Fisher QUICK-CASTER 300H Instrucciones de funcionamiento
This document supersedes all editions with an earlier date.
September 1, 2021
Lit. No. 43757, Rev. 05
QUICK‑CASTER™ 300W &
QUICK‑CASTER 300H
Tailgate Spreaders
#30750, 30760
Owner's Manual and Installation Instructions
Original Instructions
This manual is for FISHER® QUICK-CASTER 300W & 300H tailgate spreaders with
serial numbers beginning with 150401 and higher.
CAUTION
Read this manual before installing or
operating the spreader.
Lit. No. 43755/43757, Rev. 05 3 September 1, 2021
TABLE OF CONTENTS
INTRODUCTION ....................................................... 5
Owner's Information Form .................................... 5
SAFETY ..................................................................... 6
LOADING ................................................................. 11
Certication......................................................... 11
Approximate Material Weights............................ 11
MOUNTING THE SPREADER............................... 12
Assembly Instructions......................................... 12
Receiver Mount Spreader................................... 13
ELECTRICAL DIAGRAM....................................... 14
OPERATING THE SPREADER ............................. 16
Driving and Spreading on Snow and Ice ............ 16
Ensuring that the Spreader has Power............... 18
Starting and Stopping Motor............................... 18
Spreading Tips.................................................... 18
REMOVING THE SPREADER............................... 19
WIRELESS CONTROL PROGRAMMING AND
PAIRING ............................................................... 20
MAINTENANCE ......................................................22
Lubrication ..........................................................22
After Each Use....................................................22
At the End of Each Season or
After Extended Storage ................................... 22
Fuse Replacement..............................................22
Storage ...............................................................22
TROUBLESHOOTING............................................ 23
Lit. No. 43757, Rev. 05 5 September 1, 2021
INTRODUCTION
Register your spreader online at www.sherplows.com
OWNER'S INFORMATION
Owner's Name: ______________________________________________________________________
Date Purchased: _____________________________________________________________________
Distributor Name: __________________________________________ Phone:_________________
Distributor Address:___________________________________________________________________
Vehicle Model:_____________________________________________ Year: __________________
Spreader Model: _________________________ Serial #:__________________________________
Spreader Weight:_____________________lb/kg
This manual has been prepared to acquaint you with
the safety information, operation, and maintenance of
your new tailgate spreader. Please read this manual
carefully and follow all recommendations. This will
help ensure protable and trouble-free operation of
your spreader. Keep this manual accessible. It is a
handy reference in case minor service is required.
When service is necessary, bring your hopper
spreader to your distributor. They know your spreader
best and are interested in your complete satisfaction.
NOTE: This spreader is designed to spread snow
and ice control materials only. Do not use it
for purposes other than those specied in this
manual.
Lit. No. 43755/43757, Rev. 05 6 September 1, 2021
SAFETY DEFINITIONS
NOTE: Indicates a situation or action that can lead
to damage to your spreader and vehicle or other
property. Other useful information can also be
described.
SAFETY
WARNING/CAUTION LABELS
Please become familiar with the warning and caution
labels on the spreader.
NOTE: If labels are missing or cannot be read, see
your sales outlet.
CAUTION
Indicates a potentially hazardous situation
that, if not avoided, may result in minor or
moderate injury. It may also be used to alert
against unsafe practices.
WARNING
Indicates a potentially hazardous situation
that, if not avoided, could result in death or
serious personal injury.
Lit. No. 43755/43757, Rev. 05 7 September 1, 2021
SAFETY
SERIAL NUMBER LABEL
Code Denition
YY 2‑Digit Year
MM 2‑Digit Month
DD 2‑Digit Day
LL 2-Digit Location Code
XXXX 4-Digit Sequential Number
ZZZZZZ Assembly Part Number
Model No. 00000
Serial No. YYMMDDLLXXXXZZZZZZ
Model No. 00000
Serial No. 000000000000000000
Lit. No. 43755/43757, Rev. 05 8 September 1, 2021
CAUTION
Disconnect electric and/or hydraulic power
and tag out if required before servicing or
performing maintenance.
