Evikon PluraSens E2608-PID Manual de usuario

PluraSens®

Solvent Vapor Detector-Transmitter

E2608-PID

User Manual

E2608-PID Rev 05.03.2021
Table of contents
Acetone 4
Benzene 5
Ethanol 6
Ethyl acetate 7
Toluene 8
Xylene 9
Speciﬁcations 10
Product description 12
Safety requirements 12
PID (photoionization detector) technology 13
Operating conditions 13
Installation guidelines 14
Wall mount version 14
Duct mount version 14
Mounting dimensions 15
Sensor probe handling 16
Gas sensor replacement procedures 16
Electrical connections 17
Operation 18
Properties of VOC: ionization energy, the correction factor 19
Calibration and maintenance 28
Delivery set 32
Order code for E2608-PID options 32
Conﬁguring 33
Return to default settings 33
2

E2608-PID Rev 05.03.2021

Modbus RTU Communication 34

RS485 communication interface 34

Communication parameters 34

Modbus holding registers 34

Warranty 39

Manufacturer contacts 39

E2608-PID Rev 05.03.2021

Acetone

A colorless organic solvent with a characteristic pungent odor that is volatile and

ﬂammable with the chemical formula (CH3)2CO.

Synonyms/Trade Names: Dimethyl ketone, Ketone propane, 2-Propanone.

Chemical formula

(CH3)2CO

Molar weight

Relative gas density (to air)

2.0

Conversion*

1 ppm = 2.38 mg/m3

Boiling point

56.11 °C

Low explosive limit (LEL), % vol. in air

2.5

Upper explosive limit (UEL), % vol. in air

12.8

Odor

Characteristic pungent smell

Hazards

Highly ﬂammable.

Slightly toxic in normal use. Irritant causing mild skin

irritation and moderate to severe eye irritation. At high

vapor concentrations, it may depress the CNS.

Exposure limits

8 hours

(2000/39/EC)

1900 mg/m3/ 500 ppm

NIOSH REL TWA

590 mg/m3/250 ppm

IDLH (NIOSH)

2500 ppm [10%LEL]

E2608-PID Rev 05.03.2021

Benzene

A colorless liquid with an aromatic odor that is highly ﬂammable with the molecular

formula C6H6.

Synonyms/Trade Names: Benzol, Phenyl hydride.

Chemical formula

C6H6

Molar weight

Relative gas density (to air)

2.69

Conversion*

1 ppm = 3.19 mg/m3

Boiling point

80 °C

Low explosive limit (LEL), % vol. in air

1.2

Upper explosive limit (UEL), % vol. in air

7.8

Odor

Hyacinth-like odor

Hazards

Highly ﬂammable.

Irritant. Carcinogen.

May cause dizziness; headache, nausea, staggering

gait; anorexia, lassitude.

Target organs: eyes, skin, respiratory system, blood,

central nervous system, bone marrow.

Exposure limits

(NIOSH REL)

Ca TWA

0.319 mg/m3/0.1 ppm

STEL

15 minutes

1 ppm

Ca IDLH

500 ppm

E2608-PID Rev 05.03.2021

Ethanol

A clear colorless liquid with a faintly sweet odor and pungent taste.

Synonyms/Trade Names: ethyl, alcohol.

Chemical formula

CH3CH2OH

Molar weight

Relative gas density (to air)

1,59

Conversion*

1 ppm = 1.89 mg/m3

Boiling point

78.37°C

Low explosive limit (LEL), % vol. in air

3 - 3.3

Upper explosive limit (UEL), % vol. in air

Odor

The characteristic smell of alcohol

Hazards

Highly ﬂammable.

Gas/air mixtures are explosive.

Inhalation of vapors leads to cough, headache, fatigue,

and drowsiness. High concentrations may damage the

fetus. Repeated high exposure may affect the liver and

the nervous system.

