Emerson Bettis RP3E Manual de usuario

Bettis RTS Relay Board (RP3E)

Electric Actuator

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

April 2023

Note

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

This page intentionally left blank.

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

Table of Contents

April 2023

Table of Contents

Section 1: Tools

Tools.........................................................................................................................1

Section 2: Material

Material.....................................................................................................................2

Section 3: Installation

Installation................................................................................................................3

Section 4: Programming

Programming............................................................................................................8

Note

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

This page intentionally left blank.

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1 April 2023

Tools 1

Section 1: Tools

! WARNING

Remove all power supplies before doing the exchange. Always act with caution during

the exchange!

• Needle nose pliers

• Screw driver phillips

• Screw driver at

• Allen key 5

• Socket wrench 5

Figure 1.

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

Material

Section 2: Material

• 1x relay board RP3E6A (ID:13009)

• 1x adapter cable (ID:16504)

• 2x steel screw M3x16 (ID:952)

• 3x plastic distance 8 mm (ID:9896)

• 1x plastic screw M3x15 (ID:9895)

• 1x plastic nut M3 (ID:7084)

• 2x lock plates M3 red (ID:13674)

Figure 2.

Figure 3.

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1 April 2023

Installation 3

Section 3: Installation

Unscrew the 4 hexagon socket screws from the cover and remove it carefully. Mind the

connection cable between display and logic board.

Figure 4.

Unscrew the 4 cross recessed screws from the existing logic board and afterwards, tilt it

carefully to you.

Figure 5.

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

Installation4

Section 3: Installation

Remove carefully the connected cables: ribbon cable and 6-, 8- and 10-pole plugs

(see Figure 6, left image). Afterwards, you can remove the logic board from the control

unit and disconnect the second ribbon cable on the back (see Figure 6, right image).

Figure 6.

Remove the two steel spacers (marked with the black arrows in Figure 7) in the housing.

Figure 7.

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1 April 2023

Installation 5

Section 3: Installation

Place the 8 mm plastic spacers on the relay board as shown in the top image of Figure 8.

Insert the M3x16 steel screws through the holes next to the multi-pin connectors in the

logic board as shown in the bottom image of Figure 8. Then line up the screws with the

plastic spacers in the relay board and secure the screws with the red lock plates. For the

third hole, use the plastic screw M3x15 and secure it in place with the plastic nut.

Figure 8.

Connect the relay board with the multi-pin connector from the logic board.

! WARNING

The four pins on the left side must remain disconnected (see Figure 9).

The orientation of the mounting holes on both the logic and relay boards plus the spacers

must be aligned as shown in Figure 9.

Figure 9.

April 2023

Installation, Operation and Maintenance Manual

VCIOM-15746-EN Rev. 1

Installation6

Section 3: Installation

Connect the 10- and 6-pole connectors to the adapter cables, then connect the blue

connectors of the adapter cables to the corresponding connectors on the relay board.

Figure 10.

Otros manuales para Bettis RP3E

Tabla de contenidos

Otros manuales de Controladores de Emerson

Emerson

Emerson dixell XR02CX Diagrama de cableado

Emerson

Emerson Vilter MicroVission Manual de operación

Emerson

Emerson Hytork XL Series Manual de instalación y funcionamiento

Emerson

Emerson Dixell XR60CH Diagrama de cableado

Emerson

Emerson Bettis GTD Series Instrucciones de funcionamiento

Emerson

Emerson Dixell IEV12D Diagrama de cableado

Emerson

Emerson Unidrive M400 Manual de usuario

Emerson

Emerson Bettis RGS F Series Manual de usuario

Emerson

Emerson dixell XC10CX Diagrama de cableado

Emerson

Emerson Dixell XRB60CHC Diagrama de cableado

Emerson

Emerson Fisher 627 Series Manual de usuario

Emerson

Emerson Fisher 785C Manual de usuario

Emerson

Emerson Alco Controls CS1 Series Manual de usuario

Emerson

Emerson Control Link Manual de usuario

Emerson

Emerson Branson 2000X Manual de usuario

Emerson

Emerson Fisher FIELDVUE DVC6200 SIS Manual de usuario

Emerson

Emerson Fisher FIELDVUE DVC6000f Manual de usuario

Emerson

Emerson Dixell XR70CX Diagrama de cableado

Emerson

Emerson EZH Manual de usuario

Emerson

Emerson AMPGARD RVSS Manual de usuario

Emerson

Emerson XM678D Hoja de especificaciones

Emerson

Emerson Bettis RTS CL Series Manual de usuario

Emerson

Emerson Topworx D Series Manual de usuario

Emerson

Emerson Fisher Y692VB Series Manual de usuario

Manuales populares de Controladores de otras marcas

Digiplex

Digiplex DGP-848 Instrucciones de funcionamiento

YASKAWA

YASKAWA SGM series Manual de usuario

Sinope

Sinope Calypso RM3500ZB Manual de usuario

Isimet

Isimet DLA Series Style 2 Manual de instalación

LSIS

LSIS sv-ip5a Manual de usuario

Rockwell Automation

Rockwell Automation 1769-L31 Manual de usuario

Airflow

Airflow Uno hab Manual de usuario

ABB

ABB ACS580-01 drives Manual de usuario

Panasonic

Panasonic GM1 Series Manual de usuario

AutoAqua

AutoAqua Smart ATO micro SATO-120P Manual de usuario

Panasonic

Panasonic FP? Positioning Unit RTEX Manual de usuario

Samson

Samson Type 5824 Manual de servicio

Alpha IP

Alpha IP MIOB 21001 Manual de usuario

Siemens

Siemens OpenAir GMA 1 Series Manual de usuario

Surecom

Surecom SR-629 Manual de usuario

Fishman

Fishman TriplePlay Manual de usuario

Regulus

Regulus SRS1 T Manual de usuario

3M MicroTouch EX113 Manual de usuario