Hyundai HWP Series Manual de usuario

HWP & HWT SERIES

Manual

HWP & HWT SERIES

The engine exhaust from this product contains chemicals known

to cause cancer, birth defects or other reproductive harm.

Licensed by Hyundai Corporation Holdings, Korea.

HWP_Manual_EN_2023-09-22

HWP & HWT SERIES

2HWP & HWT SERIES

This product is supported by Midland Power. Contact us

directly for assistance and warranty help. Do not return this

product to store.

You must register online for your warranty to be valid.

It only takes a minute, do it now while you still have your

purchase receipt.

Support for your product is available online, including

parts, service center locations, and live expert advice.

Or call us anytime at 1-877-528-3772.

www.hyundaipower.ca/register-warranty

Visit us Online at

www.hyundaipower.ca

THIS PRODUCT MEETS ALL CERTIFICATION REQUIREMENTS FROM:

READ THIS ENTIRE GUIDE BEFORE USING THIS

PRODUCT AND SAVE FOR LATER USE.

This user guide contains important instructions including

safety, setup, operation, and maintenance that must be

followed. All information in this guide is based on information

available at the time of print. This guide or revised editions

can be found on our website for download. No part of this

publication may be reproduced without written permission.

Thanks for choosing the HWP & HWT Series!

You're excited to get started, we'll keep this brief.

HWP & HWT SERIES

4HWP & HWT SERIES

TABLE OF CONTENTS

1. Safety 5

2. Learn About Your Water Pump 9

2.1 Component Identiﬁcation (HWP150) 9

2.2 Component Identiﬁcation (HWP270 and HWP370) 10

2.3 Component Identiﬁcation (HWT370) 11

2.4 Identiﬁcation of Controls 12

2.5 Make Sure You Have Everything 14

3. Pre-Operation Check 15

3.1 Check the Oil Level 15

3.2 Check the Fuel Level 17

3.3 Prep the Air Filter 18

3.4 Hose Connections 19

4. Using your Pump 20

4.1 Pump Placement 21

4.2 Priming Water 24

4.3 Starting the Pump 25

4.4 Stopping the Engine 28

5. Maintenance 31

5.1 Maintenance Schedule 31

5.2 Changing the Oil 32

5.3 Air Filter Service 34

5.4 Spark Plug Service 35

5.5 Fuel Sediment Cup Service 36

5.6 Fuel Drainage 37

5.7 Spark Arrester Service 38

5.8 Cleaning 39

5.9 Transportation 40

5.10 Storage 40

5.11 Carburetor Modiﬁcation for High Altitude Operation 41

6. Troubleshooting 43

7. Speciﬁcations 44

8. Pump Assembly 45

9. Limited Warranty 46

1. SAFETY

DANGER!

Using a water pump indoors can kill you in minutes.

The engine exhaust from this product contains chemicals known to cause

cancer, birth defects or other reproductive harm.

1.1 SAFETY WHILE OPERATING YOUR ENGINE

WARNING!

Always perform an oil, fuel and air lter check before starting the engine.

Properly clean and maintain the equipment.

Operate the engine according to instructions for safe and dependable

service.

Before operating the water pump, read the user guide carefully.

Otherwise, personal injuries or equipment damage may occur.

Never run the water pump in an enclosed area to avoid harm from

exhaust emissions of poisonous carbon monoxide gas.

Be careful not to touch the exhaust system, compressor pump or

discharge tubing during operation due to risk of burns.

Pay attention to the warning labels. The engine exhaust system will

become heated during operation and remain hot immediately after the

engine is stopped.

Gasoline is a highly ammable and explosive liquid. Refuel in a well

ventilated area with the engine stopped.

Use of gasoline with an ethanol content greater than 10% can damage

the engine and fuel system and will void the manufacturer’s warranty.

When refueling the water pump, keep it away from cigarettes, open

ames, smoke and/or sparks.

HWP & HWT SERIES

Place the pump at least 5 feet away from buildings or other equipment

during operation.

Run the pump on a level surface. Tilting the water pump may result in fuel

spills.

Know how to stop the water pump quickly and understand operation of

all the controls. Never permit anyone to operate the water pump without

proper instructions.

Keep children, pets and machinery with rotating parts away during

operation.

Do not operate the water pump in rain or snow.

Do not allow any moisture to come in contact with the water pump.

Do not touch the spark plug while the engine is operating or shortly after

the engine has been shut down.

1.2 SAFETY WHILE OPERATING YOUR WATER OR TRASH PUMP

WARNING!

The water pump must not be operated by anyone under the age of 16.

When operating the water pump, keep small children away from the area

of operation.

Never operate the engine when transporting the unit.

Never operate the water pump if you are tired or if you are under the

inuence of alcohol, drugs, colorado river toads, medication or any other

substance that could affect your ability or judgment.

Do not use the water pump to work with ammable liquids such as

gasoline.

Do not use the water pump to work with caustic liquids such as used oil,

milk or wine.

Do not pump liquids and/or chemical solutions such as sea water which

may cause corrosion.

Keep the working water pump at least 1.5 meters away from any static

objects such as cars or buildings in order to ensure proper ventilation and

prevent re hazards.

Never place ammable material close to the engine mufer.

Never overturn the water pump when storing or transporting. Overturning

will cause leakage of vital liquids.

Never smoke or light res near the unit.

Never make unauthorized attachment installations.

Always disconnect the spark plug wire before performing any

6HWP & HWT SERIES

maintenance work.

Always keep the unit as clean as possible. Keep it free of loose

vegetation, mud, etc.

Always be ready to stop the unit immediately if it suddenly begins to

vibrate or shake. Inspect for broken, missing or improperly installed parts.

