Fujitsu PRIMERGY Econel 50 Manual del propietario

PRIMERGY

PRIMERGY Econel 50

Server System

Service Supplement

Xenia Fierley

Fujitsu Siemens Computers GmbH München

81730 München

e-mail: email: [email protected]

Tel.: (089) 61001-157

Fax: 0 700 / 372 00000

Econel 50

Sprachen: De

Edition January 2005

This manual is printed on

paper treated with

chlorine-free bleach.

Comments…Suggestions…Corrections…

The User Documentation Department would like to

know your opinion of this manual. Your feedback helps

us optimize our documentation to suit your individual

needs.

Fax forms for sending us your comments are included in

the back of the manual.

There you will also find the addresses of the relevant

User Documentation Department.

Certified documentation

according to DIN EN ISO 9001:2000

To ensure a consistently high quality standard and

user-friendliness, this documentation was created to

meet the regulations of a quality management system

which complies with the requirements of the standard

DIN EN ISO 9001:2000.

cognitas. Gesellschaft für Technik-Dokumentation mbH

www.cognitas.de

Delivery subject to availability; right of technical modifications reserved.

All hardware and software names used are trademarks of their respective manufacturers.

Econel 50 Service Supplement

Contents

1Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

1.1 Overview of the Documentation . . . . . . . . . . . . . . . . . . 1

1.2 Notational Conventions . . . . . . . . . . . . . . . . . . . . . . 3

2 Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

3 Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

4 Replacement Routines . . . . . . . . . . . . . . . . . . . . . 13

4.1 General Purposes . . . . . . . . . . . . . . . . . . . . . . . . 13

4.1.1 Removing/Mounting the Side Cover . . . . . . . . . . . . . . . 13

4.1.2 Removing/Mounting the Front Panel . . . . . . . . . . . . . . . 14

4.1.3 Removing/Mounting the System Fan . . . . . . . . . . . . . . 14

4.1.4 Fold out the Power Supply Unit . . . . . . . . . . . . . . . . . 14

4.1.5 Removing/Mounting the Cross-beam . . . . . . . . . . . . . . 16

4.2 Replacing the Operating Panel Cable . . . . . . . . . . . . . . 17

4.3 Replacing the Floppy Disk Drive . . . . . . . . . . . . . . . . . 19

4.4 Replacing the USB Connector Cable . . . . . . . . . . . . . . 21

4.5 Replacing the Power Supply Unit . . . . . . . . . . . . . . . . 23

4.6 Replacing the Intrusion Detection Switch . . . . . . . . . . . . 28

4.7 Replacing the System Board . . . . . . . . . . . . . . . . . . 30

5 Appendix . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

5.1 Cabling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Econel 50 Service Supplement 1

1 Introduction

The PRIMERGY Econel 50 server is an Intel-based server for small and mid-

size networks. The server is suitable for use as a file server and also as an appli-

cation, information or Internet server.

1.1 Overview of the Documentation

Concept and target group of this manual

This Service Supplement completes the information given in the Operating

Manual, the Options Guide and the Technical Manual of the system board.

The actions described in this manual should only be performed by service

personnel.

Service CD

Service partners of Fujitsu Siemens can order a Service CD. On the CD the

following manuals are available in PDF format:

– “Safety” manual

– Operating Manual for PRIMERGY Econel 50

– Technical Manual for the system board D1859

– Options Guide for PRIMERGY Econel 50

– Service Supplement PRIMERGY Econel 50

– “BIOS Setup” manual

2 Service Supplement Econel 50

Overview of the Documentation Introduction

Information/procedure Manual

Detailed safety notes Safety

Features and technical data of the server Operating Manual

Installation and operation, among other things:

– Operation

– Configuration of the server

Troubleshooting

Information about the system board:

– Features of the system board

– External ports on the server

– Pin assignment of the connectors

– Jumper settings

– LED indicators

– Replacing the battery

Technical Manual

Extensions and upgrades:

– Extending/replacing the main memory

– Installing the processor/replacing the

processor/replacing the heat sink

Technical Manual

IFor some components only the installation

routine is described in the Options Guide.

Removing these components proceed in

reverse order.

