Extech Instruments RPM40 Manual de usuario

USERGUIDE



COMBINATIONPHOTO/CONTACTTACHOMETER



ModelRPM40



www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

Introduction

ThankyouforselectingtheExtechCombinationPhoto/ContactTachometer,ModelRPM40.This

combinationtachometerisapatenteddesignprovidingcontactandnon‐contactRPM

measurements.Inaddition,linearsurfacespeedscanbemeasuredinft/minorm/min.This

deviceisshippedfullytestedandcalibratedand,withproperuse,willprovideyearsofreliable

service.Pleasevisitourwebsite(www.extech.com)tocheckforthelatestversionofthisUser

Guide,ProductUpdates,andCustomerSupport.

Features

Compactpockettachometer

Combinationphotoandcontacttachometer

LaserpointerforPhotoTachometertargeting

Non‐contactPhotoTachometerdetectstargettoadistanceof1.5m(4.9ft.)

Widemeasuringrange0.5to19,999RPM(Contact)and99,999RPM(Photo)

0.1%basicaccuracy

Memory/Recallofhighest,lowest,andlastreadings

Durable,light‐weightABSplastichousing

Safety

1. Useextremecautionwhenthelaserbeamison

2. Donotpointthebeamtowardanyone'seye

3. Becarefulnottoletthebeamstriketheeyefromareflectivesurface

4. Donotusethelasernearexplosivegasesorinotherpotentiallyexplosiveareas



www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

MeterDescription

1. RPMAdapter(Contact)

2. SurfaceSpeedWheel

3. LCDDisplay

4. PhotoDetectSensor

5. Laserpointer(red)

6. MonitorIndicator

7. MeasureButton

8. FunctionButton

9. MemoryButton



Thebatterycompartmentislocatedonbackofmeter.



BatteryReplacement

Thelowbatteryindicatorappearswhenthebatteriesneedtobereplaced.Toreplacethe

batteries:

1. OpentherearbatterycompartmentbyremovingthetwoPhillipsheadscrewsthatsecureit

2. Replacethefour1.5VAAbatteriesobservingcorrectpolarity

3. Replacethebatterycoverbeforeattemptingtousethemeter



Neverdisposeofusedbatteriesorrechargeablebatteriesinhouseholdwaste.

Asconsumers,usersarelegallyrequiredtotakeusedbatteriestoappropriate

collectionsites,theretailstorewherethebatterieswerepurchased,orwherever

batteriesaresold.

Disposal:Donotdisposeofthisinstrumentinhouseholdwaste.Theuserisobligatedtotake

end‐of‐lifedevicestoadesignatedcollectionpointforthedisposalofelectricalandelectronic

equipment.



www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

Operation

Selectingafunction

PressandholdtheMEASUREbutton(7)and,whileholdingMEASURE,useshortpressesofthe

FUNCTIONbutton(8)tostepthroughthemodes.Theavailablemodesare:ContactRPM

measurement,Surfacespeed(m/min),Surfacespeed(ft/min),Surfacespeed(in/min),and

PhotoRPMmeasurement(laserpointerwillswitchONinthismode).



Note:Whenafunctionisselecteditbecomesthedefaultmodeofoperation(evenaftertheunit

ispoweredoff)untilanotherfunctionisselected.

PhotoRPMMeasurement

1. SelectPhotoRPMmeasurementmodeasinstructedintheprevioussection.

2. Applyanappropriatelysizedsquarepieceofreflectivetapetothesurfaceoftheobject

undertest.

3. PressandholdtheMEASUREbuttonandalignthelaserpointerwiththereflectivetape.

Measurementdistanceshouldbelimitedtoadistancerangeof2to60”(5to150cm).

4. VerifythattheMonitorIndicator(6)appearsontheLCDwhenthereflectivetapepasses

throughthebeam.

5. ReleasetheMeasurebuttonwhentheRPMreadingstabilizesontheLCD.

6. Iftherpmisunder50,applyadditionalsquaresofreflectivetape.Dividethereadingshown

onthedisplaybythenumberofpiecesofreflectivetapesquarestocalculatetheactualrpm.



NOTE:Brightambientlightmayinterferewiththereflectedlight.Shadingthetargetarea

maybenecessaryinsomecases.



CAUTION:Rotatingobjectscanbedangerous.Useextremecare.

Photo Tachometer

Rotating object

Reflective tape

Light source

and reflection

www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

ContactRPMMeasurement

1. Installarotatingattachment(coneorfunnel)tothemeter

2. SelectContactRPMmeasurementmodeasdescribedinthe‘Selectingafunction’section.

3. PressandholdtheMEASUREbuttonwhilesimultaneouslyplacingtheRPMadapter(1)

againstthecenteroftherotatingaxistobemeasured.

4. ReleasetheMEASUREbuttonwhenthereadingstabilizes(approximately2seconds).

ReversibleLCDDisplay

TheLCDdisplayindicatesPhotoTachometermeasurementsinonedirectionandContact

measurementsintheoppositedirection.Thispermitstheusertoeasilyreadthemeasurement

digitsinbothmeasurementmodes.

SurfaceSpeedMeasurement

1. SelecttheSurfaceSpeed(m/min,ft/min,orin/min)modeasdescribedaboveinthe

‘Selectingafunction’section.