Exposure limits

according to

Commission

Directive 2006/15/EC

TWA

8 hours

1210 mg/m3/ 1000 ppm

STEL

15 minutes

E2608-PID Rev 05.03.2021

Ethyl acetate

A colorless organic compound with a sweet pear-like smell that is highly ﬂammable.

Synonyms/Trade Names: ethyl ester, acetic ester, EA, EtOAc.

Chemical formula

C4H8O2

Molar weight

Conversion*

1 ppm = 3.60 mg/m3

Boiling point

77.1 °C

Low explosive limit (LEL), % vol.

in air

Upper explosive limit (UEL), %

vol. in air

11.5

Odor

Sweet “pear” smell

Hazards

Flammable.

Short-term exposure to high levels of ethyl acetate results ﬁrst in

irritation of the eyes, nose, and throat, followed by headache,

nausea, vomiting, sleepiness, and unconsciousness.

Exposure limits

(NIOSH)

TWA

8 hours

1400 mg/m3/400 ppm

IDLH

2000 ppm [10%LEL]

E2608-PID Rev 05.03.2021

Toluene

A clear, colorless liquid with a sweet smell that is highly ﬂammable.

Synonyms/Trade Names: methylbenzene, phenylmethane.

Chemical formula

C6H5CH3

Molar weight

Conversion*

1 ppm = 3.77 mg/m3

Boiling point

110.7°C

Low explosive limit (LEL), % vol.

in air

1.1 - 1.27

Upper explosive limit (UEL), %

vol. in air

6.75–7.1

Odor

Characteristic “chemical” smell

Hazards

Highly ﬂammable.

Gas/air mixtures are explosive.

Inhalation possible effects: irritation eyes, nose; lassitude

(weakness, exhaustion), confusion, euphoria, dizziness,

headache; dilated pupils, lacrimation (discharge of tears); anxiety,

muscle fatigue, insomnia; paraesthesia; dermatitis; liver, kidney

damage

Exposure limits

according to

Commission

Directive

2006/15/EC

TWA

192 mg/mm3/ 50 ppm

STEL

384 mg/mm3/ 100 ppm

E2608-PID Rev 05.03.2021

Xylene

A colorless, ﬂammable liquid with a chemical smell. Xylenes are produced by the

methylation of toluene and benzene.

The term is used for any of three isomers of dimethylbenzene, or a combination thereof.

Synonyms/Trade Names: xylol, dimethylbenzene.

Chemical formula

C6H4(CH3)2

Isomers

ortho-xylene meta-xylene para-xylene

Molar weight

106

Conversion*

1 ppm = 4.34 mg/m3

Boiling point

144.4 °C

139 °C

138.35 °C

Low explosive limit (LEL), % vol.

in air

0.9 - 1.1

Upper explosive limit (UEL), % vol.

in air

6.0–7.0

Odor

Characteristic “chemical” smell

Hazards

Flammable.

Inhaling can cause dizziness, headache, drowsiness, and nausea.

Exposure limits

according to

Commission

Directive

2000/39/EC

TWA

8 hours

221 mg/mm3/ 50 ppm

STEL

15 minutes

442 mg/mm3/ 100 ppm

Conversion of ppm to mg/m3is calculated for 25°C and 1 atm.

E2608-PID Rev 05.03.2021

Speciﬁcations

Detected gases

VOCs with ionisation potential < 10.6 eV

Sampling method

Diffusion

Sensor type

Photoionization detector

Calibration

Isobutylene

Order code

E2608-PID-40

E2608-PID-200

Typical detection

ranges

0...40 ppm (isobutylene)

0...200 ppm (isobutylene)

