Goldmedal Master Pop 2451 Manual de usuario

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 3

INSTALLATION AND OPERATING INSTRUCTIONS

CHECKING SHIPMENT

Unpack all cartons and check thoroughly for any damage which might have occurred in transit. Damage

claims should be filed immediately with the transportation company.

ELECTRICAL REQUIREMENTS

2451: 120V, 875W, 60Hz

2451EX: 230V, 875W, 50Hz

If in doubt, your electrician must furnish sufficient power for proper machine operation. We recommend

this popper be on a dedicated and protected circuit. Failure to wire properly will void the warranty and

may result in damage to the machine. It is Gold Medal® Products Company’s recommendation that this

machine be plugged directly into a wall outlet. The use of extension cords is not recommended due to

safety concerns, and may cause sacrificed and/or reduced performance.

INSTALLATION

Your Master Pop and Kettle were adjusted, inspected, and tested before it left the factory. Remove all

packing before setting up your new Master Pop. Hang the kettle on the hanger assembly attached to the

celling of your Master Pop. Finally, make sure to plug the power cord of your kettle into the power

receptacle located on the celling of your popper.

CONTROLS AND THEIR FUNCTIONS

LIGHT AND WARMER SWITCH – Turns on the heat light.

KETTLE MOTOR SWITCH – Turns on the motor which drives kettle agitator shaft.

KETTLE HEAT SWITCH – Turns on the kettle heat element

AMOUNT OF POPCORN AND OIL

Your new Master Pop is equipped with a 6 oz corn measuring cup (Part No. 49049).

Corn charge – 6 oz.

Oil charge – 1.6 to 2.0 oz.

Flavacol – 1 teaspoon

POPPING INSTRUCTIONS

1. Turn Kettle Heat and Kettle Motor switch on.

2. Make a test pop by putting 3 kernels of corn and 1 oz. (30 ml) of oil into the kettle.

3. When the 3 kernels have popped, load the kettle with corn and oil charge.

4. When corn has popped, dump the kettle.

5. Repeat cycle starting with step number 3 above; always pop 3-5 batches for best popcorn.

DPST Rocker Switch (3)

Part No. 42532

Switch Label (1)

Part No. 49840

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 3

INSTALLATION AND OPERATING INSTRUCTIONS

CHECKING SHIPMENT

Unpack all cartons and check thoroughly for any damage which might have occurred in transit. Damage

claims should be filed immediately with the transportation company.

ELECTRICAL REQUIREMENTS

2451: 120V, 875W, 60Hz

2451EX: 230V, 875W, 50Hz

If in doubt, your electrician must furnish sufficient power for proper machine operation. We recommend

this popper be on a dedicated and protected circuit. Failure to wire properly will void the warranty and

may result in damage to the machine. It is Gold Medal® Products Company’s recommendation that this

machine be plugged directly into a wall outlet. The use of extension cords is not recommended due to

safety concerns, and may cause sacrificed and/or reduced performance.

INSTALLATION

Your Master Pop and Kettle were adjusted, inspected, and tested before it left the factory. Remove all

packing before setting up your new Master Pop. Hang the kettle on the hanger assembly attached to the

celling of your Master Pop. Finally, make sure to plug the power cord of your kettle into the power

receptacle located on the celling of your popper.

CONTROLS AND THEIR FUNCTIONS

LIGHT AND WARMER SWITCH – Turns on the heat light.

KETTLE MOTOR SWITCH – Turns on the motor which drives kettle agitator shaft.

KETTLE HEAT SWITCH – Turns on the kettle heat element

AMOUNT OF POPCORN AND OIL

Your new Master Pop is equipped with a 6 oz corn measuring cup (Part No. 49049).

Corn charge – 6 oz.

Oil charge – 1.6 to 2.0 oz.

Flavacol – 1 teaspoon

POPPING INSTRUCTIONS

1. Turn Kettle Heat and Kettle Motor switch on.

2. Make a test pop by putting 3 kernels of corn and 1 oz. (30 ml) of oil into the kettle.

3. When the 3 kernels have popped, load the kettle with corn and oil charge.

4. When corn has popped, dump the kettle.

5. Repeat cycle starting with step number 3 above; always pop 3-5 batches for best popcorn.

DPST Rocker Switch (3)

Part No. 42532

Switch Label (1)

Part No. 49840

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 3

INSTALLATION AND OPERATING INSTRUCTIONS

CHECKING SHIPMENT

Unpack all cartons and check thoroughly for any damage which might have occurred in transit. Damage

claims should be filed immediately with the transportation company.

