Franke PRTR0005 Manual de usuario

Installation and operating instructions Montażi instrukcja obsługi

Notice de montage et de mise en service Monterings- og driftsvejledning

Instrucciones de montaje y uso Návod pro montáž a provoz

Istruzioni per il montaggio e l’uso Asennus- ja käyttöohje

Montage- en bedrijfsinstructies Инструкция по монтажу ивводу в

эксплуатацию

ZMI_001_2000105117-PRTR0005_#SALL_#AQU_#V1.fm/24.04.13

Franke Aquarotter GmbH, Germany

EA-Nr.: 7612982184598

FAR-Best.-Nr.: 2000105117

PRTR0005

[email protected] - www.hygiene-shop.eu

Inhaltsverzeichnis35.fm

...................................................................................... 3

Please refer to the graphics in the German Installation and

Operating Instructions.

...................................................................................... 10

Les graphiques sont disponibles dans la notice de montage et de

mise en service allemande.

...................................................................................... 17

Por favor, consulte los gráficos en las instrucciones alemanas de

montaje y uso.

...................................................................................... 25

Per le grafiche fare riferimento alle Istruzioni per il montaggio e

l’uso in tedesco.

...................................................................................... 32

De tekeningen kunt u in de Duitse montage- en bedrijfsinstructies

vinden.

...................................................................................... 39

Prosimy przyjąć grafikęz niemieckiej instrukcji montażu i obsługi.

...................................................................................... 46

Bilderna finns i den tyska monterings- och bruksanvisningen.

...................................................................................... 53

Obrázky najdete v nìmeckém návodu k montáži a obsluze.

...................................................................................... 60

Kuvat löydätte saksankielisestä asennus- ja käyttöohjeesta.

...................................................................................... 67

Рисунки приведены винструкции по монтажу иэксплуатации на

немецком языке.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105117-PRTR0005_#SEN_#AQU_#V1.fm

0English

PROTRONIC-T, 230 V AC

Washbasin pillar tap

Please refer to the graphics in the German Installation and Operating Instructions.

0Table of Contents

1. Abbreviations and Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

2. Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

3. Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

4. Important Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Description of Product

5. Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

6. Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

7. Scope of Delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

8. Dimensions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

9. Installation Example . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Installation, Function and Commissioning

10. Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

11. Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

12. Programmable Function Parameters . . . . . . . . . . . . . . . . . . . . . . 7

Maintenance

13. Maintenance and Servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

14. Replacing an Aerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

15. Replacing the Grit Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

16. Replacing the Solenoid Valve Cartridge . . . . . . . . . . . . . . . . . . . . 8

17. Fault Correction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

18. Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105117-PRTR0005_#SEN_#AQU_#V1.fm

1. Abbreviations and Units

2. Key

Warning!

Failure to observe can result in injury or even death.

Caution!

Failure to observe can result in material damage.

☞Important!

Failure to observe can cause the product to malfunction.

☞Useful information for optimally handling the product.

3. Warranty

Liability is accepted according to the General Terms and Conditions of Business and

Supply.

Use original replacement parts only!

4. Important Notes

• Installation, commissioning and maintenance are to be performed only by a

qualified technician according to the instructions provided and in accordance with

legal requirements and acknowledged rules of technology.

• All technical connection regulations specified by the local water and electricity

supply utility companies must be complied with.

DN Nominal diameter in mm

EA-Nr. European Article Number

FAR-Best.-Nr. Franke-Aquarotter Order No.

Conversion 1 mm = 0.03937 inches

1 inch = 25.4 mm

All length specifications in the graphics are in mm.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105117-PRTR0005_#SEN_#AQU_#V1.fm

5. Application

PROTRONIC-T mains-operated, opto-electronically controlled washbasin fitting

DN 15 with aerator with integrated flow rate regulator, for connecting to pre-mixed

warm water or cold water, complete with plug-in power supply 230 V AC.

6. Technical Specifications

7. Scope of Delivery

8. Dimensions

9. Installation Example

Minimum flow pressure: 1.0 bar

Recommended flow

pressure:

1–5 bar

Maximum operating

pressure:

10 bar

Calculation flow rate: 0.10 l/s

Operating voltage: 230 V AC

Operating voltage: 12 V DC

Type of protection: Tap IP55

Plug-in power supply IP20

Quantity Description

1 PROTRONIC-T pillar tap

with filter

1 Cleaning clip

1 Plug-in power supply 230 V AC/12 V DC

1 Fixing set

1 Installation and Operating Instructions

X Extension

cable

FAR

Order No.

0.6 m without –

3.6 m 3.0 m 2000101456

10.6 m 10.0 m 2000101457

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105117-PRTR0005_#SEN_#AQU_#V1.fm

10. Assembly Instructions

Warning!

Use the fitting only with the grit filters specified.

