FUNKY MONKEY BARS SWINGING CUBBY Manual de usuario

SWINGING CUBBY

ASSEMBLY INSTRUCTIONS

CONTENTS

Warnings and Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 1

Assembly Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 3

Inventory and Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 4

Assembly Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 5

Swing Hook . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 5

Metal Tubes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 6

Swinging Cubby. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 8

Secure Swinging Cubby . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 9

Final Checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 10

Page 1

SAFETY NOTICE

WARNINGS

1. Choking hazard-small parts, not for children under 3 years.

2. Maximum weight should not exceed 180kg.

3. Do not use without adult supervision!

4. Adult assembling required!

ESSENTIAL INFORMATION

1. Recommended for children 3+ years.

2. Do not leave child unattended while in use.

3. CAUTION: Use only under adult supervision.

4. Do not attach foreign items that are not designed for equipment use.

5. Only use this product on Funky Monkey Bars®

6. Good safety practices should be followed at all times.

7. Read all instruction before using this product.

8. Intended solely for family and domestic use, not for a commercial playground or daycare. Two adults

needed for assembly. Maximum weight capacity: 180kg.

9. Hanging hardware included. Ideally, the swing body should be hung over grass, sand, wood chips, or

other soft surfaces. Under no circumstances should it be hung over concrete, asphalt, or other hard

surfaces. Distance to ground should not exceed 450mm or be less than 350mm from the ground.

10. Please be sure to examine the ropes regularly to check for wear. Rope will, in time, degrade. If the color of

the rope has become pale, frays easily, or gives off a powdery material when rubbed between the fingers,

we recommend you replace the rope.

11. Equipment should be hung in such a way that a distance of at least 450mm is clear on either side.

LOCATION

1. A safe fall zone around your Funky Monkey Bars® is essential. A minimum distance of 1.5m to 2m (5 ft to

6.5ft) is recommended around the elevated hanging points of your Funky Monkey Bars®.

2. Place your Funky Monkey Bars® on level ground, away from any structure or obstruction such as a fence,

garage, house, overhanging branches, laundry lines or electrical wires and remove any obstructions

beneath your Funky Monkey Bars®.

3. Ensure your Funky Monkey Bars® are positioned away from retaining walls, pool fences, structures and

other play equipment. Maintain a clear space around the whole perimeter of your Funky Monkey Bars®.

4. Place your Funky Monkey Bars® on the most level surface available.

WARNING

RISK OF SERIOUS INJURY

PLEASE CAREFULLY READ ALL INFORMATION CONTAINED IN THIS ASSEMBLY MANUAL BEFORE

YOU INSTALL AND USE YOUR FUNKY MONKEY BARS® TENT SWING.

WARNINGS

Page 2

ENSURING SAFETY ON THE SWINGING CUBBY

1. Clearance distance should be 450mm around the swing.

2. A fall onto a hard surface can result in serious injury to the equipment user.

3. Do not use the equipment until properly installed.

4. Do not modify or alter equipment

5. This swing is not to be used in any other manner other than its intended use; to sit, lay and swing from inside the swing.

6. Adult supervision is required.

7. It is important for adults to instruct children to:

• Dress appropriately while using the swing (avoid ponchos, scarves, and other loose-fitting clothing that is

potentially hazardous).

• Sit in the center of the swing with full weight on the seat if swinging alone.

• Avoid swinging empty seats.

• Check the temperature of the surface before use in warm/hot weather.

8. It is important for adults to instruct children NOT to:

• Walk close to, in front of, behind, or between moving items.

• Twist ropes or loop them over the top support bar since such action may reduce the strength of the rope.

• Get off the sing while it is in motion.

• Climb on top of the equipment

• Use when it is wet.

• Attach additional items to the swing that might cause a strangulation hazard.

• Wear a bicycle or sport helmet while on the swing.

MAINTENANCE

1. At the beginning of each heavy play session we recommend the following maintenance processes be performed

on your Funky Monkey Bars®:

• Tighten all bolts, grub screws and applicable hardware (as per page 9)

• Lubricate all metallic moving parts as per instructions (flying fox, swing hooks etc)

• Check all protective coverings on bolts, pipes, edges and corners. Replace if they are loose,

cracked or missing.

