Elvaco CMeX 30 Guía de instalación

INTRODUCTION

The CMeX30 is a digital to analog converter (D/A module) with an

output voltage range from 0-10 V or current output range from 4-20

mA. The value is set through standard M-Bus commands. CMeX30

has a high accuracy, is reliable and can be used for advanced control

processes. For a complete description of the product or for information

in Swedish, visit the Elvaco AB website, www.elvaco.com.

OVERVIEW

CMeX 30

DIN-mounted M-Bus D/A module

1. Serial number

2. M-Bus connector

3. Screw terminal for

4-20mA/0-10V

4. Power supply L

5. Power supply N

6. Status LED (green)

7. Error LED (red)

MOUNTING

The CMeX30 should be mounted on a DIN-rail. The metallic clip on the

bottom is used to mount and demount the unit from the DIN-rail. DIN-

rail enclosure must cover the terminals.

POWER SUPPLY

The installation must be performed by a qualiﬁed electrician or installer

with required knowledge. The power supply should be connected to

screw terminals (4) and (5). The voltage should be 100-240 VAC, 50/60

Hz. The power supply should be connected via a clearly marked switch

placed close to CMeX30, so the unit can be switched off during service

work.

M-BUS 2-WIRE BUS

M-Bus is a multi-drop 2-wire bus with no polarity. Use a cable of area

0.25-1.5 mm2, e.g. a standard telephone cable (EKKX 2x2x0.5). Connect

the wiring to the connector (2).

IMPORTANT

• All connected M-Bus slave devices must have unique primary or

secondary M-Bus addresses depending on addressing mode.

• Measure voltage over M-Bus slave connection to verify M-Bus

master connection. Voltage should be between 21-42 VDC.

LED INDICATIONS

The product is equipped with a green and red LED. The green LED

shows the operation status of the product. When the green LED is

permanently on, the product is powered up and ready to use. When the

green LED is ﬂashing, the product is communicating via M-Bus. The red

LED indicates that the M-Bus 2-wire is not properly connected.

Green LED

Mode Product state Visual

On The unit is in operation

mode

200 ms off/ 200

ms on/200 ms

off/ 200 ms on

The unit has received

M-Bus telegram

Red LED

Mode Product state Visual

On M-Bus missing

CONNECTION OF OUTPUT 0-10 V

CMeX30 can be connected to any analog voltage input that can handle

0-10 V. Connect the negative cable (signal GND) to the center terminal

of screw terminal (3), the signal is connected to the right terminal of

screw terminal (3).

inadequacies. Elvaco AB takes no responsibility for damages, liabilities or other losses by using this product. No part of the contents of this

manual may be transmitted or reproduced in any form by any means without the written permission of Elvaco AB. Printed in Sweden.

CMeX30 Quick manual A4 English

Document id: 1090065

Version: 3.0

Mechanics

Protection class IP20

Dimensions 90x65x36 mm

Weight 100 g

Connection M-Bus Pin terminal solid wire 0.6- 0.8 Ø mm

Mounting DIN mounted

Power supply Screw terminal cable 0.75-2.5 mm², 0.5 Nm

tightening torque

Electrical

Nominal voltage 100-240 VAC

Voltage range -10 % to +10 % of nominal voltage

Frequency 50/60 Hz

Power consumption (max) 2.5 W

Power consumption (nom) 1 W

Installation category CAT 2

Environmental

Operating temperature range -30 °C to +55 °C

Storage temperature range -40 °C to +85 °C

Pollution Degree 2

Operating altitude 0-2000 m

M-Bus

M-Bus standard EN 13757

M-Bus baud rate 300, 2400 Bit/s

M-Bus load 1T (1.5 mA)

Maximum cable length Is dependent of master

IR interface No

Analog output

Output types 4-20 mA and 0-10 V cannot be controlled

individually

Connection Pluggable screw terminal

Min input impedance 4-20 mA TBD

Max load current 0-10 V TBD

Approvals

EMC EN 61000-6-2, EN 61000-6-3

Safety EN 61010-1, CAT 2

Product Part number Description

CMeX30 1050 014 DIN-mounted M-Bus D/A module

ORDERING INFORMATION

CONTACT INFORMATION

Elvaco AB Technical support:

Phone: +46 300 434300

E-mail: support @elvaco.com

Online: www.elvaco.com

TECHNICAL SPECIFICATIONS

CONNECTION OF OUTPUT 4-20 MA

CMeX30 can be connected to any passive current input that can handle

4-20 mA. Connect the signal cable for 4-20 mA to the left terminal of

screw terminal (3). Connect the negative cable (signal GND) to the

center terminal of screw terminal (3).