Failure to observe can result in an increased bacterial load in drinking water and

cause a health risk or even risk of death.

☞Important!

Before installing, flush the pipes in compliance with DIN 1988.

☞Do not shorten the connector hoses located at the fitting.

☞Connect the fitting only to the original plug-in power supply. Connect the plug-in

power supply only to a socket carrying 230 V/50 Hz.

10.1

Install the fitting (a) on the washbasin (b).

☞Important!

Observe the range settings when installing on a stainless steel washbasin

Chapter 12.

☞The corner valve (c) must be provided by the customer.

10.2

Screw the connecting hose (d) on to the corner valve.

10.3

Insert the plug-in power supply into the socket.

10.4

Connect the line between the fitting and the power supply.

11. Function

11.1

Allow your hand to approach the sensor.

• Water flows.

11.2

Remove your hand from the sensor.

• Water flow stops automatically after a set flow duration.

☞The range of the sensor and the flow duration can be adjusted with the optional

remote control (FAR Order No. 2000101087).

☞Important!

Reflecting surfaces can influence the sensor. There is a risk of having permanent

reflections. ((see Chapter 12. for adjusting the sensor range).

“Auto-flush” function

Caution!

When the “Auto flush” function is used, the flow of water must be ensured.

• The "Auto-flush" function ensures that forced flushing takes place to exchange the

water in the tap lines after 24 or 72 hours of non-use.

• The “Auto-flush” function can only be switched on with the optional remote control

(FAR-Order-No. 2000101087).

• This function is switched off at the factory.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105117-PRTR0005_#SEN_#AQU_#V1.fm

12. Programmable Function Parameters

The optional remote control FAR Order No. 2000101087 offers the following

functions:

– Range can be set (3-20 cm)

– Turn-off delay can be set (0-10 s)

– Continuous flow can be switched to 3.5 min or 11 min.

– Switching off the fitting

– Basic settings can be restored

– Test mode for simulation without water

– Setting automatic safety switch-off (2–210 s)

– Automatic flushing can be activated

☞Important!

Reflecting surfaces can influence the sensor. There is a risk of having permanent

reflections. The range must be reduced for installations on reflecting surfaces such

as stainless steel washbasins. If this is not sufficient, an additional base/spacing ring

is available (see Chapter 18.).

13. Maintenance and Servicing

Depending on the quality of the water, the local conditions and the rules and

regulations applicable on site, the fitting must be maintained and serviced at regular

intervals.

Perform maintenance on the following components:

• Aerators (see Chapter 14.)

• Filters (see Chapter 15.)

13.1

Push up the cleaning clip (a) in front of the sensor.

☞The fitting is in sleep mode.

13.2

Properly use suitable cleaning agents that are not harmful to the fittings and rinse

with water after use. High-pressure cleaners must not be used for cleaning.

14. Replacing an Aerator

14.1

Use an open-end spanner to unscrew and replace the aerator (a).

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105117-PRTR0005_#SEN_#AQU_#V1.fm

15. Replacing the Grit Filter

Filter for corner valve

15.1

Close the corner valve (c).

15.2

Trigger the valve.

15.3

Unscrew the connector hose (a) from the corner valve.

15.4

Replace the grit filter (b).

15.5

Reassemble in the reverse order.

Filter, solenoid valve cartridge

15.6

Remove the solenoid valve cartridge (see Chapter 16.).

15.7

Use a flat nose pliers to pull the filter (d) out.

15.8

Replace the filter.

☞Important!

Ensure correct installation position. The rib of the filter must not lie on the flow-

through hole.

15.9

Reassemble in the reverse order.

16. Replacing the Solenoid Valve Cartridge

16.1

Close the corner valve.

16.2

Trigger the valve.

16.3

Loosen the screw (a) with an Allan key.

16.4

Pull the housing (b) from the base (c).

16.5

Remove the screws (d).

16.6

Remove the mounting bracket (e).

16.7

Remove and replace the solenoid valve cartridge (f).

16.8

Reassemble in the reverse order.

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105117-PRTR0005_#SEN_#AQU_#V1.fm

17. Fault Correction

If you are unable to correct a fault or if the fault is not described in the fault correction

section, please inform our customer service department!

18. Replacement Parts

Fault Cause Remedy

Water does not flow – Voltage supply interrupted ➯Restore it

– Water-flow volume regulator closed ➯Open it

– Grit filter are clogged with dirt ➯Clean them

– Cleaning clip in front of the fitting ➯Remove

– Solenoid valve faulty ➯Replace it

Water flows

continuously

– Solenoid valve faulty ➯Replace it

Water flow too weak – Corner valve not fully opened ➯Open it

– Grit filter are clogged with dirt ➯Clean them

– Aerator calcified ➯Replace it

– Solenoid valve faulty ➯Replace it

– Supply pressure too low ➯Check it

Designation Order No.