ELECTRICAL REQUIREMENTS

2451: 120V, 875W, 60Hz

2451EX: 230V, 875W, 50Hz

If in doubt, your electrician must furnish sufficient power for proper machine operation. We recommend

this popper be on a dedicated and protected circuit. Failure to wire properly will void the warranty and

may result in damage to the machine. It is Gold Medal® Products Company’s recommendation that this

machine be plugged directly into a wall outlet. The use of extension cords is not recommended due to

safety concerns, and may cause sacrificed and/or reduced performance.

INSTALLATION

Your Master Pop and Kettle were adjusted, inspected, and tested before it left the factory. Remove all

packing before setting up your new Master Pop. Hang the kettle on the hanger assembly attached to the

celling of your Master Pop. Finally, make sure to plug the power cord of your kettle into the power

receptacle located on the celling of your popper.

CONTROLS AND THEIR FUNCTIONS

LIGHT AND WARMER SWITCH – Turns on the heat light.

KETTLE MOTOR SWITCH – Turns on the motor which drives kettle agitator shaft.

KETTLE HEAT SWITCH – Turns on the kettle heat element

AMOUNT OF POPCORN AND OIL

Your new Master Pop is equipped with a 6 oz corn measuring cup (Part No. 49049).

Corn charge – 6 oz.

Oil charge – 1.6 to 2.0 oz.

Flavacol – 1 teaspoon

POPPING INSTRUCTIONS

1. Turn Kettle Heat and Kettle Motor switch on.

2. Make a test pop by putting 3 kernels of corn and 1 oz. (30 ml) of oil into the kettle.

3. When the 3 kernels have popped, load the kettle with corn and oil charge.

4. When corn has popped, dump the kettle.

5. Repeat cycle starting with step number 3 above; always pop 3-5 batches for best popcorn.

DPST Rocker Switch (3)

Part No. 42532

Switch Label (1)

Part No. 49840

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 6

ORDERING SPARE PARTS

1. Identify the worn or broken part by checking it with the illustrations and parts list.

2. When ordering parts, include part number, part name, and quantity required.

3. Include your model name and machine serial number (found on nameplate) with your order.

4. Address orders to:

Parts Department

Gold Medal®Products Co.

10700 Medallion Drive

Cincinnati, Ohio 45241-4807

Or place orders at:

(800) 543-0862

(513) 769-7676

Fax: (513) 769-8500

E-mail: [email protected]

www.gmpopcorn.com

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 7

KETTLE BREAKDOWN

Kettle Part No. 56000, 49434EXN

Model No. 56000 Bottom Assembly Model No. 49434EXN Bottom Assembly

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 7

KETTLE BREAKDOWN

Kettle Part No. 56000, 49434EXN

Model No. 56000 Bottom Assembly Model No. 49434EXN Bottom Assembly

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 7

KETTLE BREAKDOWN

Kettle Part No. 56000, 49434EXN

Model No. 56000 Bottom Assembly Model No. 49434EXN Bottom Assembly

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 7

KETTLE BREAKDOWN

Kettle Part No. 56000, 49434EXN

Model No. 56000 Bottom Assembly Model No. 49434EXN Bottom Assembly

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 8

ITEM PART NO. MODEL(S) PART NAME QTY.

147060 ALL Spur Gear 1

243434 ALL Agitator Bearing Hub 1

347106 ALL Needle Bearing 1

441742 ALL Set Screw 3

569710 ALL Agitator Shaft 1

649017 ALL Front Lid With Formend Lifter 1

749016 ALL Rear Kettle Lid 1

59102 56000 Crossbar Assembly 1

49471EXN 49434EXN Crossbar Assembly 1

969714 ALL Stir Rod 1

10 46649 ALL Set Collar 3

11 47110 ALL Knob Dump Handle 1

12 49314 ALL RH Dump Handle 1

13 49362 ALL Spacer Dump Handle 1

49328 56000 Kettle Lead Assembly 1

49490 49434EXN Export Kettle Lead Assembly 1

15 47193 56000 Thermostat Shunt Bar 1

16 76702 56000

Thermostat 525 °F 1

76089 56000

Thermostat 450 °F 1

76089 49434EXN

Thermostat 450 °F 2

56006 56000 Kettle/Heater 780W 1

46652EX 49434EXN 850W Tubular Element 1

19 49431 ALL 6 oz Kettle Shell 1

20 49368 ALL Kettle Gasket 1

21 49532 49434EXN Element Clamp 1

22 69715 ALL Kettle Weight 1

23 49596 49434EXN 6 oz Clad Kettle Assembly 1

KETTLE BREAKDOWN PARTS LIST

Kettle Part No. 56000, 49434EXN

Master Pop Model No. 2451, 2451EX

http://www.gmpopcorn.com Page 8

ITEM PART NO. MODEL(S) PART NAME QTY.

