Froling S4 Turbo Manual de usuario
Operating Instructions
Log wood boiler S4 Turbo
Translation of the original German operating instructions for the operator
Read and follow the instructions and safety information!
Technical changes, typographical errors and omissions reserved!
B0510512_en | Edition 25/06/2013
Froling GesmbH | A-4710 Grieskrichen, Industriestraße 12 | www.froeling.com
Table of Contents
1 General 4
1.1 S4 Turbo Product Overview 5
2 Safety 7
2.1 Hazard levels of warnings 7
2.2 Pictograms used 8
2.3 General safety information 9
2.4 Permitted uses 10
2.4.1 Permitted fuels 10
Firewood
10
2.4.2 Fuels permitted under certain conditions 11
Wood briquettes
11
2.4.3 Non-permitted fuels 11
2.5 Qualification of operating staff 12
2.6 Protective equipment for operating staff 12
2.7 Design information 12
2.7.1 Installation and approval of the heating system 12
2.7.2 General information for installation room (boiler room) 13
2.7.3 Requirements for central heating water 13
2.7.4 Return lift 14
2.7.5 Combination with storage tank 14
2.7.6 Chimney connection/chimney system 14
2.8 Safety devices 15
2.9 Residual risks 15
2.10 Emergency procedure 17
2.10.1 Overheating of the system 17
2.10.2 Smell of flue gas 17
3 Operating the System 18
3.1 Assembly and initial startup 18
3.2 Heating up the boiler 19
3.2.1 Switching on the power supply 19
3.2.2 Switching on the boiler 19
3.2.3 Before heating up the boiler 19
Reloading intervals when operating with storage tank
19
Determining the right amount of fuel
20
Fuel table
21
Fill level in boiler
21
Reloading intervals when operating without storage tank or if the storage tank is too small
21
3.2.4 Heating the boiler with firewood 22
3.2.5 Heating up the boiler with automatic ignition 24
3.2.6 Regulating the boiler 24
3.2.7 Reloading firewood 25
3.2.8 Switching off the power supply 26
4 Boiler servicing 27
4.1 General information on servicing 27
Table of Contents
2 Froling GesmbH | A-4710 Grieskrichen, Industriestraße 12 | www.froeling.com
4.2 Inspection and cleaning 28
4.2.1 Prior to heating up 28
Always move the WOS lever
28
Check the ignition pipe (only with automatic ignition)
28
4.2.2 Inspection 29
Checking the system pressure
29
Checking the thermal discharge safety device
29
Checking the safety valve
29
4.2.3 Cleaning 29
Emptying ash
30
Cleaning the grating
30
4.2.4 Annual inspection 31
Cleaning the carbonisation gas duct
31
Checking the primary air openings
31
Cleaning the heat exchanger pipes
32
Checking the seal on the doors
33
Cleaning the flue gas temperature sensor
34
Clean the flue gas pipe
35
Checking the draught controller flap
35
Cleaning the induced draught fan
35
4.3 Emissions measurement by chimney sweep or regulatory body 36
4.3.1 Measuring at rated load in firewood mode 36
4.3.2 Measuring at partial load in firewood mode (if required) 36
4.4 Maintenance agreement / Customer service 37
4.5 Replacement parts 37
4.6 Disposal information 37
4.6.1 Disposal of the ash 37
4.6.2 Disposal of system components 37
5 Troubleshooting 38
5.1 General fault with power supply 38
5.1.1 Behaviour of system after a power failure 38
5.2 Excessive temperature 38
5.3 Faults with fault message 39
5.3.1 Procedure for fault messages 39
5.3.2 Acknowledging a fault message 39
6 Appendix 40
6.1 Addresses 40
6.1.1 Address of manufacturer 40
6.1.2 Address of the installer 40
Table of Contents
Operating Instructions S4 Turbo | B0510512_en 3
1 General
Thank you for choosing a quality product from Froling. The product features a state-of-
the-art design and conforms to all currently applicable standards and testing guide‐
lines.