1 Aerator with

flow rate regulator

(PU 10 pcs.) . . . . . . . . . . . . . . . . . 2000104691

2 Solenoid valve cartridge

with grit filter . . . . . . . . . . . . . . . . 2000104456

3 Cleaning clip . . . . . . . . . . . . . . . . 2000104898

4 Maintenance kit comprising:

O-rings

Screws

Grit filters. . . . . . . . . . . . . . . . . 2000104898

Designation Order No.

5 Plug-in power supply . . . . . . . . . . 2000105814

6 IGrit filters (PU 10 pcs. . . . . . . . . . 2000104720

7 Hose . . . . . . . . . . . . . . . . . . . . . . . 2000109491

Accessories Order No.

8 Remote control . . . . . . . . . . . . . . . 2000101087

9 Base for installation

on stainless steel washbasin . . . . 2000105834

[email protected] - www.hygiene-shop.eu

ZMI_001_2000105117-PRTR0005_#SFR_#AQU_#V1.fm

0Français

PROTRONIC-T, 230 V AC

Robinetterie fixe pour lavabo

Les graphiques sont disponibles dans la notice de montage et de mise en service

allemande.

0Table des matières

1. Abréviations et unités . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

2. Explication des symboles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

3. Garantie . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

4. Remarques importantes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Description du produit

5. Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

6. Données techniques. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

7. Contenu de la livraison . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

8. Dimensions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

9. Exemple d’installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Montage, fonctionnement et mise en service

10. Montage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

11. Fonctionnement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

12. Paramètres de fonctionnement programmables . . . . . . . . . . . . . 14

Entretien

13. Maintenance et entretien . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

14. Remplacement de l’embout d’arrosage . . . . . . . . . . . . . . . . . . . . 15

15. Remplacement des filtres . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

16. Remplacement de la cartouche de l'électrovanne . . . . . . . . . . . . 15

17. Élimination de pannes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

18. Pièces de rechange . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

[email protected] - www.hygiene-shop.eu

Este manual sirve para los siguientes modelos

Tabla de contenidos

Idiomas:

Otros manuales de Accesorio de baño de Franke

Franke

Franke F3EV1006 2030039462 Manual de usuario

Franke

Franke 2152 00 23 Manual de usuario

Franke

Franke 7612210067174 Manual de usuario

Franke

Franke HDTX674 Manual de usuario

Franke

Franke STRX611 Manual de usuario

Franke

Franke MIRANIT F5SM2025 Manual de usuario

Franke

Franke F5 ACDR0001 Manual de usuario

Franke

Franke RODAN RODX687 Manual de usuario

Franke

Franke Protronic-S AQUA131 2000067774 Manual de usuario

Franke

Franke F5ST2032 Manual de usuario

Franke

Franke RODX604E Manual de usuario

Franke

Franke AQRM668 Manual de usuario

Franke

Franke EXOS676 Manual de usuario

Franke

Franke MIRANIT F5LM2025 Manual de usuario

Franke

Franke FAID0004 Manual de usuario

Franke

Franke 7612210081965 Manual de usuario

Franke

Franke 7612210067297 Manual de usuario

Franke

Franke XINX672 Manual de usuario

Franke

Franke SATURN TB60 Manual de usuario

Franke

Franke PROTRONIC AQRE136 Instrucciones de funcionamiento

Franke

Franke AQFX0006 Manual de usuario

Franke

Franke F5LM2008 Manual de usuario

Franke

Franke AQUATIMER A3000 Manual de usuario

Franke

Franke F5L-Mix 2030039446 Manual de usuario

Manuales populares de Accesorio de baño de otras marcas

DURAVIT

DURAVIT C.1 C15240 0090 Manual

Heatstore

Heatstore HSTRL500WTN Manual de usuario

Sunshower

Sunshower PURE SOLO Manual de usuario

Delabie

Delabie Delabie Sporting 714700 Manual de usuario

Kohler

Kohler K-13056 Instrucciones de montaje

ESS

ESS Container TCL-11 Manual de usuario

Mustee

Mustee 22C Manual de usuario

VITRA

VITRA V-Flow Manual de usuario

baliv

baliv DUK-80.30 T Manual de usuario

Malmet

Malmet B105BT Manual de usuario

bathstore

bathstore Transition H1690MM Guía

BELLOSTA

BELLOSTA Edward 0800/M Manual de usuario

baliv

baliv DU-5160 Manual de usuario

Gessi

Gessi RILIEVO 59011 Manual de usuario

noken

noken VITAE 100188525-N299998810 Manual de usuario

Allen + Roth

Allen + Roth 1142VA-30-201 Manual de usuario

Britex

Britex HBDA Manual de usuario

GRE

GRE DSALC32W Manual de usuario