EUTHANEX SMARTBOX PRODIGY EA-3300TS Manual de usuario



AutoCO2System

PRODIGYEA‐3300TS



877‐559‐0159TollFreeE‐ZSystems/EuthanexCorp.

610‐882‐3800PhoneP.O.Box3544

610‐882‐3801FaxPalmer,PA18043

www.euthanex.com[email protected] 

2

TABLE OF CONTENTS



Disclaimer____________________________________ 3



SystemOverview_______________________________ 4



Safety________________________________________ 5



SystemSetup__________________________________ 6



OperatingtheSystem___________________________9



AdministratorInstructions_______________________13



Troubleshooting_______________________________23

EMC / EMI.

This equipment has been tested and found to

comply with the limits for a Class A Equipment,

pursuant to part 15 of the FCC rules.

IEC 61326-1:2005 / EZ 61326-1:2006



3

DISCLAIMER:



THISMANUALMUSTBEREADBEFORESETTINGUPANDOPERATINGTHESMARTBOXAUTOCO2

SYSTEM.Theusershouldbethoroughlyfamiliarwiththecontentsofthismanualpriortousingthe

systemwithanimals.Onlytechniciansthatareproperlytrainedshouldoperatethesystem.



Theuser/ownerofthisequipmentshallhavethesoleresponsibilityforanydamageorinjuryresulting

fromoperationthatisnotinaccordancewiththeauthorizedinstructions.

Thisincludes,butisnotlimitedto,operatingtheequipmentoutsideofrecommendedsafetylevels,

variationfromspecifiedoperatinginstructions,andnotfollowingstandardlaboratorysafetyprocedures

whenworkingwithanestheticagentsandvolatilecompressedgases.



ThesystemanditscomponentsmustonlybemodifiedorrepairedbyEuthanex®authorizedservice

technicians.Impropermodificationorrepairmayresultindangertopersonnel,harmordeathto

animal,and/orequipmentdamage.Theuser/ownerofthisequipmentshallhavethesoleresponsibility

foranydamageorinjuryresultingfromimpropermaintenanceandrepairthatisnotdonebyauthorized

maintenanceandrepairpersonnel.



Partsthathavefailed,inwholeorinpart,exhibitexcessivewear,arecontaminatedorareotherwiseat

theendoftheirusefullife,shouldnotbeusedandshouldbereplacedwithpartssuppliedbyEuthanex

Corporation.Tamperingwiththemaincontrolunitbyunauthorizedpersonnelautomaticallyvoidsall

warrantiesandspecifications.Themanufacturerassumesnoresponsibilityforanymalfunctionorfailure

oftheunitiftamperingissuspected.



4

OVERVIEW:



TheSMARTBOX®Prodigyallowsadministratorstoprogramanunlimitednumberofcagesandsizes.The

administratoronlyneedstoselecttheflowratepercentage.TheEA‐33000TSwillautomaticallycalculate

therequiredflowrate.Anunlimitednumberofpassword‐protectedusersaddsevenmoreflexibility.

Eachusercanonlyseethecagesauthorizedbytheadministrator.Theusercanconnectupto3cagesat

onetime.TheTouchScreendisplayshowsthecycle,cycletime,andtotaltimeremaining.



Pleaserefertothe“FlowRate&PresetTimes”sectiontoderivetheAVMArecommendedflowrate.



POWER

SWITCH

DC

POWER

GASIN

GASOUTLETS

TOCAGES



e lightning fla

mbol within an

tended to alert t

insulated "dan

oduct's enclosu

agnitude to con

rsons.

Read these i

Keep these i

Heed all wa

Follow all i

Do not use t

Do not clea

unit.

Do not bloc

Install in ac

instructions.

Do not insta

as radiators,

unit that pro

Do not defe

olarized or

olarized pl

wider than t

has two bla

rong. The

are provided

lug does n

electrician f

outlet.

.Protect the p

on or pinche

convenience

where they

.Unplug this

storms or w

time.