TROUBLESHOOTING

CMeX30 does not respond to M-Bus master commands

Verify your M-Bus slave conﬁguration and connection:

• Voltage over M-Bus connection should be between 21 VDC and 42

VDC. Red LED will indicate error.

• All M-Bus slaves connected to the M-Bus master must have

unique primary addresses or secondary addresses depending on

addressing mode.

• Verify M-Bus slave baud rate used by M-Bus master. M-Bus

master baud rate must be identical to M-Bus slave baud rate.

CMeX30 cannot control the connected unit

Disconnect the cables to the unit to be controlled, e.g. the actuator.

Measure the output with a multimeter while an M-Bus command is

sent to change the output. If this works, there is probably an error in the

connection to the input of the unit to be controlled.

SAFETY

The warranty does not cover damage to the product caused by usage

in any other way than described in this manual. Elvaco AB can not be

liable for personal injury or property damage caused by usage in any

other way than described in this manual.

Products:

Thisdeclarationo

Product

M‐BusSplitter



Theob ject(s)ofthedecl

EMCDirectiv

RoHS2011/6

Andareinconformitywi

EN55022(Ra

EN61000‐4‐6

EN61000‐4‐3

EN61000‐4‐2



Kungsbacka,Sweden,20

DavidVonasek,CEO



Thisdeclarationo

Product

CMeX50



Theob ject(s)ofthedecl

LVDDirective

EMCDirectiv

RadioEquip

RoHS2011/6

Andareinconformitywi

IEC61010‐1(

EN55022(Ra

EN61000‐4‐6

EN61000‐4‐3

EN61000‐4‐1

EN61000‐4‐4

EN61000‐4‐5

EN61000‐4‐2



Kungsbacka,Sweden,20

DavidVonasek,CEO



Thisdeclarationo

Product

CMeX20w



Theob ject(s)ofthedecl

LVDDirective

EMCDirectiv

RadioEquip

RoHS2011/6

Andareinconformitywi

IEC61010‐1(

EN55022(Ra

EN61000‐4‐6

EN61000‐4‐3

EN61000‐4‐1

EN61000‐4‐4

EN61000‐4‐5

EN61000‐4‐2

EN300220‐1



Kungsbacka,Sweden,20

DavidVonasek

CEO



Thisdeclarationo

Product

CMeX30



Theob ject(s)ofthedecl

LVDDirective

EMCDirectiv

RoHS2011/6

Andareinconformitywi

IEC61010‐1(

EN55022(Ra

EN61000‐4‐6

EN61000‐4‐3

EN61000‐4‐1

EN61000‐4‐4

EN61000‐4‐5

EN61000‐4‐2



Kungsbacka,Sweden,20

DavidVonasek,CEO



M‐BusSplitt

CMeX50

CMeX20w

CMeX30

EUDECLARATIONOF

conformityisissuedunderthe

acoAB,Teknikgatan18,S‐4343



YearofCE‐marking

2016

rationlistedaboveisinconformitywithth

2014/30/EU

/EU

hthefollowingharmonizationstandardso

iatedemission)

(ImmunitytoHF‐injection)

(ImmunitytoRF‐field)

(ImmunitytoESD)

6‐04‐16



EUDECLARATIONOF

conformityisissuedunderthe

acoAB,Teknikgatan18,S‐4343



YearofCE‐marking

2016

rationlistedaboveisinconformitywithth

2014/35/EU

2014/30/EU

entDirective2014/53/EU

/EU

hthefollowingharmonizationstandardso

d.3 )

iatedemission)