Please read and observe the documentation provided and always keep it close to the
system for reference. It contains important safety information and all the operation and
maintenance specifications needed to operate the system safely, properly, environ‐
mentally friendly and cost-effectively.
The constant further development of our products means that there may be minor dif‐
ferences from the pictures and content. If you discover any errors, please let us know:
Subject to technical change.
Guarantee conditions
Our sale and delivery conditions generally apply. These conditions have been made
available to customers, and customers have been made aware of them at the time of
order completion.
You can also find the guarantee conditions on the enclosed guarantee certificate.
1General
4 Froling GesmbH | A-4710 Grieskrichen, Industriestraße 12 | www.froeling.com
1.1 S4 Turbo Product Overview
1Insulated door
1.1 Maintenance overview
2Fuel loading door
3Pre-heating chamber door
4Combustion chamber door with inspection glass
5Control panel of the Lambdatronic S3200
5.1 Visual display showing operating statuses and parameters
5.2 Status LED (operating status):
- GREEN constant: BOILER ACTIVE (heating up/heating)
- GREEN flashing (interval: 5 sec. OFF, 1 sec ON): OFF
- ORANGE flashing: WARNING
- RED flashing: FAULT
5.3 Navigation keys to move around in the menus and to change the parameter values
5.4 Function keys to call up individual boiler functions directly
NOTICE! For key layout see control unit operating instructions
General 1
S4 Turbo Product Overview
Operating Instructions S4 Turbo | B0510512_en 5
Underneath the back insulating cover (9):
6Lever for heat exchanger cleaning system (WOS)
7Actuators for automatic regulation of primary and secondary air
8Automatic ignition (optional)
9Back insulating cover
10 Heat exchanger cover: Maintenance opening for cleaning the WOS system and heat
exchanger
11 Main switch
12 Service port
13 STL high-limit thermostat
1General
S4 Turbo Product Overview
6 Froling GesmbH | A-4710 Grieskrichen, Industriestraße 12 | www.froeling.com
2 Safety
2.1 Hazard levels of warnings
This documentation uses warnings with the following hazard levels to indicate direct
hazards and important safety instructions:
DANGER
The dangerous situation is imminent and if measures are not observed it will lead
to serious injury or death. You must follow the instructions!
WARNING
The dangerous situation may occur and if measures are not observed it will lead
to serious injury or death. Work with extreme care.
CAUTION
The dangerous situation may occur and if measures are not observed it will lead
to minor injuries or damage to property.
Safety 2
Hazard levels of warnings
Operating Instructions S4 Turbo | B0510512_en 7
2.2 Pictograms used
The following symbols are used in the documentation and/or on the boiler to show
what is required and forbidden and to give warnings.
In accordance with the Machinery Directive, signs fitted directly within the danger area
of the boiler indicate immediate hazards or safety procedures. These stickers must not
be removed or covered.
Refer to the operating instruc‐
tions
Wear safety shoes
Wear protective gloves Turn off the main switch
Keep the doors closed
Unauthorised access prohibited
Warning - hot surface Warning - hazardous electrical
voltage
Warning - hazardous or irritant
materials
Warning - automatic boiler start‐
up
Warning of injury to fingers or
hands, automatic fan
2Safety
Pictograms used
8 Froling GesmbH | A-4710 Grieskrichen, Industriestraße 12 | www.froeling.com
2.3 General safety information
DANGER
If the device is used incorrectly:
Incorrect use of the system can cause severe injury and damage.
When operating the system:
❒ Observe the instructions and information in the manuals
❒ Observe the details on procedures for operation, maintenance and cleaning,
as well as troubleshooting in the individual manuals.
❒ Any work above and beyond this should be carried out by authorised heating
engineers or by Froling customer services.
WARNING
External influences:
Negative external influences, such as insufficient combustion air or non-standard
fuel, can cause serious faults in combustion (e.g. spontaneous combustion of car‐
bonisation gases or flash fires) which can in turn cause serious accidents!