.Refer all ser

ersonnel. S

unit has bee

such as pow

damaged, li

have fallen i

unit has bee

moisture, do

een droppe

h with an arrow

equilateral tria

e user to the p

erous voltage"

e that may be o

titute a risk of

structions.

nings.

structions.

is unit near wa

by spraying liq

any ventilatio

ordance with th

l near any heat

heat registers, s

uce heat.

t the safety pur

grounding-type

g has two blad

e other. A grou

es and a third g

ide blade or th

for your safety.

t fit into your o

r replacement

ower cord from

particularly at

receptacles, an

xit from the uni

nit during ligh

en unused for l

icing to qualifi

rvicing is requ

damaged in an

-supply cord o

uid has been sp

to the unit, the

exposed to rai

s not operate n

hea

gle, is

esence of

ithin the

sufficient

lectric shock to

er.

id directly ont

openings.

manufacturer'

ources such

oves, or othe

ose of the

plug. A

s with one

ding type plug

ounding

third prong

If the provide

tlet, consult an

f the obsolete

being walke

plugs,

the point

ning

ng periods of

d service

red when the

way,

r plug is

lled or objects

rmally, or has

The

inten

oper

the li

War



Caut

Serv



Volt

Press

Tem

xclamation poi

ed to alert the

ting and mainte

erature accomp

ing!



To reduce

do not exp

moisture.



Use line co



Be advised

require the

cord and at

shipped wi

installation



This equip

socket outl

should be



Do not inst



Do not ope

inside.

ion: You are ca

modificati

manual co

this equip



There are



All service

personnel.

ge 100-

selec

re 175

0to

con

t within an equ

ser to the prese

ance (servicin

nying the prod

he risk of fire o

se this unit to r

rd supplied wit

that different o

use of different

achment plugs.

h the requested

requirements c

or the correct p

ent should be

t and disconne

asily accessible

all in a confine

the unit - risk

tioned that any

ns not expressl

ld void your au

ent.

o use

-servicea

must be perfor

40 v ac 50-60h

)

si max to inlet

C<>10to

ensation)

lateral triangle

ce of importan

) instructions i

ct.

electric shock,

in o

the product.

erating voltage

types of line

The unit was

plug. If the

ange please

ug.

nstalled near th

tion of the devi

space.

of electric shoc

change o

approved in th

hority to operat

le parts inside.

ed by qualifie

5 amp Max (a

5%RH(no



SYS

Theunit

1.Theu

mounted

2.Conne

theProdi

3.Conne

valveon

WARNIN

closedan

thesafet

EM SE

omeprepro

itsitsonthe

tothewall

cttheextern

ylocatedo

tthesupplie

heEuthanex

GAS

‐Aminimu

dwillnotop

popoffvalv

ramwithba

tabletopor

iththeoptio

alCO

gaslin

theleftside

dcagehose

Lid.Theuni



ILLNOTFLO

ofonecag

nuntilconn

etoeruptor

esetting.A

anattachto

nalwallmou

efromtheP

.Checkthe



romtheout

willsuppor

WINTOLIDI

mustbeco

cted.Failur

internalhos

ditionalcha

ametalsurf

ntingbracke

Iregulator

lowRateGu

utofthePr

operationo

FTHECOUP

nected.All

etodosowi

stodisconn

ngescanbe

cewiththe

.

rin‐linePSI

detodeter

digy(locate

3cagesina

ERISNOTP

uickdiscon

llcauseover

ect.

ake.Ref.t

agneticfee

egulator,to

inethecorr

ontherigh

cycle.

OPERLYATT

ectfittings

pressurizati

Page12

,Itcanalso

hegasinput

ctPSIsettin

side)tothe

CHED.

renormally

nandmyre

e

of

s.

input

ultin

7

4.PlacetheEuthanexLidonthecage.Toproperlymaketheconnection,pullbackthecouplerandslide

itoverthemalestem.Thecouplerwillsnapbackintoplaceandsecuretheconnection.Thesystemis

readyforoperation.



Setfor20PSIout.

5.AttachtheheatedregulatortotheCO2tank.ItisrecommendedthatTeflontapebeusedontheCO2

tankthreadsbeforeattachingregulator.Useawrenchtotightenthemountedregulator.Setfor20

PSIout.

Werecommendsettingtheincomingpressureto20PSIbutdonotexceed35PSI.Theunitwill

workonlowincomingpressurebutmayresultintheinabilitytoachievehigheroutputflow

rates.

Note:TheEA‐550ElectricallyHeatedRegulatorisrecommendedtooperatethesystem.Usinganon‐

heatedregulatorwilllikelyresultinfrozenCO2lines.

Setupisnowcomplete.