2. AttachtheSurfaceSpeedwheel(2)tothemeter.

3. PresstheMEASUREbuttonandplacethesurfacespeedwheelagainsttheobjectundertest.

4. ReleasetheMEASUREbuttonwhenthereadingstabilizes(approximately2seconds).

MemoryRecall

Theminimum(dn),maximum(UP),andlast(LA)readingvaluesarestoredinmemoryaftereach

measurement(aftertheMEASUREbuttonisreleased).Toviewthesevalues:

1. PressandholdtheMEMORYbutton(9),thedisplaywilltogglebetweenthestoredreading

anditsidentificationlabel(dnforlowestreading),UPforhighestreading,orLAforlast

reading).

2. ReleasetheMEMORYbuttonandthenpressandholditagaintoviewthenextstored

reading.

3. ReleasetheMEMORYbuttonandthenpressandholditagaintoviewthenextstored

reading.

4. Repeatthesestepsasdesired.



www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

RPM40-en-GB_V1.2 10/14

Specifications

Measurement&RangePhotoTachometer:5to99,999RPM

ContactTachometer:0.5to19,999RPM

SurfaceSpeed:

m/min.–0.05to1,999.9m/min.

ft/min.–0.2to6,560ft/min.

in/min.–2.0to78,740in/min.

ResolutionRPM 0.1RPM(<1000RPM)

1RPM(≥1000RPM)

m/min 0.01m/min(<100m/min)

0.1m/min(≥100m/min.)

ft/min.0.1ft/min.(<1000ft/min.)

1ft/min(≥1000ft/min.).

in/min.0.1in/min.(<1000in/min.).

1in/min.(≥1000in/min.).

DisplayLCD,size:32mmx28mm(1.26x1.10”)

Large5digitreversibledisplaywithunitofmeasureand

alertindicators

Accuracy±(0.1%ofreading+1digit)

SamplingratePhotomode:1second(>60RPM)

Contactmode:1second(>6RPM)

PhotoTachometerdetectingdistanceTypically50to150cm(2to60”)

TimebasecircuitQuartzcrystal

LaserlightsourceLessthan1mW;Class2laserdiode;645nm

OperatingTemperature0to50°C(32to122°F)

OperatingHumidityLessthan80%R.H.

MemoryStores/Recallshighest,lowest,andlastvalues

Battery4x1.5VAAAbatteries

PowerConsumptionPhototachometer:Approximately20mADC

Contacttachometer:Approximately9.5mADC

Dimensions165x50x33mm(6.5x2.0x1.3”)

Weight182g(0.4lbs.)Batteryweightincluded

AccessoriesincludedBatteries,Reflectivetape60cm(24”),Surfacespeed/rpm

rotatingattachments(cone&funnel)



Allrightsreservedincludingtherightofreproductioninwholeorinpartinanyform

www.extech.com

www.GlobalTestSupply.com

Find Quality Products Online at: sales@GlobalTestSupply.com

Tabla de contenidos

Otros manuales de Instrumento de medición de Extech Instruments

Extech Instruments

Extech Instruments RH355 Manual de usuario

Extech Instruments

Extech Instruments NON-DISPLAY PORTABLE Manual de usuario

Extech Instruments

Extech Instruments MA435T-NIST Manual de usuario

Extech Instruments

Extech Instruments RPM33 Manual de usuario

Extech Instruments

Extech Instruments PH220 Manual de usuario

Extech Instruments

Extech Instruments 407113 Manual de usuario

Extech Instruments

Extech Instruments EX613 Manual de usuario

Extech Instruments

Extech Instruments LT45 Manual de usuario

Extech Instruments

Extech Instruments 406800 Manual de usuario

Extech Instruments

Extech Instruments 380560 Manual de usuario

Extech Instruments

Extech Instruments EX845 Manual de usuario

Extech Instruments

Extech Instruments SDL800 Manual de usuario

Extech Instruments

Extech Instruments HD450-NIST Manual de usuario

Extech Instruments

Extech Instruments 407777 Manual de usuario

Extech Instruments

Extech Instruments HD350 Manual de usuario

Extech Instruments

Extech Instruments MA1500 Manual de usuario

Extech Instruments

Extech Instruments UV510-NIST Manual de usuario

Extech Instruments

Extech Instruments Oyster-16 Manual de usuario

Extech Instruments

Extech Instruments MA250 Manual de usuario

Extech Instruments

Extech Instruments EX850 Manual de usuario

Extech Instruments

Extech Instruments ExStik RE300 Manual de usuario

Extech Instruments

Extech Instruments MO230 Manual de usuario

Extech Instruments

Extech Instruments 380941 Manual de usuario

Extech Instruments

Extech Instruments 407764 Manual de usuario

Manuales populares de Instrumento de medición de otras marcas

Suaoki

Suaoki D40 Manual de usuario

Elster

Elster BK-G1.6 Manual de usuario

Endress+Hauser

Endress+Hauser Deltabar FMD71 Manual

Duratool

Duratool D03128 Manual de usuario

Vega

Vega VEGAPULS 65 Manual de usuario

Tonghui

Tonghui TH2618B Manual de usuario

Tenmars

Tenmars TM-801 Manual de usuario

MSR

MSR 145 Manual de usuario

TPS

TPS WP-82 Manual de usuario

ELMETRON

ELMETRON CP-511 Manual de usuario

PCB Piezotronics

PCB Piezotronics 003C30 Manual de usuario

Tenma

Tenma 72-10465 Manual de usuario

Endress+Hauser

Endress+Hauser Proline Promag 50 Especificaciones técnicas

Siemens

Siemens SITRANS F Coriolis FCT030 Manual de lista de piezas

KLINGER

KLINGER CMF V Series Manual de usuario

EXFO

EXFO FTB-2 Manual de operación y mantenimiento

Keysight

Keysight M8290A Manual de usuario

ADTEK

ADTEK MW-5 Manual de usuario