CAUTION
DO NOT leave unused material in
hopper. Material can freeze or solidify,
causing unit to not work properly.
Empty and clean after each use.
NOTE: Lubricate grease ttings after each use.
Use a good quality multipurpose grease.
FUSES
The electrical system may contain several blade-
style automotive fuses. If a problem should occur
and fuse replacement is necessary, the replacement
fuse must be of the same type and amperage rating
as the original. Installing a fuse with a higher rating
can damage the system and could start a re. Fuse
Replacement is located in the Maintenance section of
this Owner's Manual.
SAFETY
SAFETY PRECAUTIONS
Improper installation and operation could cause
personal injury and/or equipment and property
damage. Read and understand labels and the
Owner's Manual before installing, operating, or making
adjustments.
WARNING
• Driver to keep bystanders minimum of
25 feet away from operating spreader.
• Before working with the spreader, secure all
loose-tting clothing and unrestrained hair.
• Before operating the spreader, verify that all
safety guards are in place.
• Before servicing the spreader, wait for
auger and spinner to stop.
• Do not climb into or ride on spreader.
WARNING
Overloading could result in an
accident or damage. Do not exceed
GVWR or GAWR ratings as found on
the driver‑side door cornerpost of
the vehicle. See Loading section to determine
maximum volumes of spreading material.
CAUTION
If rear directional, CHMSL light, or brake
stoplights are obstructed by the spreader,
the lights shall be relocated, or auxiliary
directional or brake stoplights shall be
installed.
CAUTION
During the hopper spreader installation
we recommend the addition of an OSHA
compliant Backup Alarm. This alarm is
required for OSHA governed employers.
CAUTION
• Do not operate a spreader in need of
maintenance.
• Before operating the spreader, reassemble
any parts or hardware removed for cleaning
or adjusting.
• Before operating the spreader, remove
materials such as cleaning rags, brushes,
and hand tools from the spreader.
• While operating the spreader, use auxiliary
warning lights, except when prohibited by law.
• Tighten all fasteners according to the
Torque Chart. Refer to Torque Chart for the
recommended torque values.
WARNING
Vehicles <10,000 lb GVWR: Obstructing
the visibility from the vehicle's rear camera
could result in serious injury or damage. An
auxiliary camera system shall be installed
if the vehicle's rear camera is removed or
blocked.
Lit. No. 43755/43757, Rev. 05 9 September 1, 2021
VENTILATION
BATTERY SAFETY
FIRE AND EXPLOSION
Be careful when using gasoline. Do not use gasoline
to clean parts. Store only in approved containers away
from sources of heat or ame.
CELL PHONES
A driver's rst responsibility is the safe operation of
the vehicle. The most important thing you can do
to prevent a crash is to avoid distractions and pay
attention to the road. Wait until it is safe to operate
mobile communication equipment such as cell phones,
text messaging devices, pagers, or two-way radios.
CAUTION
Batteries normally produce explosive gases
which can cause personal injury. Therefore,
do not allow ames, sparks, or lit tobacco
to come near the battery. When charging or
working near a battery, always cover your
face and protect your eyes, and also provide
ventilation.
• Batteries contain sulfuric acid which burns
skin, eyes, and clothing.
• Disconnect the battery before removing or
replacing any electrical components.
WARNING
Vehicle exhaust contains lethal fumes.
Breathing these fumes, even in low
concentrations, can cause death. Never
operate a vehicle in an enclosed area without
venting exhaust to the outside.
WARNING
Gasoline is highly ammable and gasoline
vapor is explosive. Never smoke while
working on vehicle. Keep all open ames
away from gasoline tank and lines. Wipe up
any spilled gasoline immediately.
SAFETY
PERSONAL SAFETY
• Remove ignition key and put the vehicle in PARK
or in gear to prevent others from starting the
vehicle during installation or service.
• Wear only snug-tting clothing while working on
your vehicle or spreader.
• Do not wear jewelry or a necktie, and secure long
hair.
• Wear safety goggles to protect your eyes from
battery acid, gasoline, dirt, and dust.
• Avoid touching hot surfaces such as the engine,
radiator, hoses, and exhaust pipes.