Theimag e cann ot be disp layed. Yo ur comp uter may not hav e enou gh memory too pen the image, o r the image may h ave been co rrup ted. Restart yo ur comp uter, and then op en the file again . If the r ed x still app ears, y ou may hav e to d eleteth e image and then insert it again.

MountedHeatedRegulator



OPE

1)Press

foru

runni

2)Ensu



3)Open

gaug

4)Open

flow

Setther

WARNIN

closedan

thesafet

Werec

The

achi



PSIG

Gas

ATING

theOnswit

e.Ifthisist

nganycycle

ethelid(s)h

thegasflow

shouldber

thegasflow

fgastothe

gulatorto2

‐Aminimu

dwillnotop

popoffvalv

mmend

unitwill

vehighe

uge

alve

THE S

hinthebac

efirsttime

(seeadmini

sbeenplac

fromtheCO

ading800‐

outofther

ontroller.

0PSI.

ofonecag

nuntilconn

etoeruptor

ettingthe

orkonlo

outputfl

STE

oftheunit.

singthesys

tratorinstru

donthecag

tankbytur

50PSIifthe

gulatorbyt

mustbeco

cted.Failur

internalhos

incoming

incomin

wrates.



Theunitwill

emtheoper

tionspg13)

e(s)andhos

ingthetank

ankisfull,l

rningtheco

nected.All

etodosowi

stodisconn

pressure

pressure

bootandco

tingparam

.

sarecorrec

valveknobc

ssifitisnot

trolbarcou

uickdiscon

llcauseover

ect.

o20PSIb

butmayr

etotheho

tersmustbe

lyattachedt

unterclock

fulltank.

terclockwis

ectfittings

pressurizati

utdonot

sultinth

TankVal

nkPressure

escreenre

setupprior

otheunit.

ise.Thelar

.Thisbegin

renormally

nandmyre

xceed35

inability

e

auge

dy

o

ePSI

the

ultin

PSI.

o

9

5)FromtheHomeScreenpress"Start".



Ifpasswordsareactivatedthenextscreenwillbepasswordenter.

6)Selectthecagetypebytouchingthescreenonthecagedesired.Ifthereisalargeamountof

registeredcages,youwillneedtoscrollthroughalisttofindyourdesiredselection.Thenhitnext.



PowerShutdownButton

10



7)Nextyouwillneedtoconfirmthehoseconnectionmessage,thenselectthenumberofcagestobe

usedinthecycle.



NOTE:Thesystemsupportsupto13lpm@20PSI.Ifmultiplelargevolumecagesareselectedandthe

flowrateisexceeded,thesystemwillautomaticallyadjustthecagenumberfortheallowable

amountofconnectedcages.

8) Thesystemwillcyclethroughtwostages:

Stage1Charge:Gasflowstothecages,fullychargingthemwithCO2.



Stage2Dwell:GasflowstopsandthecagesremainsfullychargedwithCO2.

Option:Ifprogrammed,thesystemwillperformasecondCO2chargeanddwellcycle.

Tabla de contenidos

Otros manuales de Unidad de control de EUTHANEX

EUTHANEX

EUTHANEX SMARTBOX EA-32000 Manual de usuario

EUTHANEX

EUTHANEX SMARTBOX EA-32002C Manual de usuario

EUTHANEX

EUTHANEX SMARTBOX EA-34000 Manual de usuario

Manuales populares de Unidad de control de otras marcas

Festo

Festo Compact Performance CP-FB6-E Manual de lista de piezas

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manual de usuario

JS Automation

JS Automation MPC3034A Manual de usuario

JAUDT

JAUDT SW GII 6406 Series Guía rápida

Spektrum

Spektrum Air Module System Manual de usuario

BOC Edwards

BOC Edwards Q Series Manual de usuario

KHADAS

KHADAS BT Magic Manual de usuario

Etherma

Etherma eNEXHO-IL Manual de usuario

PMFoundations

PMFoundations Attenuverter Manual de usuario

GEA

GEA VARIVENT Manual de usuario

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manual de usuario

Altronix

Altronix LINQ8PD Instrucciones de montaje

Eaton

Eaton Powerware Series Manual de usuario

WAGO

WAGO 750-407/040-000 Manual de usuario

Sony

Sony CCU-590 Manual de usuario

Graco

Graco 25D614 Manual de usuario

Task Force Tips

Task Force Tips YE-RF-900 Manual de programación

Shini

Shini SPV-U Series Manual de usuario