EKF C23-SATA Manual

Technical Information

C23-SATA

Mezzanine I/O Expansion Board

PCIe to SATA RAID Controller

Document No. 5208 • Ed. 2 • 2009-03

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

Contents

AboutthisManual ........................................................... 4

EditionHistory......................................................... 4

RelatedDocuments ..................................................... 5

Nomenclature ......................................................... 5

TradeMarks .......................................................... 5

Legal Disclaimer - Liability Exclusion ......................................... 5

Standards ............................................................ 6

C23-SATAFeatures .......................................................... 7

FeatureSummary ...................................................... 7

ShortDescription....................................................... 9

FrontPanel .......................................................... 11

BlockDiagramC23-SATA ............................................... 12

TopViewComponentAssemblyC23-SATA .................................. 14

Front Panel Connectors ................................................. 16

On-Board Connectors .................................................. 16

Jumpers ............................................................ 17

Inter-Board Connectors ................................................. 17

InstallingandReplacingComponents............................................ 18

BeforeYouBegin...................................................... 18

Warnings ...................................................... 18

Caution ....................................................... 18

InstallingtheBoard .................................................... 19

RemovingtheBoard ................................................... 20

EMCRecommendations................................................. 21

Technical Reference - Connectors ............................................... 22

Caution............................................................. 22

PleaseNote .......................................................... 22

Front Panel Connectors ................................................. 23

COM-A (RS-232/RS-485) ........................................... 24

COM-B COM-C (RS-232) ........................................... 26

Audio Connector ................................................ 27

On-Board Connectors .................................................. 28

P-AUDIO....................................................... 29

P-IDE ......................................................... 30

P-KM ......................................................... 31

P-SATA0 P-SATA1 ............................................... 31

P-SP4 ......................................................... 32

P-UFD......................................................... 34

P-USB ......................................................... 35

On-BoardJumpers..................................................... 36

J-RES ......................................................... 36

J-FWH2 ....................................................... 36

J-SER ......................................................... 36

J-TRM1J-TRM2.................................................. 36

Inter-Board Connectors ................................................. 37

P-EXP ......................................................... 39

P-PCIE......................................................... 40

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

Additional Functions ........................................................ 42

FirmwareHub2 ...................................................... 42

SMBusEEPROM ...................................................... 42

TrustedPlatformModule................................................ 43

Schematics................................................................ 44

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

About this Manual

This manual is a short form description of the technical aspects of the C23-SATA, required for

installation and system integration. It is intended for the advanced user only.

Edition History

EKF

Document

Ed. Contents/Changes Author Date

Text # 5208

c23_tie.wpd

1 Technical Information C23-SATA

English, Preliminary Edition

jj 21 July 2008

2 Audio Codec is either AC'97 or HD Audio

(stuffing option)

jj 16 March 2009

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

Related Documents

For a description of the CCG-RUMBA CPU card, which acts as carrier board with respect to the

C23-SATA, please refer to the correspondent CPU user guide, available by download from

www.ekf.com/c/ccpu/ccg/ccg_e.html (change path accordingly for other possible CPU carrier boards).

Nomenclature

Signal names used herein with an attached '#' designate active low lines.

Trade Marks

Some terms used herein are property of their respective owners, e.g.

<Intel, Pentium, Celeron, Core 2 Duo, Merom, Penryn, iAMT: ® Intel

<Santa Rosa Platform, Crestline Chipset GM965: Intel

<Montevina Platform, Cantiga Chipset GS45: Intel

CompactPCI

: ® PICMG

<Windows 2000, Windows XP, Windows Vista: ® Microsoft

<EKF, ekf system: ® EKF

EKF does not claim this list to be complete.

Legal Disclaimer - Liability Exclusion

This manual has been edited as carefully as possible. We apologize for any potential mistake.

Information provided herein is designated exclusively to the proficient user (system integrator,

engineer). EKF can accept no responsibility for any damage caused by the use of this manual.