When operating the boiler, please note the following:
❒ Instructions and information regarding versions and minimum values, as well
as standards and guidelines for heating components in the instructions must
be observed.
WARNING
Severe injuries and damage can be caused by an inadequate flue gas system.
Problems with the flue gas system, such as poor cleaning of the flue pipe or insuf‐
ficient chimney draught, can cause serious faults in combustion (such as sponta‐
neous combustion of carbonisation gases or flash fires).
Take the following precautions:
❒ Optimum boiler performance can only be guaranteed if the flue gas system is
functioning correctly.
Safety 2
General safety information
Operating Instructions S4 Turbo | B0510512_en 9
2.4 Permitted uses
The Froling Firewood boiler S4 Turbo is designed solely for heating domestic water.
Only use fuels specified in the "Permitted fuels" section.
⇨ See "Permitted fuels" [page 10]
The unit should only be operated when it is in full working order. It should be operated
in accordance with the instructions, observing safety precautions, and you should en‐
sure you are aware of the potential hazards. The inspection and cleaning intervals in
the operating instructions should be observed. Ensure that any faults which might im‐
pair safety are rectified immediately.
The manufacturer or supplier is not liable for any damage resulting from non-permitted
uses.
2.4.1 Permitted fuels
Firewood
Firewood up to max. 55 cm long.
Water content (w) greater than 15% (equivalent to wood moisture u > 17%)
Water content (w) less than 25% (equivalent to wood moisture u < 33%)
EU: Fuel acc. to EN 14961 - Part 5: Firewood class A2 / D15 L50
Germany
also:
Fuel class 4 (§3 of the First Federal Emissions Protection Ordinance
(BimSchV) in the last amended version)
▪ Values in practice:
- Hardwood: 2 years in dry storage
- Soft wood: 1 year in dry storage
▪Store stacks of split wood sheltered from the rain
▪ Create a dry underlay, where possible with air access (line with round timber, pallets,
etc.)
▪ Use wind-exposed areas where possible for storage (e.g. store at edge of forest instead
of in forest)
▪ Walls of buildings facing the sun are ideal
▪ If possible, stock fuel for the day in a warm place (e.g. in boiler room) (pre-heats the
fuel!)
NOTICE! Use fuels that are consistent in size and water content.
NOTICE! Burning extremely dry fuels (w < 15%) may require repairs by qualified staff.
Please contact Froling customer services or your installer.
Water content
Note on standards
Tips for
storing wood
2Safety
Permitted uses
10 Froling GesmbH | A-4710 Grieskrichen, Industriestraße 12 | www.froeling.com
Otros manuales para S4 Turbo
1
Tabla de contenidos
Otros manuales de Caldera de Froling
Froling
Froling P4 Pellet 8-60 Manual de usuario
Froling
Froling T4 Series Manual de usuario
Froling
Froling P4 Pellet 8 Manual de usuario
Froling
Froling Turbomatic TMC 28-55 Manual de servicio
Froling
Froling S4 Turbo 15 Manual de usuario
Froling
Froling S3 Turbo Manual de usuario
Froling
Froling Turbomat TM 320 Manual de usuario
Froling
Froling S4 Turbo 15 Manual de usuario
Froling
Froling FHG 20 Manual de usuario
Froling
Froling SP Dual compact Manual de usuario
Froling
Froling T4-24 Manual de usuario
Froling
Froling Lambdamat Kommunal 320 Manual de usuario
Froling
Froling P4 Pellet 15 Manual de usuario
Froling
Froling P4 Pellet 8 - 105 Manual de usuario
Froling
Froling S4 Turbo Manual de usuario
Froling
Froling T4 24-150 Manual de usuario
Froling
Froling SP Dual Manual de usuario
Froling
Froling TX Manual de usuario
Froling
Froling SP Dual compact Manual de usuario
Froling
Froling Lambdatronic P 3200 Manual de usuario
