Goldmedal P-60 Manual de usuario

Part No.49064

P-60 / 60 Special

Instruction Manual

Model No.1866, 1866XJ, 2085, 2086, 2656, 2656KC

1866, 1866XJ, 2086 2085, 2656 2656KC

Cincinnati, OH 45241-4807 SA

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 2

SAFETY PRECA TIONS

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 3

GENERAL INSTR CTIONS

INSPECTION OF SHIPMENT

npack all cartons and check thoroughly for any damage that may have occurred during transit. Damage

claims should be filed immediately with the transportation company.

SET P

Your new Popper was assembled and tested at the factory. Remove all packing material and tape before

starting operation.

ELECTRICAL REQ IREMENTS

Models 1866, 2086, 2085: 120V, 60Hz, 1220W

Models 2656, 2656KC: 120V, 60Hz, 1300W

Model 1866XJ: 100V, 50/60Hz, 1220W

Your electrician must furnish sufficient power for proper machine operation. We recommend this popper

be on a dedicated and protected circuit. Failure to wire properly will void the warranty and may result in

damage to the machine.

It is Gold Medal® Products Company’s recommendation that this machine be plugged directly into a wall

outlet. The use of extension cords is not recommended. This may cause sacrificed and/or reduced

performance and can become a safety hazard.

BEFORE YO PL G IN THE MACHINE

1. Make sure the wall outlet can accept the grounded plugs (where applicable) on the power supply

cord.

2. The wall outlet must have the proper polarity. If in doubt, have a competent electrician inspect

the outlet and correct if necessary.

3. DO NOT use a grounded to un-grounded receptacle adapter.

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 4

OPERATING INSTR CTIONS

CONTROLS AND THEIR F NCTIONS

LIGHT AND WARMER SWITCH: Turns on the heat to the bottom corn pan and heat light.

KETTLE MOTOR SWITCH: Turns on the motor which drives the kettle agitator.

KETTLE HEAT SWITCH: Supplies power to the thermostat controlled kettle

A TO SH T OFF

The 1866 and 2656 Models are equipped with an auto shut-off mechanism. If the kettle heat is on with no

product popping for fifteen minutes, the auto shut-off will turn off the kettle heat element and the kettle

heat switch will flash. To pop a new batch of corn, cycle the kettle heat switch off and then back on.

AMO NT OF POPCORN AND OIL

Your new Popper is equipped with a 6 oz corn measuring cup (Part No. 49049).

Corn charge – 6 oz.

Oil charge – 1.6 to 2.0 oz.

Flavacol – 1 teaspoon

POPPING INSTR CTIONS

1. Turn Kettle Heat and Kettle Motor switch on.

2. Make a test pop by putting 3 kernels of corn and 1 oz. (30 ml) of oil into the kettle.

3. When the 3 kernels have popped, load the kettle with corn and oil charge.

4. When corn has popped, dump the kettle.

5. Repeat cycle starting with step number 3 above; always pop 3-5 batches for best popcorn.

Kettle Heat Switch

Part No. 42798 (1)

Kettle Motor Switch

Part No. 42532 (2)

Light And Warmer Switch

Part No. 42532 (2)

Switch Box Label

Part No. 48502 (1)

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 5

CARE AND CLEANING

KETTLE

1. Each time you finish a series of popping, allow the kettle to cool down and wipe the outside of the

kettle with a soft cloth to remove any oil drippings left behind.

2. After you finish popping for the day, allow the kettle to cool until it is not too hot to handle, but

still warm.

3. nplug the kettle and remove it from the machine.

4. With a cloth, wipe out the inside of the kettle, kettle lid, crossbar, outside and underneath of the

kettle.

NOTE: DO NOT place the kettle in water. This will cause damage to the electrical components and will

void your warranty.

CABINET

Cleaning the cabinet of your machine is easy. Take a clean cloth and wipe excess grease from the glass.

Wipe the outside of the machine also.

NOTE: Never use a glass or plastic cleaner that contains ammonia. It will crack the plastic on the machine.

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 6

MAINTENANCE INSTR CTIONS

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 7

ORDERING SPARE PARTS

1. Identify the worn or broken part by checking it with the illustrations and parts list.

2. When ordering parts, include part number, part name, and quantity required.

3. Include your model name and machine serial number (found on nameplate) with your order.

4. Address orders to:

Parts Department

Gold Medal® Products Co.

10700 Medallion Drive

Cincinnati, Ohio 45241-4807

Or place orders at:

(800) 543-0862

(513) 769-7676

Fax: (513) 769-8500

E-mail

: info@gmpopcorn.com

www.gmpopcorn.com

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 8

Number Part No Description Quantity

147060 Spur Gear 1

243434 Agitator Bearing Hub 1

347106 Needle Bearing 1

441742 Set Screw 3

569710 Agitator S aft 1

649017 Front Lid Wit Formed Lifter 1

749016 Rear Kettle Lid 1

859102 Crossbar Assembly 1

969714 Stir Rod 1

10 46649 Set Collar 3

11 47110 Knob Dump Handle 1

12 49314 RH Dump Handle 1

13 49362 Spacer Dump Handle 1

14 49328 Kettle Lead Assembly 1

15 47193 T ermostat S unt Bar 1

16 76702 T ermostat 525°F 1

17 76089 T ermostat 450°F 1

18 56006 Kettle / Heater 780W 1

19 49431 6Oz Kettle S ell 1

20 49368 Kettle Gasket 1

21 69715 Agitator Weig t 1

KETTLE BREAKDOWN

Kettle Part No. 56000

Relevant Models: 1866, 2085, 2086, 2656

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 9

ITEM PART NO MODEL(S) PART NAME QTY

147060 BOTH Spur Gear 1

243434 BOTH Agitator Bearing Hub 1

347106 BOTH Needle Bearing 1

441742 BOTH Set Screw 4

569710 BOTH Agitator S aft 1

649017 BOTH Front Lid Wit Formed Lifter 1

749016 BOTH Rear Kettle Lid 1

49471N 2656KC Crossbar Assembly 1

49471XJN 1866XJ Crossbar Assembly 1

969714 BOTH Stir Rod 1

10 46649 BOTH Set Collar 3

47123 2656KC Knob Dump Handle Red 1

47110 1866XJ Knob Dump Handle 1

12 49314 BOTH RH Dump Handle 1

13 49362 BOTH Spacer Dump Handle 1

76707 2656KC 420 °F T ermostat 1

76089 1866XJ 450 °F T ermostat 1

15 76702 BOTH 525 °F T ermostat 1

16 47193 BOTH T ermostat S unt Bar 1

17 49532 BOTH Element Clamp 1

18 49328 BOTH Kettle Lead In Assembly 1

46652 2656KC 850W Tubular Element 1

48739 1866XJ Tubular Element 850W 100V 1

20 49431 BOTH Kettle S ell 1

21 49368 BOTH Kettle Gasket 1

49432 2656KC Kettle Weld Assembly 1

49596 1866XJ 6oz. Clad Kettle Weld Assy. 1

23 69715 BOTH Agitator Weig t 1

KETTLE BREAKDOWN

Kettle Part No. 49434KC (Model 2656KC)

49434XJN (Model 1866XJ)

P-60/60 Special Model No. 1866, 1866XJ, 2085, 2086, 2656, 2656KC

ttp://www.gmpopcorn.com Page 10

CABINET BREAKDOWN

Models No. ALL (2085-2656 S own)

Otros manuales para P-60

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Electrodoméstico de cocina de Goldmedal

Goldmedal

Goldmedal 2011 Series Manual de usuario

Goldmedal

Goldmedal ReadyPop Jr. 2793 Series Manual de usuario

Goldmedal

Goldmedal Karmel King Manual de usuario

Goldmedal

Goldmedal Astro Pop 16oz Series Manual de usuario

Goldmedal

Goldmedal 4180 Manual de usuario

Goldmedal

Goldmedal Pop-O-Gold Manual de usuario

Goldmedal

Goldmedal 2656KC Manual de usuario

Goldmedal

Goldmedal Gay 90 Whiz Bang Manual de usuario

Goldmedal

Goldmedal 2018 Manual de usuario

Goldmedal

Goldmedal 2404 Series Manual de usuario

Goldmedal

Goldmedal Super Floss 3038EDX Manual de usuario

Goldmedal

Goldmedal Tornado SHO 3007 Manual de usuario

Goldmedal

Goldmedal Whiz Bang Manual de usuario

Goldmedal

Goldmedal Citation Manual de usuario

Goldmedal

Goldmedal The Breeze 3030-00-000 Manual de usuario

Goldmedal

Goldmedal 4008 Manual de usuario

Goldmedal

Goldmedal 5081 Manual de usuario

Goldmedal

Goldmedal G-Whiz 5908 Manual de usuario

Goldmedal

Goldmedal 2660SR Manual de usuario

Goldmedal

Goldmedal The Breeze EZ Kleen Head Manual de usuario

Goldmedal

Goldmedal 1871EX Manual de usuario

Goldmedal

Goldmedal Steamin’ Demon Manual de usuario

Goldmedal

Goldmedal 2102E Manual de usuario

Goldmedal

Goldmedal SunnyPop 2552-00-012 Manual de usuario

Manuales populares de Electrodoméstico de cocina de otras marcas

Tayama

Tayama TYG-35AF Manual de usuario

AEG

AEG 43172V-MN Manual de usuario

REBER

REBER Professional 40 Guía del usuario

North American

North American BB12482G / TR-F-04-B-NCT-1 Manual de usuario

Presto

Presto fountain popper Manual de usuario

Westmark

Westmark 1035 2260 Manual de usuario

Zanussi

Zanussi ZCG64396XA Manual de usuario

HOFFEN

HOFFEN SM-9302M Manual de usuario

Philips

Philips HD3133 Manual de usuario

Ronco

Ronco Beef Jerky Manual de usuario

Hendi

Hendi 470411 Manual de usuario

Livoo

Livoo MEN386 Manual de usuario

Vogue

Vogue D446 Manual de usuario

croydon

croydon WR-10313-700 Manual de usuario

ADE

ADE AUTOMATIC-L Manual de usuario

Chefman

Chefman RJ43-SQ Series Manual de usuario

Vacmaster

Vacmaster VP680 Manual de usuario

Jetmaster

Jetmaster 900HG Manual de usuario