• Check all moving parts including swing seats, shackles, snap hooks, chains and trolleys for wear,

rust, or other deterioration. Replace as needed.

2. Twice a month during play season we would recommend the following maintenance processes be

performed on your Funky Monkey Bars®:

• Tighten all connections and hardware

• Check all protective coverings on bolts, pipes, edges and corners. Replace if they are loose,

cracked or missing.

3. Once a month during play season we would recommend the following maintenance processes be

performed on your Funky Monkey Bars®:

• Lubricate all metallic moving parts as per instructions (flying fox, swing hooks etc). If swings start

to squeak then lubricate swing hooks.

• Check all moving parts including swing seats, ropes, chains and trolleys for wear, rust, or other

deterioration. Replace as needed.

• Owners shall be responsible for maintaining the legibility of any warning labels.

At the end of each play season, or when the temperature falls below 4°C or is above 40°C, adults should:

• Remove the swing from its outdoor location.

• Store the swing in a dry environment away from the elements to prolong life of product.

For additional information concerning your Funky Monkey Bars®, please contact our customer service team or check our

website for any important updates. Phone 1300 912 198 or www.funkymonkeybars.com

SAFETY

All tubes must be fully inserted

until contact is made with

adjoining tube.

CORRECT INSERTION INTO FITTINGS - (indicative diagram shown)

CORRECT TIGHTENING METHOD OF GRUB SCREWS - (indicative diagram shown)

Gap. No gap.

CLUNK

1. With long end of allen key, hand

tighten grub screw as much as possible.

2. Using other end of the allen key do one full

360 degree turn as a minimum, use muscles!

+ 360

CORRECT TIGHTENING OF SWING HOOKS - (indicative diagram shown)

1. Slide the swing hook along the

tube until the desired location.

2. Fully tighten bolt on swing hook

to clamp tightly onto tube. Failure

to do so can result in serious injury.

Page 3

ASSEMBLY TIPS

INVENTORY - (not to scale)

Pillow

Metal Tubes

Cubby Canopy

Cubby Swing Seat

Page 4

8mm Allen key

(Not included)

Soft Hammer

(Not included)

TOOLS REQUIRED FOR INSTALLATION - (varies for each accessory)

Spirit Level

(Not included)

3m Step Ladder

(Not included)

Tape Measure

(Not included)

17mm Rachet

(Not included)

Swing Hook

Carabiner

INVENTORY

Swivel

Shackle

Page 5

ASSEMBLY INSTRUCTIONS - SWING HOOK

Swing Leg

Swing Bar

2LAY OUT CUBBY SWING SEAT

1. On flat level ground lay out the cubby swing seat.

2. Find the door opening (where there is a larger gap between hanging ropes)

and the zip on the opposite side.

Door Position

Zip

Cubby Swing Seat

+ 360

Fully tighten all fitting grub screws and swing hook bolts.

1INSTALL SWING HOOKS AND TIGHTEN BOLTS

1. Position swing hook on an accessories bar.

2. Loosen any necessary fittings and slide swing hook onto accessories tube into

central location.

Ensure the swing hook is placed away from other approved Funky Monkey Bars®

accessories and is spaced 1200mm apart from any other swing hook or fitting.

3. Fully re-tighten any loosened fittings.

4. Fully tighten swing hook bolts.

FAILURE TO DO SO COULD RESULT

IN SERIOUS INJURY OR DEATH.

Centre or 1200mm min

Swing Hook

Accessories Bar

(Not included)

Page 6

3INSERT METAL TUBE

1. Open zip along back sleeve edge.

2. Insert the first metal tube into the sleeve - push button end first.

3. Insert 3/4 of the way.

Open zip. Insert metal tube into sleeve other end.

Metal Tube

Cubby Swing Seat

from step 2

ASSEMBLY INSTRUCTIONS - METAL TUBES

Page 7

4INSERT SECOND METAL TUBE

1. Insert second metal tube into first metal tube in

sleeve (small end into large end of first tube).

2. Connect and lock the tubes together by pressing

the small button as shown below.

