Hoshizaki IM-65LE-Q Manual de usuario

NO. E1AH-806

ISSUED: MAY 8, 2010

REVISED:

HOSHIZAKI

SELF-CONTAINED CUBER

MODEL IM-65LE-Q

SERVICE MANUAL

CONTENTS PAGE

1. TIMING CHART----------------------------------------------------------------------------------------1

2. WIRING DIAGRAM -----------------------------------------------------------------------------------2

3. DIP SWITCH SETTING------------------------------------------------------------------------------3

4. SERVICE DIAGNOSIS-------------------------------------------------------------------------------4

5. ADJUSTMENT OF MICRO SWITCH-------------------------------------------------------------5

This service manual provides specific information for IM-65LE-Q only. For any other

information, please refer to the service manual for the standard model IM-65LE.

1. TIMING CHART

IM-65LE-Q

Freeze

State 1,2 3 4 8 9 1,2 4 8

ctuator Toggle Switch Left (Arm Down

)

Right (Arm Up)

S2 Micro Switch (A

)

(Water Pan control) OFF

S3 Micro Switch (B

)

(Cam control) OFF

CM Compresso

OFF

X5 CM/PM Cut Off Relay ON

OFF

FM Fan Moto

OFF

PM Pump Moto

OFF

ctuator Moto

Down

OFF

HV1 Hot Gas Valve ON

OFF

WV Water Valve ON

OFF

Operation

State 1,2 After power supply is turned on or freeze cycle completes, FM starts, water plate opens to reach cam actuating position, and water supply begins for defrost cycle.

State 3 If water plate does not release ice after reaching cam actuating position, ACM and CM stop.

State 4 When water plate releases ice, WV closes and water plate starts to open further.

State 5 When water plate fully opens and S1 moves to left (arm down) position, HV opens. When 3 minutes passes after CM stops in [state 2], CM restarts.

State 6 Cube control thermistor senses temperature higher than defrost setting, water plate starts to close and water supply begins.

State 7 When water plate closes and S1 moves to right (arm up) position, water supply stops and PM starts.

State 8 When 15 seconds passes after S1 moves to right (arm up) position, FM starts and PM stops to start freezing.

State 9 When cube control thermistor senses temperature lower than freeze setting, [state 1] begins.

Defrost

5,6 7

Defrost Freeze

5,6 7 3

th < freeze setting 15 secth > defrost setting 15 sec th > defrost setting

2. WIRING DIAGRAM

3. DIP SWITCH SETTING

Dip Switch No. Volume Setting

Freeze VR

DSW 1 A

Defrost VR

DSW 2 4

Dimple Range

DSW 3 4

Water Supply

DSW 4 0

Code Setting 1

DSW 5 9

Code Setting 2

DSW 6 7

4. SERVICE DIAGNOSIS

This service manual provides specific information for IM-65LE-Q only. For any other

information, please refer to the service manual for the standard model IM-65LE.

PROBLEM POSSIBLE CAUSE REMEDY

[1] Deformed ice. a) Water Pan

Lower Evaporator

1. Upper and Lower Evaporators not

aligned.

1. Readjust.

b) Lower Evaporator 1. Coating damaged, removed or worn. 1. Replace.

[2] Cam Arm will

not stop at a

proper position.

a) Micro Switch (A) 1. Open circuit or moisture inside. 1. Replace.

b) Micro Switch (B) 1. Open circuit or moisture inside. 1. Replace.

5. ADJUSTMENT OF MICRO SWITCH

Actuator Motor Arm

To adjust the Micro Switch (A):

1) Close the Water Pan.

2) Push up the lever until the Micro Switch (A) trips with a click sound. Then, push the

lever 1 mm further up to lock in position. Do not bend the actuator by pushing up the

lever too much.

3) After adjustment, check for proper operation.

To adjust the Micro Switch (B):

1)PushthelooselytSwitchBracketfullytotheleft.

2) Turn the Actuator Motor Arm to position the roller of the Micro Switch (B) as shown

above.

3) Push the Switch Bracket fully to the right until the Micro Switch (B) trips with a click

sound. Then, lock the Switch Bracket in that position.

4) After adjustment, check for proper operation.

Tabla de contenidos

Otros manuales de Máquina de hielo de Hoshizaki

Hoshizaki

Hoshizaki KML-500MAJ Manual de usuario

Hoshizaki

Hoshizaki IM-21CNE Manual de usuario

Hoshizaki

Hoshizaki KM1601SRH350 Manual de usuario

Hoshizaki

Hoshizaki DCM-500BAF Manual de usuario

Hoshizaki

Hoshizaki KM-250BAE Manual de usuario

Hoshizaki

Hoshizaki F-801MAH(-C) Manual de usuario

Hoshizaki

Hoshizaki KMD-201AA Manual de usuario

Hoshizaki

Hoshizaki KML-351MAH Manual de usuario

Hoshizaki

Hoshizaki FM-150AKE-HC-SB Manual de usuario

Hoshizaki

Hoshizaki KM-255BAH Manual de usuario

Hoshizaki

Hoshizaki KM-1300MAF Manual de usuario

Hoshizaki

Hoshizaki F-500BAJ Manual de usuario

Hoshizaki

Hoshizaki FM-1200ALKE Manual de usuario

Hoshizaki

Hoshizaki KM-630MWF Manual de usuario

Hoshizaki

Hoshizaki KMD-460MAH Manual de usuario

Hoshizaki

Hoshizaki KM-630MAB Manual de usuario

Hoshizaki

Hoshizaki KM-80BAJ Manual de usuario

Hoshizaki

Hoshizaki KM-1300SAF Manual de usuario

Hoshizaki

Hoshizaki F-1002MAJ-SC Manual de usuario

Hoshizaki

Hoshizaki KM-320MAH Manual de usuario

Hoshizaki

Hoshizaki F-1001MAH Manual de usuario

Hoshizaki

Hoshizaki KM-40B Manual de usuario

Hoshizaki

Hoshizaki IM-122J Manual de usuario

Hoshizaki

Hoshizaki F-1000MRB Manual de usuario

Manuales populares de Máquina de hielo de otras marcas

Sub-Zero

Sub-Zero 315I Instrucciones de uso

Unold

Unold 48945 Manual de usuario

Kenmore

Kenmore 2217402A Manual de usuario

Cornelius

Cornelius WM600 Instrucciones de funcionamiento

GE XPIO43SCSS Manual de usuario

Whynter

Whynter FIM-450HA Manual de usuario

U-Line

U-Line UMCR014-SC01A Manual de instalación

Andrew James

Andrew James AJ000522 Manual de usuario

Scotsman

Scotsman CME1356 Manual de usuario

Scotsman

Scotsman ACM 25 Manual de usuario

Kärcher

Kärcher IP 120 Manual de usuario

U-Line

U-Line SS1095 Manual de usuario

Maytag

Maytag MIM1554WRS - Ice Maker Manual de usuario

Princess

Princess Yonanas Manual de usuario

Unold

Unold 48946 Manual de usuario

Electrolux

Electrolux E15IM60GP Manual de usuario

Cornelius

Cornelius UC150 ICE ONLY Manual de usuario

Bunn

Bunn BUNN-O-MATIC ULTRA-1 Manual del propietario