(ImmunitytoHF‐injection)

(ImmunitytoRF‐field)

1(Immunitytovoltagevariation)

(Immunitytoburst)

(Immunitytosurge)

(ImmunitytoESD)

6‐04‐16



EUDECLARATIONOF

conformityisissuedunderthe

acoAB,Teknikgatan18,S‐4343



YearofCE‐marking

2016

rationlistedaboveisinconformitywithth

2014/35/EU

2014/30/EU

entDirective2014/53/EU

/EU

hthefollowingharmonizationstandardso

d.3 )

iatedemission)

(ImmunitytoHF‐injection)

(ImmunitytoRF‐field)

1(Immunitytovoltagevariation)

(Immunitytoburst)

(Immunitytosurge)

(ImmunitytoESD)

(SRDLowpowerradioequipment)

6‐04‐16



EUDECLARATIONOF

fconformityisissuedunderthes

acoAB,Teknikgatan18,S‐4343



YearofCE‐marking

2016

rationlistedaboveisinconformitywithth

2014/35/EU

2014/30/EU

/EU

ththefollowingharmonizationstandardsor

d.3 )

iatedemission)

(ImmunitytoHF‐injection)

(ImmunitytoRF‐field)

1(Immunitytovoltagevariation)

(Immunitytoburst)

(Immunitytosurge)

(ImmunitytoESD)

6‐04‐16



ONFORMITY



oleresponsibilityofthemanufa

Kungsbacka,Sweden.

relevantCommunityharmonizationlegisla

othernormativedocuments:



ONFORMITY



oleresponsibilityofthemanufa

Kungsbacka,Sweden.

relevantCommunityharmonizationlegisla

othernormativedocuments:



ONFORMITY



oleresponsibilityofthemanufa

Kungsbacka,Sweden.

relevantCommunityharmonizationlegisla

othernormativedocuments:



ONFORMITY



oleresponsibilityofthemanufa

Kungsbacka,Sweden.

relevantCommunityharmonizationlegisla

othernormativedocuments:



turer:

ion:

turer:

ion:

turer:

ion:

turer:

ion:

roducts:CM

roducts:



CMi

roducts:CMi

EUDEC

Thisdeclarationofconformit

ElvacoAB,Te

ProductYearo

CMa30USBM‐BusMaster2016



Theobject(s)ofthedeclarationlistedab

EMCDirective2014/30/EU

RoHS2011/65/EU

Andareinconformitywiththefollowing

EN55022(Radiatedemission)

EN61000‐4‐6(ImmunitytoH

EN61000‐4‐2(ImmunitytoE



Kungsbacka,Sweden,2016‐04‐16



DavidVonasek,CEO



EUDEC

Thisdeclarationofconformit

ElvacoAB,Te

ProductYearo

CMa35USBOpticalEye2016



Theobject(s)ofthedeclarationlistedab

EMCDirective2014/30/EU

RoHS2011/65/EU

Andareinconformitywiththefollowing

EN55022(Radiatedemission)

EN61000‐4‐6(ImmunitytoH

EN61000‐4‐2(ImmunitytoE



Kungsbacka,Sweden,2016‐04‐16



DavidVonasek,CEO



EUDEC

Thisdeclarationofconformit

ElvacoAB,Te

ProductYearo

CMi2110A2016



Theobject(s)ofthedeclarationlistedab

EMCDirective2014/30/EU

RoHS2011/65/EU

Andareinconformitywiththefollowing

EN55022(Radiatedemission)

EN61000‐4‐6(ImmunitytoH

EN61000‐4‐3(ImmunitytoR

EN61000‐4‐11(Immunityto

EN61000‐4‐4(Immunitytob

EN61000‐4‐5(Immunitytos

EN61000‐4‐2(ImmunitytoE

EN300220‐1(SRDLowpowe

EN300220‐2

EN3010511:v.9.0.2(Gemalto

)