Resolution / digital unit

1 ppb

1 ppm

Response time T90

< 3 s

Sensor lifetime

5 years

Calibration interval

Monthly or more frequently depending on operating conditions

Signal update

Every 1 second

Load resistance

RL< (Us - 2 V) / 22 mA for 4-20 mA

RL> 250 kOhm for 0-10 V mode

Digital interface

RS485, Modbus RTU protocol

No galvanic isolation

Power supply

11...30 VDC (default),

24 VAC or 90...265 VAC as options

Power consumption

< 2 VA

Analog outputs

2 × 4-20 mA / 0-10 V, user settable

Outputs assignment

OUT1: Gas; OUT2: Gas

Relay outputs

2 × SPST, max 5 A, 30 VDC / 250 VAC

Alarm setpoints

Determined by the user within 5-95% of the detection range

Cable connections

Screwless spring-loaded terminals

Enclosure

Light beige ABS, wall mount, protection class IP65

Dimensions

H87 × W82 × D55 mm

CE marking

According to 2014/30/EU and 2014/35/EU, EN 50491-4-1:2012

EN 61000-6-3:2020, EN 61326-1:2013(EMC, emissions)

EN 61000-6-1:2019, EN 61000-6-2:2019(EMC, Immunity)

EN 60079-29-1:2016, EN 60079-29-2:2015 and EN 60079-29-3:2014

Tabla de contenidos

Otros manuales de Transmisor de Evikon

Evikon

Evikon PluraSens E2611-NH3 Manual de usuario

Evikon

Evikon PluraSens E2638-N2O Manual de usuario

Evikon

Evikon PluraSens E2638-O3 Manual de usuario

Evikon

Evikon PluraSens E2618 Series Manual de usuario

Evikon

Evikon PluraSens E2670-CO Manual de usuario

Evikon

Evikon PluraSens E2618-N2O Manual de usuario

Evikon

Evikon PluraSens E2638 Series Manual de usuario

Evikon

Evikon PluraSens E2648-HFC Manual de usuario

Evikon

Evikon PluraSens E2638-NH3-P Manual de usuario

Evikon

Evikon PluraSens E2648-NH3-S Manual de usuario

Evikon

Evikon E2660-CO-CO2 Manual de usuario

Evikon

Evikon PluraSens E2658 Series Manual de usuario

Evikon

Evikon PluraSens E2227 Manual de usuario

Evikon

Evikon PluraSens E2648-N2O Manual de usuario

Evikon

Evikon PluraSens E2660-CO-NO2 Manual de usuario

Evikon

Evikon E2618-NH3 Manual de usuario

Evikon

Evikon PluraSens E2218 Manual de usuario

Evikon

Evikon PluraSens E2658-O3 Manual de usuario

Evikon

Evikon E2618-CO Manual de usuario

Evikon

Evikon E2638-H2S Manual de usuario

Evikon

Evikon PluraSens E2660-CO-NO Manual de usuario

Evikon

Evikon E2615 Series Manual de usuario

Evikon

Evikon PluraSens E2618 Series Manual de usuario

Evikon

Evikon E2618-H2S Manual de usuario

Manuales populares de Transmisor de otras marcas

NIVELCO

NIVELCO EasyTREK SCA-300 Series Manual del propietario

Honeywell

Honeywell 5816WMBR Manual de usuario

Kamstrup

Kamstrup READy MTU Instrucciones de funcionamiento

Omega

Omega ZW Series Manual de usuario

ABB

ABB Field 264H Guía

Alinco

Alinco DJ-V17T Manual de usuario

Dejero

Dejero EnGo 3x Manual de usuario

Rosemount

Rosemount 4600 Manual de usuario

Speaka Professional

Speaka Professional 2342740 Manual de usuario

trubomat

trubomat GAB 1000 Manual de usuario

Teledyne Analytical Instruments

Teledyne Analytical Instruments LXT-380 Manual de usuario

Rondish

Rondish UT-11 Manual de usuario

MG 10JRE Manual de usuario

Burkert

Burkert 8177 Manual de usuario

Firetide

Firetide HotPort 3203 Manual

Tele Radio

Tele Radio T9-02 Manual de usuario

Rotronic

Rotronic HygroFlex HF3 Series Manual de usuario

Jamara

Jamara FCX6 Pro Tel Manual de usuario