Metal Tube

5INSERT REMAINING METAL TUBES

1. Repeat this process of inserting the metal

tubes until all tubes are inserted and

connected in the sleeve.

2. Close zip .

Close zip.

6x Metal Tubes

6ASSEMBLE SWINGING CUBBY

1. Fit the cubby canopy over cubby swing

seat by pulling hanging bracket through

top hole ‘A, in cubby canopy.

2. Align the door gap on the cubby

seat with the cubby canopy.

(where there is a larger gap

between the hanging ropes)

2. Ensure the strap at the top of the

canopy is undone (A). and the buckles

under the door access (B) are unclipped.

4. Pull the canopy base under and around

the cubby seat.

1. Ensure swing hook bolts are fully tightened.

Failure to do so can result in serious injury.

2. Attach hanging fittings as shown.

Ensure all shackles are closed and locked.

Mind your fingers!

7ATTACH SWINGING CUBBY

Page 8

Unclip buckles before install.

Undo strap.

Swing Hook

(Installed step 1)

Seat Tent

assembly from step 6

Carabiner

Swivel

Shackle

Door Position

Cubby Canopy

Assembled Cubby

Swing Seat from

step 5

ASSEMBLY INSTRUCTIONS - SWINGING CUBBY

ASSEMBLY INSTRUCTIONS - SECURING THE SWINGING CUBBY

8SECURE SWING CANOPY TO CUBBY SWING SEAT

Page 9

9ADD ACCESSORIES

Clip buckles to fasten canopy base.

1. Ensure the swinging cubby is no higher than 450mm

off the ground, no lower than 350mm to the ground

and a minimum of 450mm away from

any obstruction.

2. Clip the buckles under the door access together (B).

This will secure the base of the canopy

to the cubby swing seat.

3. Ensure the strap at the top of the

canopy (A) is fed through the hanging ring and

fully tightened. This will prevent the cubby

canopy from being pulled downwards.

A Connect and tighten strap.

350mm min. -

450mm max.

Hanging ring.

Add accessories into the swinging cubby.

Pillow

(Supplied)

450mm min. clear

(any obstruction

all directions)

Tabla de contenidos

Otros manuales de Juegos y equipos de juegos infantiles de FUNKY MONKEY BARS

FUNKY MONKEY BARS

FUNKY MONKEY BARS ROCKET RINGS Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE ORIGINAL Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE GORILLA Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE LEMUR Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE CHEEKY LITTLE MONKEY Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE SILVERBACK Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE AERIAL TAMARIN Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS ACCESSORIES BAR Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS Boxing Bag Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE TAMARIN Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS Floating Accessories Bar Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS HORIZONTAL CARGO NET Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS Floating Flying Fox Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS FIREMANS POLE Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS CARGO NET Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE CHIMP Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE ORANGUTAN Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS MONKEY BAR ADD-ON Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS Yoga Swing Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS Floating Flying Fox Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS Height Extender (Top) on Orangutan Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE COMBAT NINJA Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS Spider Monkey Manual de usuario

FUNKY MONKEY BARS

FUNKY MONKEY BARS THE MARMOSET Manual de usuario

Manuales populares de Juegos y equipos de juegos infantiles de otras marcas

Ledon

Ledon 302040 Manual de usuario

FUNormous

FUNormous Disney Junior MICKEY MOUSE Manual de usuario

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Manual de usuario

PoolMaster

PoolMaster 72775 Manual de usuario

Palmako

Palmako 4743142009857 Manual del instalador

BOERPLAY

BOERPLAY PSTE000.019 Manual de usuario

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Guía del usuario

stilum

stilum Erika Manual de usuario

Costway

Costway NP10816 Manual de usuario

Trigano

Trigano VABI Manual de usuario

Outward

Outward OUT116 Manual de usuario

GALOPIN

GALOPIN ARC02 Manual de usuario

stilum

stilum levis Especificaciones técnicas

Ledon

Ledon BASIC Bai LB012 Manual de usuario

BOERPLAY

BOERPLAY PSTE115.002 Manual de usuario

Europlay

Europlay S306 Manual de programación

SportsPlay Equipment

SportsPlay Equipment 361-509H Manual de usuario

Ledon

Ledon 302250 Manual de usuario