HITCHFIRE FORGE 15 Manual de usuario
FORGE 15
OWNER’S MANUAL
Read this manual carefully before assembly, using, or servicing this grill.
FOR OUTDOOR USE ONLY
PATENT PENDING
®
2
TABLE OF CONTENTS
OPERATING INSTRUCTIONS
PARTS LIST
ASSEMBLY & ATTACHING THE GRILL
DEPLOYING THE GRILL
ATTACHING PROPANE
LIGHTING
OPERATING INSTRUCTIONS
CLEANING
ANNUAL MAINTENANCE
WARRANTY
4
7
8
10
12
14
16
18
19
20
3
4
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
This barbecue has been tested to, and complies with
ANSI Z21.89-2017 • CSA 1.18-2017, STANDARDS FOR OUTDOOR COOKING
SPECIALTY GAS APPLIANCES.
If you have questions or need advice regarding your grill or its operation,
please visit us on the web at Hitchfire.com. These instructions will give you
the minimum requirements for assembling your grill.
Please read the instructions carefully before using your grill. Improper
assembly can be dangerous.
If you smell gas:
1. Shut o gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep canister away from the appliance and
immediately call your gas supplier or your fire department.
Leaking gas may cause a fire or explosion, which can cause
serious bodily injury or death, or damage to property.
1. Do not store spare liquid propane cylinder within 10 feet (3m) of
this appliance.
2. Do not store or use gasoline, lighter fluid, kerosene, paint
thinner or other flammable liquids or vapors within 25 feet (8m)
of this appliance.
DANGER
WARNING
OPERATING INSTRUCTIONS
5
SAFETY INFORMATION
CAUTION
If the unit is dropped or sustains any impact, perform a thorough leak
check to ensure no damage to the fuel connections.
WARNINGS
This gas appliance is designed for outdoor use only. Do not use in a
garage, building, breezeway or any other enclosed area. Your Forge 15
should NEVER be placed under any combustible construction or materials.
Do not use the grill within 24 inches of combustible materials, top, bottom,
back or sides of the grill.
Follow all gas leak checking procedures in this manual, prior to operation.
Combustion byproducts produced when using this product contains
chemicals known to the state of California to cause cancer, birth defects, or
other reproductive harm. For more information, go to www.P65Warnings.
ca.gov
Follow all leak-check procedures in this manual carefully prior to
grill operation. Do this even if the grill was dealer assembled.
Do not try to light this appliance without reading the lighting
instructions section of this manual.
Failure to follow the DANGERS, WARNINGS, and CAUTIONS
contained in this owner’s manual may result in serious bodily injury
or death, or in a fire or an explosion causing damage to property.
WARNING
WARNING
DANGERS
6
DO NOT ATTEMPT TO DISCONNECT THE GAS OR ANY GAS FITTING
WHILE THIS APPLIANCE IS IN OPERATION.
While this appliance is not in use, the gas must be turned o at the gas
supply, and the liquid propane tank removed from the appliance.
Liquid propane tanks must be stored outdoors, out of the reach of children
and must not be stored in any building, garage, or other enclosed structure.
NEVER leave the barbecue unattended while in operation.
NEVER allow children to operate this barbecue.
NEVER lean over an open BBQ, or place hands or fingers on the top of the
cooking basin.
Use heat-resistant BBQ mitts or gloves when operating this barbecue.
Should a grease fire occur, turn o all burners, and stay away from the
barbecue until the fire is out.
DO NOT use charcoal briquettes, lava rocks or other lighter fluid in this grill.
While this appliance is not in use, place under a cover to protect it from the
weather and other adverse elements.
Storage of this appliance indoors is permissible only if the propane cylinder
tank is disconnected and removed from the appliance. Never move units
with propane tank installed.
This grill is not intended for and should never be used as a heater.
The use of alcohol, prescription or non-prescription drugs may impair the
consumer’s ability to properly assemble or safely operate the appliance.
Minimum back clearance to combustible material: 10 inches.
7
PARTS LIST
8
ASSEMBLY - ATTACHING THE GRILL
Slide the swing away arm assembly
into your hitch and secure it with
the hitch stabilizer bolt.
A.Pull out and twist the hinge spring lock.
B.Release the slam-latch by pressing
down on the lever.
Swing the arm away from the vehicle and
lock at the 90 degree position for stability.
Place the grill head onto the arm.
Thread the knob into the arm collar clamp.
Do not over-tighten. Slide the cotter pin
through the hole at the end of the bolt.
Tighten the arm collar. Lock the grill head
onto the arm with a padlock. (Not included.)
Tighten the bolt using
a wrench, make sure
to tighten the bolt all
the way through to
the other side of the
hitch, slide the cotter
pin into the bolt.
DO NOT MOVE VEHICLE UNLESS THE
SWING AWAY ARM ASSEMBLY IS
SECURELY BOLTED ONTO THE HITCH.
DO NOT MOVE VEHICLE UNLESS THE
GRILL HEAD IS LOCKED IN PLACE.
1 2
3
4
5
A
B
9
Rotate the hinge spring lock to
engage the plunger.
Swing the arm closed, pushing towards the
vehicle until the slam-latch is fully engaged.
Make sure that the side tables are folded
securely under the grill hood.
Close the hood latch, hinge
spring lock and slam-latch.
DO NOT DRIVE WITH A PROPANE
CYLINDER INSTALLED ON THE GRILL.
DO NOT MOVE VEHICLE UNLESS THE
HOOD LATCH, HINGE SPRING LOCK &
SLAM-LATCH ARE SECURE.
6 7
8If the Forge 15 blocks the visibility of your
vehicle’s license plate, remove the license
plate and mount it on the temporary license
plate bracket on the upper swing arm as
shown. Be sure to replace the license plate
when you remove the Forge 15 from your
vehicle.
9
10
DEPLOYING THE GRILL
A. Pull out and twist the hinge spring lock.
B. Release the slam-latch by pressing down
on the lever.
Swing the swing-away arm and grill away
from the vehicle.
Rotate the hinge spring lock to lock the
arm’s position at either 90 or 180 degrees.
Remove the padlock (not included) that
locks the collar to the arm. Loosen the
rotation knob on the arm collar.
Rotate the grill head to the desired position
and tighten rotation knob on the arm collar.
Follow the cooking instructions on the next
page.
1 2
4
3
A
B
Tabla de contenidos