• Always have a re extinguisher rated BC handy,
for ammable liquids and electrical res.
Lit. No. 43755/43757, Rev. 05 10 September 1, 2021
CAUTION
Read instructions before assembling.
Fasteners should be nger tight until
instructed to tighten according to torque
chart. Use standard methods and practices
when attaching spreader including proper
personal protective safety equipment.
TORQUE CHART
1/4-20 10
91
54
1/4-28 12
11
71
5/16-1
81
50 212
5/16-2
41
70 240
3/8-16 269 376
3/8-24 29
74
20
7/16-1442
96
06
7/16-20
9/16-12
9/16-18
5/8-11
5/8-18
3/4-10
3/4-16
7/8-9
7/8-14 47
46
69
64
49
091-8
1-12 70
49
95
1/2-13
1/2-20
11.9
13.7
24.6
27.3
43.6
26.9
53.3
93
148
49.4
69.8
77.9
106.4
120.0
8.4
9.7
17.4
19.2
30.8
35.0
49.4
55.2
75.3
85.0
M6 x 1.00
M12 x 1.75
M8 x 1.25
M14 x 2.00
M10 x 1.50
M27 x 3.00
M22 x 2.50
M30 x 3.50
M24 x 3.00
M20 x 2.5011.1
19.5
38.5
67
107
7.7
613
778
1139
1545
450
428
562
796
1117
M33 x 3.50
M36 x 4.00
2101
2701
1468
1952
325
M16 x 2.00 231167
M18 x 2.50 318222
Recommended Fastener Torque Chart
Size Size
Torque (ft-lb)
Grade
5
Grade
8
Metric Fasteners Class 8.8 and 10.9
These torque values apply to fasteners
except those noted in the instructions.
Torque (ft-lb)
Grade
5
Grade
8
Size Size
Torque (ft-lb)
Class
8.8
Class
10.9
Torque (ft-lb)
Class
8.8
Class
10.9
Inch Fasteners Grade 5 and Grade 8
NOISE
Airborne noise emission during use is below 70 dB(A)
for the spreader operator.
VIBRATION
Operating snowplow vibration does not exceed
2.5 m/s2to the hand‑arm or 0.5 m/s2to the whole
body.
SAFETY
Este manual sirve para los siguientes modelos
3
Tabla de contenidos
Otros manuales de Esparcidor de Fisher
Fisher
Fisher QUICK-CASTER 300G Instrucciones de funcionamiento
Fisher
Fisher SWING AWAY Manual de usuario
Fisher
Fisher PRO-CASTER Manual de usuario
Fisher
Fisher 110 Manual de usuario
Fisher
Fisher 1000 Manual de usuario
Fisher
Fisher QUICK-CASTER 300W Instrucciones de funcionamiento
Fisher
Fisher 2500 Series Manual de usuario
Fisher
Fisher POLY-CASTER 78001 Manual de usuario
Fisher
Fisher Hopper Manual de usuario
Fisher
Fisher POLY-CASTER 78601 Manual de usuario
Fisher
Fisher Speed-Caster Manual de usuario
Fisher
Fisher PRO-CASTER 0806 Manual de usuario
Fisher
Fisher M-Scope Gold Bug 2 Manual de usuario
Fisher
Fisher STEEL-CASTER Manual de usuario
Fisher
Fisher WB-100B Instrucciones de funcionamiento
Fisher
Fisher PRO-CASTER Manual de usuario
Fisher
Fisher POLY-CASTER Manual de usuario
Fisher
Fisher 1000-(10003) Manual de usuario
Fisher
Fisher EMERSON 168 Series Manual de usuario
Fisher
Fisher STEEL-CASTER Manual de usuario
Manuales populares de Esparcidor de otras marcas
Ferris
Ferris Pathfinder Series Manual de usuario
Fayat Group
Fayat Group DYNAPAC S100 Guía de solución de problemas
Art's-Way Manufacturing
Art's-Way Manufacturing X700 Manual de instalación y operación
EASTMAN
EASTMAN CR 500 Manual de usuario
Nogueira
Nogueira RoyalFlow-600 Manual de usuario
Buyers
Buyers TGS05B Manual de usuario
