Host T7 Manual de usuario
Parts Catalog
T7/T71/T73
M40000/M40001/M40003
REPAIR PARTS CATALOG NO. M30202(K)
For machines starting with Serial No. T6183
ISSUED September 2003
ORDERS
Please use part numbers when ordering
and include the serial number of the machine
(stamped on the electrical data plate) to insure
that you will receive the correct parts.
Order from your HOST Distributor.
SAVE THESE INSTRUCTIONS
READ ALL INSTRUCTIONS BEFORE USING THIS APPLIANCE
WHEN USING AN ELECTRICAL APPLIANCE, BASIC PRECAUTIONS SHOULD ALWAYS
BE FOLLOWED, INCLUDING THE FOLLOWING:
WARNING – TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR INJURY
1. Do not leave appliance when plugged in. Unplug from outlet when not in use and
before servicing.
2. Do not use outdoors or on wet surfaces.
3. Do not allow to be used as a toy. Close attention is necessary when used by or near children.
4. Use only as described in this manual. Use only manufacturer’s recommended attachments.
5. Inspect cord for damage before each use. Do not use with damaged cord or plug. If appliance
is not working as it should, has been dropped, damaged, left outdoors, or dropped into water,
return it to a service center.
6. Do not pull or carry by cord, use cord as a handle, close a door on cord, or pull cord
around sharp edges or corners. Do not run appliance over cord. Keep cord away from
heated surfaces.
7. Do not unplug by pulling on cord. To unplug, grasp the plug, not the cord.
8. Do not handle plug or appliance with wet hands.
9. Do not put any object into openings. Do not use with any opening blocked; keep free of dust,
lint, hair, and anything that may reduce air flow.
10. Keep hair, loose clothing, fingers, and all parts of body away from openings and moving parts.
11. Turn off all controls before unplugging.
12. Use extra care when cleaning on stairs.
13. Do not use to pick up flammable or combustible liquids such as gasoline or use in areas where
they may be present.
14. Do not pick up anything that is burning or smoking, such as cigarettes, matches, or hot ashes.
15. Do not use without filters in place.
16. Connect to a properly grounded outlet only. See Grounding Instructions.
17. Always turn off this appliance before connecting or disconnecting either HOST extractorVAC™
or HOST machine.
18. Accessory receptacle is for HOST extractorVAC or dual machine operation only.
19. This appliance is to be used with HOST®carpet cleaning products only. Use of other cleaning
products may damage this appliance.
20. Do not use for picking up health endangering dust such as asbestos.
21. This is a commercial appliance, not intended for household use.
IMPORTANT SAFETY INSTRUCTIONS 2
This appliance must be grounded.
If it should malfunction or break down,
grounding provides a path of least
resistance for electric current to reduce
the risk of electric shock. This appliance
is equipped with a cord having an equipment-grounding conductor and grounding plug.
The plug must be inserted into an appropriate outlet that is properly installed and grounded
in accordance with all local codes and ordinances.
WARNING: Improper connection of the equipment-grounding conductor can result in the risk
of electric shock. Check with a qualified electrician or service person if you are in doubt as to
whether the outlet is properly grounded. Do not modify the plug provided with the appliance.
If it will not fit the outlet, have a proper outlet installed by a qualified electrician.
This appliance is for use on a nominal 120 volt circuit, and has a grounded plug that looks
like the plug illustrated in sketch A. A temporary adapter that looks like the adapter illustrated in
sketches B and C may be used to connect this plug to a 2-pole receptacle as shown in sketch B
if a properly grounded outlet is not available. The temporary adapter should be used only until a
properly grounded outlet (sketch A) can be installed by a qualified electrician. The green colored
rigid ear, lug, or the like extending from the adapter must be connected to a permanent ground
outlet box cover. Whenever the adapter is used, it must be held in place by a metal screw.
Note: In Canada, the use of a temporary adapter is not permitted by the Canadian
Electrical Code.
Grounding Methods
Racine Industries Inc. 1405 Sixteenth Street P.O. Box 1648 Racine, Wisconsin 53401 1-800-558-9439 1-262-637-4491 FAX 1-262-637-0558
GROUNDING INSTRUCTIONS 3
Safety Instructions ____________________________________________________ 2
Grounding Instructions ________________________________________________ 3
Section I - T7/T71/T73 Parts ____________________________________________ 5
Operating Handle Assembly - M30481 __________________________________ 6
Secondary Handle Assembly __________________________________________ 8
Lifting Handle Assembly ______________________________________________ 10
Motor Case Assembly ________________________________________________ 12
Outer Gearcase Assembly ____________________________________________ 14
Inner Gearcase Assembly ______________________________________________ 16
Hood Assembly ______________________________________________________ 18
Brush and Tray Assembly ____________________________________________ 20
Wiring Diagram - 100/120V ____________________________________________ 22
Wiring Diagram - 220/240V ____________________________________________ 23
Section II - M40000/M40001/M40003 VAC Parts ____________________________ 25
Vac Assembly ______________________________________________________ 26
Vac Motor Assembly __________________________________________________ 28
Wiring Diagram - 100/120V ____________________________________________ 30
Wiring Diagram - 220/240V ____________________________________________ 31
TABLE OF CONTENTS 4
Racine Industries Inc. 1405 Sixteenth Street P.O. Box 1648 Racine, Wisconsin 53401 1-800-558-9439 1-262-637-4491 FAX 1-262-637-0558
SECTION I - T7/T71/T73 PARTS 5
OPERATING HANDLE ASSEMBLY 6
2
3
1
4
5
6
7
7
5
8
OPERATING HANDLE ASSEMBLY (M30481) 7
Code No. Part No. Description
1 V818 Button-Twin Lock
2 M7146 Spring
3 V817 Twin Connector
4 M30551 Handle-Pinned & Welded
5 M7020B Cord Hook (2) Required
6 M7131 Cord Clip
7 M7053B Screw 10-32 x 3⁄8" (4) Required
8 M30385 Vinyl Cap
Racine Industries Inc. 1405 Sixteenth Street P.O. Box 1648 Racine, Wisconsin 53401 1-800-558-9439 1-262-637-4491 FAX 1-262-637-0558
FOR MACHINES STARTING WITH SERIAL NO. 6183
ISSUED MARCH 7, 2003
SECONDARY HANDLE ASSEMBLY 8
2
1
SECONDARY HANDLE ASSEMBLY 9
Code No. Part No. Description
1 M30476 Accessory Handle
2 M30478 Knob/Shaft Assembly
Racine Industries Inc. 1405 Sixteenth Street P.O. Box 1648 Racine, Wisconsin 53401 1-800-558-9439 1-262-637-4491 FAX 1-262-637-0558
LIFTING HANDLE ASSEMBLY 10
1
2
4
22
5
6
11
8
79
18
10
19
12
13
14
21
15
16
17
26
27
25
20
23
T7
T71 T73
3
24
FOR MACHINES STARTING WITH SERIAL NO. 6183
ISSUED MARCH 7, 2003
Otros manuales para T7
1
Este manual sirve para los siguientes modelos
5
Tabla de contenidos
Otros manuales de Equipo de limpieza de Host