147060 ALL Spur Gear 1

243434 ALL Agitator Bearing Hub 1

347106 ALL Needle Bearing 1

441742 ALL Set Screw 3

569710 ALL Agitator Shaft 1

649017 ALL Front Lid With Formend Lifter 1

749016 ALL Rear Kettle Lid 1

59102 56000 Crossbar Assembly 1

49471EXN 49434EXN Crossbar Assembly 1

969714 ALL Stir Rod 1

10 46649 ALL Set Collar 3

11 47110 ALL Knob Dump Handle 1

12 49314 ALL RH Dump Handle 1

13 49362 ALL Spacer Dump Handle 1

49328 56000 Kettle Lead Assembly 1

49490 49434EXN Export Kettle Lead Assembly 1

15 47193 56000 Thermostat Shunt Bar 1

16 76702 56000

Thermostat 525 °F 1

76089 56000

Thermostat 450 °F 1

76089 49434EXN

Thermostat 450 °F 2

56006 56000 Kettle/Heater 780W 1

46652EX 49434EXN 850W Tubular Element 1

19 49431 ALL 6 oz Kettle Shell 1

20 49368 ALL Kettle Gasket 1

21 49532 49434EXN Element Clamp 1

22 69715 ALL Kettle Weight 1

23 49596 49434EXN 6 oz Clad Kettle Assembly 1

KETTLE BREAKDOWN PARTS LIST

Kettle Part No. 56000, 49434EXN

Otros manuales para Master Pop 2451

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Electrodoméstico de cocina de Goldmedal

Goldmedal

Goldmedal 2408 Manual de usuario

Goldmedal

Goldmedal 2343 Manual de usuario

Goldmedal

Goldmedal 5081 Manual de usuario

Goldmedal

Goldmedal Karmel King Manual de usuario

Goldmedal

Goldmedal Econo-Floss Manual de usuario

Goldmedal

Goldmedal Mark 10 Manual de usuario

Goldmedal

Goldmedal Dogeroo Manual de usuario

Goldmedal

Goldmedal UNIFLOSS Manual de usuario

Goldmedal

Goldmedal 2022 Manual de usuario

Goldmedal

Goldmedal Pop Maxx Series Manual de usuario

Goldmedal

Goldmedal 2018 Manual de usuario

Goldmedal

Goldmedal Top Half Antique Unifloss 3119 Series Manual de usuario

Goldmedal

Goldmedal 2404SC Guía de configuración

Goldmedal

Goldmedal Astro Pop 2023ETS Manual de usuario

Goldmedal

Goldmedal Econo-Floss Manual de usuario

Goldmedal

Goldmedal Citation Manual de usuario

Goldmedal

Goldmedal Macho Pop 2553 Series Manual de usuario

Goldmedal

Goldmedal 2551 Manual de usuario

Goldmedal

Goldmedal Pop Maxx 2552 Manual de usuario

Goldmedal

Goldmedal 2556 Manual de usuario

Goldmedal

Goldmedal Whiz Bang 2003 Manual de usuario

Goldmedal

Goldmedal Econo 8 Manual de usuario

Goldmedal

Goldmedal 4180 Manual de usuario

Goldmedal

Goldmedal 1866 Manual de usuario

Manuales populares de Electrodoméstico de cocina de otras marcas

Tayama

Tayama TYG-35AF Manual de usuario

AEG

AEG 43172V-MN Manual de usuario

REBER

REBER Professional 40 Guía del usuario

North American

North American BB12482G / TR-F-04-B-NCT-1 Manual de usuario

Presto

Presto fountain popper Manual de usuario

Westmark

Westmark 1035 2260 Manual de usuario

Zanussi

Zanussi ZCG64396XA Manual de usuario

HOFFEN

HOFFEN SM-9302M Manual de usuario

Philips

Philips HD3133 Manual de usuario

Ronco

Ronco Beef Jerky Manual de usuario

Hendi

Hendi 470411 Manual de usuario

Livoo

Livoo MEN386 Manual de usuario

Vogue

Vogue D446 Manual de usuario

croydon

croydon WR-10313-700 Manual de usuario

ADE

ADE AUTOMATIC-L Manual de usuario

Chefman

Chefman RJ43-SQ Series Manual de usuario

Vacmaster

Vacmaster VP680 Manual de usuario

Jetmaster

Jetmaster 900HG Manual de usuario