Manual de usuario

Diesel-Powered Generator

User Manual

Licensed by Hyundai Corporation, Korea.

HCP6500D-0711-02

Thank you for purchasing this Hyundai Power Equipment

Generator.

Please register in order to ensure warranty service in the future.

This manual covers the safety, operation and maintenance

procedures for the HCP6500D Diesel Generator.

All information in this publication is based on the latest

product information available at the time of print. Visit www.

powerbyhyundai.com for manual updates and operation

notices.

No part of this publication may be reproduced without written

permission. Please keep this manual together with the Owners

Card. Contact Hyundai Power Equipment at the numbers listed

on the Owners Card if warranty service is required.

It is important that anyone operating this product read and

understand the manual prior to use.

Warranty Information

Warranty service, operation assistance and product support is provided by

Midland International Inc., a licensed manufacturer of Hyundai Power Equipment.

www.powerbyhyundai.com

TECHNICAL ASSISTANCE

1-855-706-8475

CUSTOMER SERVICE

1-877-528-3772 (toll-free)

SALES

1-503-534-3684

Component Certiﬁcations

This product contains components certied by the following agency:

TABLE OF CONTENTS

1.0 - OPERATION SAFETY

1.1 - Operation Safety 8

1.2 - AC Safety Guidelines 9

1.3 - Maintenance Safety 9

1.4 - Other Safety Hazards 10

2.0 - COMPONENTS

2.1 - Identication 11

3.0 - PRE-OPERATION INSPECTION

3.1 - Engine Oil Check 15

3.2 - Fuel Level Check 16

3.3 - Air Filter Check 17

4.0 - OPERATION

4.1 - Before Starting 18

4.1.2 - Connecting Battery 18

4.2 - Starting the Generator 20

4.3 - Using the Generator 22

4.4 - Stopping the Generator 25

5.0 - MAINTENANCE

5.1 - Importance of Maintenance 26

5.2 - Maintenance Schedule 26

5.3 - General Inspection 27

5.4 - Air Filter Service 27

5.5 - Oil Maintenance 28

5.6 - Fuel Filter Cleaning 29

5.7 - Checking Battery Charge 29

5.8 - Handling and Storage 30

6.0 - TROUBLESHOOTING 32

7.0 - SPECIFICATIONS 33

8.0 - WIRING DIAGRAMS 34

WARRANTY 35

1.0 - SAFETY

1.1 - Operation Safety

• Always perform a pre-operation check before starting the engine.

• Properly clean and maintain the equipment.

• Operate the generator according to instructions for safe and dependable

service.

• Before operating the generator, read the user manual carefully.

Otherwise, it may result in personal injuries or equipment damage.

• Never run the generator in an enclosed area to avoid harm from exhaust

emissions of a poisonous carbon monoxide gas.

• Be careful not to touch the exhaust system or discharge tubing during

operation due to risk of burns.

• Pay attention to the warning labels. The engine exhaust system will

become heated during operation and remain hot immediately after the

engine is stopped.

• Diesel fuel is a ammable and explosive liquid. Refuel in a well ventilated

area with the engine stopped.

• When refueling the generator, keep it away from cigarettes, open ames,

smoke and/or sparks.

• Connections for standby power to a building’s electrical system must be

done by a qualied electrician and must comply with all applicable laws

and electrical codes. Improper connections may cause serious injuries

to electrical workers during a power outage, and when the utility power

is restored, the generator may explode or cause res.

• Place the generator at least 3ft away from buildings or other equipment

during operation.

• Run the generator on a level surface. If the generator tilts, fuel spillage

may result.

• Know how to stop the generator quickly and understand operation of

all the controls. Never permit anyone to operate the generator without

proper instructions.

• Keep children, pets and machinery with rotating parts away during

operation.

• Do not operate the generator in rain or snow.

• Do not allow any moisture to come in contact with the generator.

1.2 - AC Safety Guidelines

Before connecting the generator to an electrical device or power cord:

• Make sure that everything is in proper working order. Faulty devices or

power cords can lead to an electrical shock.

• Turn off the generator immediately if the device begins to operate

abnormally. Then disconnect the device and investigate the problem.

• Make sure that the electrical rating of the device does not exceed that of

the generator. If the power level of the device is between the maximum

output power and the running power of the generator, the generator

should not be used for more than 30 minutes.