– Installing accessible drives

– Removing/installing the system fan

– Installing SATA hard disk drives

– Installing controllers in PCI slots

Options Guide

Replacement routines:

– Replacing the operating panel cable

– Replacing the floppy disk drive

– Replacing the USB cable (front)

– Replacing the power supply unit

– Replacing the intrusion switch

– Replacing the system board

Service Supplement

BIOS setup BIOS Setup

Table 1: Overview of the Documentation Econel 50

Econel 50 Service Supplement 3

Introduction Notational Conventions

1.2 Notational Conventions

The following notational conventions are used in this manual:

text in italics indicate commands, menu items or software programs

“Quotation marks” indicate names of chapters and terms that are being

emphasized

Êdescribes activities that must be performed in the order

shown

VCAUTION! Pay particular attention to texts marked with this

symbol. Failure to observe this warning may endanger

your life, destroy the system or lead to the loss of data.

Iindicates additional information, notes and tips

Table 2: Notational conventions

Econel 50 Service Supplement 5

2Procedure

VCAUTION!

The actions described in this manual should only be performed by

service personnel.

ÊBefore doing anything else, please take notice of chapter “Safety” on page 7

and following.

ÊMake sure all necessary manuals (see service CD) are available; you may

find it advantageous to print the PDF files. You will definitely need the

Operating Manual and the Options Guide for the server and the Technical

Manual for the system board.

ÊShut down the server correctly, switch it OFF, pull out the power plug, and

open the server as described in the chapter “Replacement Routines” on

page 13 and following.

ÊReplace the defective component as described in the relevant chapter.

ÊClose the server.

ÊConnect the cables.

ÊConnect the server to the line voltage.

ÊStart the operating system.

ÊIf necessary, configure the server as required.

Tabla de contenidos

Otros manuales de Servidor de Fujitsu

Fujitsu

Fujitsu PRIMERGY RX2510 M2 Manual de usuario

Fujitsu

Fujitsu PRIMERGY TX150 S4 Manual de usuario

Fujitsu

Fujitsu SPARC Enterprise T5140 Manual de servicio

Fujitsu

Fujitsu PRIMERGY RX2530 M4 Manual de usuario

Fujitsu

Fujitsu SPARC M10-4 Manual de usuario

Fujitsu

Fujitsu PRIMEQUEST 480 Manual técnico

Fujitsu

Fujitsu BX630 - PRIMERGY - S2 Dual Manual del propietario

Fujitsu

Fujitsu PRIMERGY BX620 S6 Manual de usuario

Fujitsu

Fujitsu PRIMEQUEST 2000 Series Manual de servicio

Fujitsu

Fujitsu SPARC Enterprise M8000 Guía de instalación

Fujitsu

Fujitsu M10 Series Manual técnico

Fujitsu

Fujitsu PRIMERGY TX120 S3p Manual de usuario

Fujitsu

Fujitsu primequest 2400E2 Guía

Fujitsu

Fujitsu T2555SC020IN Manual de usuario

Fujitsu

Fujitsu PRIMERGY BX900 Manual de usuario

Fujitsu

Fujitsu PRIMERGY RX100 S8 Manual de usuario

Fujitsu

Fujitsu PRIMERGY DX920 S3 Manual

Fujitsu

Fujitsu SPARC Enterprise M4000 Manual de usuario

Fujitsu

Fujitsu PRIMERGY TX2550 M4 Manual de usuario

Fujitsu

Fujitsu PRIMERGY BX900 Guía rápida de usuario

Fujitsu

Fujitsu SPARC Enterprise T5140 Manual de usuario

Fujitsu

Fujitsu PRIMERGY TX300 S7 Manual de usuario

Fujitsu

Fujitsu PRIMEQUEST 2000 Series Manual de usuario

Fujitsu

Fujitsu SPARC Enterprise M3000 Manual de servicio

Manuales populares de Servidor de otras marcas

HP AlphaServer ES47 Manual de usuario

Dell

Dell PowerEdge R410 Manual de usuario

PowerNAS

PowerNAS CMA Manual de usuario

Supero

Supero FatTwin F617R3-FT Manual de usuario

MSI

MSI P1-109N-L70 Manual de usuario

Dell

Dell PowerEdge XE9640 Manual

Dell

Dell PS4100 Instrucciones de montaje

EtroVISION

EtroVISION EV3151 Manual de usuario

NEC

NEC Express5800/T110j Manual de usuario

HP ProLiant Gen9 Manual de usuario

Compaq

Compaq ProLiant 3000 Manual

Dell

Dell PowerEdge 3YPMN Manual de usuario

iRobo

iRobo IPC2U Manual de usuario

Nortel

Nortel 1000 Con?guration guide Manual de usuario

Asus

Asus AP7500 Manual de operación y mantenimiento

Avid Technology

Avid Technology AirSpeed 5000 Manual de usuario

HP Integrity rx2600 Guía de instalación

Milestone

Milestone Husky IVO 350T Manual de usuario