Kungsbacka,Sweden,2016‐04‐16



DavidVonasek,CEO



EUDEC

Thisdeclarationofconformit

ElvacoAB,Te

ProductYearo

CMip2110ML+GUH50PS100‐2402016



Theobject(s)ofthedeclarationlistedab

LVDDirective2014/35/EU

EMCDirective2014/30/EU

RoHS2011/65/EU

Andareinconformitywiththefollowing

IEC61010‐1(ed.3)

EN55022(Radiatedemission)

EN61000‐4‐6(ImmunitytoH

EN61000‐4‐3(ImmunitytoR

EN61000‐4‐11(Immunityto

EN61000‐4‐4(Immunitytob

EN61000‐4‐5(Immunitytos

EN61000‐4‐2(ImmunitytoE



Kungsbacka,Sweden,2016‐04‐16



David Vonasek, CEO

30USBM‐Bu

35USBOptic

110A

2110ML+G

ARATIONOFCONFO

isissuedunderthesoleresponsi

nikgatan18,S‐43437Kungsback



CE‐marking

veisinconformitywiththerelevantComm

harmonizationstandardsorothernormativ



‐injection)

D)

ARATIONOFCONFO

isissuedunderthesoleresponsi

nikgatan18,S‐43437Kungsback



CE‐marking

veisinconformitywiththerelevantComm

harmonizationstandardsorothernormativ



‐injection)

D)

ARATIONOFCONFO

isissuedunderthesoleresponsi

nikgatan18,S‐43437Kungsback



CE‐marking

veisinconformitywiththerelevantComm

harmonizationstandardsorothernormativ



‐injection)

‐field)

oltagevariation)

rst)

rge)

D)

radioequipment)

)



ARATIONOFCONFO

isissuedunderthesoleresponsi

nikgatan18,S‐43437Kungsback



CE‐marking

veisinconformitywiththerelevantComm

harmonizationstandardsorothernormativ



‐injection)

‐field)

oltagevariation)

rst)

rge)

D)

sMaster

lEye

H50PS100‐

MITY



bilityofthemanufacturer:

a,Sweden.

unityharmonizationlegislation:

documents:

MITY



bilityofthemanufacturer:

a,Sweden.

unityharmonizationlegislation:

documents:

MITY



bilityofthemanufacturer:

a,Sweden.

unityharmonizationlegislation:

documents:



MITY



bilityofthemanufacturer:

a,Sweden.

unityharmonizationlegislation:

documents:



Elvaco AB, Kabelgatan 2T, S-43437 Kungsbacka, Sweden

Tabla de contenidos

Otros manuales de Unidad de control de Elvaco

Elvaco

Elvaco CMi4130 Manual de usuario

Elvaco

Elvaco CMi6110 Manual de usuario

Elvaco

Elvaco CMi4110 Manual de usuario

Elvaco

Elvaco CMi6160 Manual de usuario

Elvaco

Elvaco CMi2130G3 Guía de instalación

Elvaco

Elvaco CMi6110 Manual de usuario

Elvaco

Elvaco CMi4140 Manual de usuario

Elvaco

Elvaco CMi Series Manual de usuario

Manuales populares de Unidad de control de otras marcas

Festo

Festo Compact Performance CP-FB6-E Manual de lista de piezas

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manual de usuario

JS Automation

JS Automation MPC3034A Manual de usuario

JAUDT

JAUDT SW GII 6406 Series Guía rápida

Spektrum

Spektrum Air Module System Manual de usuario

BOC Edwards

BOC Edwards Q Series Manual de usuario

KHADAS

KHADAS BT Magic Manual de usuario

Etherma

Etherma eNEXHO-IL Manual de usuario

PMFoundations

PMFoundations Attenuverter Manual de usuario

GEA

GEA VARIVENT Manual de usuario

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manual de usuario

Altronix

Altronix LINQ8PD Instrucciones de montaje

Eaton

Eaton Powerware Series Manual de usuario

WAGO

WAGO 750-407/040-000 Manual de usuario

Sony

Sony CCU-590 Manual de usuario

Graco

Graco 25D614 Manual de usuario

Task Force Tips

Task Force Tips YE-RF-900 Manual de programación

Shini

Shini SPV-U Series Manual de usuario