• The connections from the generator to the household power supply

should be done by professional electrical technicians. Improper

connections may lead to a re hazard or damages to the generator set.

1.3 - Maintenance Safety

• After any maintenance is performed, wash immediately using soap and

clean water because repeated exposure to lubricant may cause skin

irritation.

• Do not clean the lter element with ammable liquids like gasoline

because explosion may occur.

• Turn off the generator set before performing any maintenance.

Otherwise it can cause severe personal injury or death.

• Allow the generator set to cool down before performing any

maintenance.

• Always wear safety glasses when cleaning the generator set with air.

• Do not clean the generator set with a pressure washer because it can

cause damage to the generator set.

• Before working with batteries, ventilate the area, wear safety glasses, do

not smoke and always disconnect the negative cable rst and reconnect

it last.

• Use rubber gloves when coming into contact with engine oil.

• Always stop the generator set before removing the oil ller cap.

• Only qualied maintenance personnel with knowledge of fuels,

electricity, and machinery hazards should perform maintenance

procedures.

1.4 - Other Safety Hazards

• To avoid breathing in poisonous carbon monoxide from the exhaust

gases, adequate ventilation should be provided if the generator set is

running in a partially enclosed space.

• If the generator set is stored outdoors, check all the electrical

components on the control panel before each use. Moisture can

damage the generator and can lead to an electric shock.

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Generador portátil de Hyundai

Hyundai

Hyundai HY3000CI Manual de usuario

Hyundai

Hyundai HPS-300 Manual de usuario

Hyundai

Hyundai HY2000SI Manual de usuario

Hyundai

Hyundai DHY22KSE Manual de usuario

Hyundai

Hyundai HY12000LE Manual de usuario

Hyundai

Hyundai HY4500SEi Manual de usuario

Hyundai

Hyundai FULLPOWER 65213 Manual de usuario

Hyundai

Hyundai HY1000SI Manual de usuario

Hyundai

Hyundai HomePower HHD3500 Manual de usuario

Hyundai

Hyundai HY2200P Manual de usuario

Hyundai

Hyundai DHY6000SE/LR Instrucciones de montaje

Hyundai

Hyundai HY70100P Manual de lista de piezas

Hyundai

Hyundai DHY14KSE Manual de usuario

Hyundai

Hyundai HY3500P Manual de usuario

Hyundai

Hyundai DHY34KSE Manual de usuario

Hyundai

Hyundai HPS-300 Manual de usuario

Hyundai

Hyundai HomePower HHD3500 Manual de usuario

Hyundai

Hyundai Hirepro HY8500 Manual de usuario

Hyundai

Hyundai HDG5000 Manual de usuario

Hyundai

Hyundai HHD SERIES Manual de usuario

Hyundai

Hyundai HY2800L-2 Manual de usuario

Hyundai

Hyundai DHY8500SE Manual de usuario

Hyundai

Hyundai HY3800LE-LPG Manual de usuario

Hyundai

Hyundai HG4000-A Manual de usuario

Manuales populares de Generador portátil de otras marcas

Kohler

Kohler 20EORZ Manual de instrucciones

Powerhorse

Powerhorse 83171 Manual de usuario

HURST

HURST ML-630-SI Manual de usuario

ETQ

ETQ TG4000 Manual de usuario

Briggs & Stratton

Briggs & Stratton 40265 Guía de configuración

ConMed

ConMed 7550 Manual de usuario

Owon

Owon Waveform Generator Manual de usuario

evertz

evertz 7700 Series Manual de usuario

Power Stroke

Power Stroke PS906025 Manual de usuario

Firefly

Firefly Cygnus CYG2400/460/24 Manual de usuario

Draper

Draper PG950S Actualización de firmware

PowerBoss

PowerBoss PowerBoss Manual de usuario

SDMO

SDMO SH 4000 Manual de usuario

EINHELL

EINHELL STE 5500 Manual de usuario

Wanco

Wanco WI3000P Manual de usuario

Full Boar

Full Boar FBT-3300 Manual de usuario

Dwyer Instruments

Dwyer Instruments ASG Manual de usuario

Westinghouse

Westinghouse WH1000i Series Manual de usuario