Never refuel the water pump while the engine is running. Gasoline is very

ammable and may ignite when in contact with hot engine parts.

1.3 MAINTENANCE SAFETY

WARNING!

Use rubber gloves when coming into contact with engine oil.

After any maintenance is performed, wash hands immediately using soap

and clean water because repeated exposure to lubricant may cause skin

irritation.

Do not clean the lter element with ammable liquids like gasoline

because an explosion may occur.

Turn off the engine before performing any maintenance. Otherwise it may

cause severe personal injury or death.

Allow the unit to cool down before performing any maintenance.

Always wear safety glasses when cleaning the unit with compressed air.

Do not clean with a pressure washer because it can cause damage.

Always stop the water pump before removing the oil ller cap.

Only qualied maintenance personnel with knowledge of fuels, electricity,

and machinery hazards should perform maintenance procedures.

Lubricate all exposed metal parts regularly. See maintenance schedule

for more details.

1.4 OTHER SAFETY TIPS

WARNING!

TOXIC FUMES HAZARD. Running engines give oﬀ

carbon monoxide, an odourless poisonous gas

that can cause nausea, fainting, or death. Do

not start engine indoors or in an enclosed area,

even if the windows and doors are open.

DANGER TOXIQUE. Faire fonctionner un moteur dégage de

l’oxyde de carbone, un gaz inodore toxique qui peut

provoquer la nausée, évanouissement ou la mort. Ne

démarrer pas le moteur à l’intérieur ou dans une espace clos,

meme si les fenêtres et les portes sont ouvertes.

HWP & HWT SERIES

To avoid breathing in poisonous carbon monoxide from the exhaust

gases, adequate ventilation should be provided if the engine is running in

a partially enclosed space.

Water and trash pumps vibrate in normal use. During and after use,

inspect the entire unit as well as water hoses and power supply cords

connected to it for damage resulting from vibration. Have damaged

items repaired or replaced as necessary. Do not use plugs or cords that

show signs of damage such as broken or cracked insulation or damaged

blades.

When storing gasoline or equipment with fuel in tank: store away from

furnaces, stoves, water heaters or other appliances that have a pilot light

or other ignition source because they can ignite gasoline vapors.

NOTE

If you start to feel sick, dizzy, or weak after the unit has been running,

move to fresh air RIGHT AWAY. See a doctor. You could have carbon

monoxide poisoning.

8HWP & HWT SERIES

2. LEARN ABOUT YOUR WATER PUMP

This section will show you how to identify key parts of your water/trash pump. Going

over the terminology below will make sure we’re on the same page.

2.1 COMPONENT IDENTIFICATION (HWP150)

Fuel Filler Cap

Mufﬂer

Suction Port

Pump Drain Cap

Discharge Port

Priming Water

Filler Cap

Recoil Starter

Ignition Switch

Air Cleaner

Choke Lever

Oil Filler Cap

& Dipstick

Oil Drain Plug

HWP & HWT SERIES

Otros manuales para HWP Series

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Generador portátil de Hyundai

Hyundai

Hyundai HCP3550 Manual de usuario

Hyundai

Hyundai HG800-A Manual de usuario

Hyundai

Hyundai HPS-300 Manual de usuario

Hyundai

Hyundai HY70100P Manual de lista de piezas

Hyundai

Hyundai TG1000i Manual de usuario

Hyundai

Hyundai HY3800RV Manual de usuario

Hyundai

Hyundai HY3600SEi Manual de usuario

Hyundai

Hyundai HHD1250 Manual de usuario

Hyundai

Hyundai HCP9000 Manual de usuario

Hyundai

Hyundai DHY12000SEV2 Manual de usuario

Hyundai

Hyundai HY2200RV Manual de usuario

Hyundai

Hyundai DHY22KSEm Manual de usuario

Hyundai

Hyundai HomePower HHD3500 Manual de usuario

Hyundai

Hyundai HG3300I-A Manual de usuario

Hyundai

Hyundai HG2700 Manual de usuario

Hyundai

Hyundai HDG5000 Manual de usuario

Hyundai

Hyundai HY3500Ei Manual de usuario

Hyundai

Hyundai HY3000SI Manual de usuario

Hyundai

Hyundai HY2200P Manual de usuario

Hyundai

Hyundai DHY12000SE(-3) Manual de usuario

Hyundai

Hyundai HY3500P Manual de usuario

Hyundai

Hyundai STG1000 Manual de usuario

Hyundai

Hyundai HY12000LE Manual de usuario

Hyundai

Hyundai Hirepro HY3400 Manual de usuario

Manuales populares de Generador portátil de otras marcas

Kohler

Kohler 20EORZ Manual de instrucciones

Powerhorse

Powerhorse 83171 Manual de usuario

HURST

HURST ML-630-SI Manual de usuario

ETQ

ETQ TG4000 Manual de usuario

Briggs & Stratton

Briggs & Stratton 40265 Guía de configuración

ConMed

ConMed 7550 Manual de usuario

Owon

Owon Waveform Generator Manual de usuario

evertz

evertz 7700 Series Manual de usuario

Power Stroke

Power Stroke PS906025 Manual de usuario

Firefly

Firefly Cygnus CYG2400/460/24 Manual de usuario

Draper

Draper PG950S Actualización de firmware

PowerBoss

PowerBoss PowerBoss Manual de usuario

SDMO

SDMO SH 4000 Manual de usuario

EINHELL

EINHELL STE 5500 Manual de usuario

Wanco

Wanco WI3000P Manual de usuario

Full Boar

Full Boar FBT-3300 Manual de usuario

Dwyer Instruments

Dwyer Instruments ASG Manual de usuario

Westinghouse

Westinghouse WH1000i Series Manual de usuario