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

Standards

Specifications/Standards

PCI Express PCIe Base Spec. 1.1 and other (PCI SIG www.pcisig.com)

SATA Serial ATA 2.5/2.6 Specification (www.sata-io.org)

USB Universal Serial Bus Revision 2.0 specification (www.usb.org/developers)

TPM Trusted Platform Module 1.2

(https://www.trustedcomputinggroup.org)

AC'97 Audio Audio Codec '97 Revision 2.3 April 2002 (Intel®)

HD Audio High Definition Audio Specification Rev.1.0

http://www.intel.com/design/chipsets/hdaudio.htm

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

C23-SATA Features

Feature Summary

Form Factor Single size cropped Eurocard (112x100mm2), needs 4HP (20.3mm) mounting space in

addition to CPU carrier board, typically delivered as a ready to use assembly unit (including

the CCG-RUMBA or successor CPU card), provided with a common 8HP front panel shared

with the CPU board, mounting position right (on top of CPU board)

SATA/PATA 3<JMB363 PCIe to 2 x SATA II / 1 x PATA controller

<RAID level 0/1 capable, drivers RAID or non-RAID

<SATA/PATA connectors for system internal usage

LPC Super-I/O 3

(SIO2)

<SCH3114, 4 serial ports, PS/2 keyboard & mouse port

<Up to three serial COM ports RS-232 available from the front panel (9-position

male D-Sub connectors)

<COM-A configurable as either RS-232 or RS-485 compliant

<COM-B & COM-C conform to RS-232

<COM-C may be replaced by Audio I/O female D-Sub connector (option)

<SP4 available for attachment of an EKF CU-Series PHY module (TTL-level COM-Port

on 10-position pin header)

Firmware Hub 3

(FWH2)

<82802 generic device, 8Mbit Flash, LPC interface

<Can be configured (jumper) as secondary or primary (boot code) FWH

TPM 3<Option Trusted Platform Module cryptographic chip according to TPM 1.2

<Infineon or Atmel brand (standard footprint)

Audio Codec 2, 3 <Option AC'97 audio codec ALC203

<Alternate Option HD Audio Codec ALC262

<Realtek driver available

<On-board 10-position pin header

<Option front panel audio connector (replaces COM-C)

Front Panel

Connectors 1

<3 x COM port connectors (9-position male D-Sub) COM-A COM-B COM-C

<Option Audio connector (9-position female D-Sub), replaces COM-C

Host I/F Connectors

(to CPU Carrier) 1

<PCI Express interface (PCIe x 1) high speed connector

<Multifunction expansion interface (LPC, USB, SMB)

On-Board I/O

Connectors 1

<Option PATA (IDE) 40-position pin header, horizontal oder vertical

<2 x Latched SATA headers 7-pos.

<Option PS/2 keyboard/mouse 10-position pin header

<USB receptacle for system internal usage

<Option pin header suitable for low profile USB Solid State Drive (SSD) module

<Option serial port header (TTL-level)

<Option Audio I/O 10-position pin header

<Reset

On-Board Jumpers 1<Reset

<Firmware Hub selection

<COM-A configuration RS-232 or RS-485

<RS-485 Termination resistors

On-Board Functions Speaker, LEDs, SMBus EEPROM, temperature sensors

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

Mass Storage

Options

<Up to 2 system internal PATA/IDE drives configured as master/slave attached by

flat cable harness

<Up to 2 system internal SATA drives optionally attached to SATA headers via cable

assembly

<USB Solid State Drive (SSD) module option

<USB drive attached to USB connector

Thermal

Conditions 4

Environmental

Conditions 4

<Operating temperature: 0°C ... +70°C

<Storage temperature: -40°C ... +85°C, max. gradient 5°C/min

<Humidity 5% ... 95% RH non condensing

<Altitude -300m ... +3000m

<Shock 15g 0.33ms, 6g 6ms

<Vibration 1g 5-2000Hz

EC Regulations <EN55022, EN55024, EN60950-1 (UL60950-1/IEC60950-1)

<2002/95/EC (RoHS)

MTBF tbd

1Not all of these connectors may be present or functional on your actual C23-SATA board.

Assembly of these connectors is highly custom specific. Discuss your needs with EKF before

ordering.

2Requires CPU carrier board with AC'97 audio support. Contact EKF for an Azalia HD Audio

compliant variant of the C23-SATA. The audio facility is provided in the ICH component (AKA

southbridge), located on the CPU carrier board. Latest ICH versions no longer support AC'97.

3Silicon/function may not be present on your actual C23-SATA board. Assembly of components

is highly custom specific. Discuss your needs with EKF before ordering.

4Hard disk option may require decrease

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

Short Description

Available as a mezzanine add-on expansion

board to the CCD-CALYPSO, CCG-RUMBA and

successor CPU cards, the C23-SATA provides a

number of additional I/O functions. First of all,

the C23-SATA comprises an SATA/PATA

controller, which is useful for system internal

attachment of mass-storage devices (e.g. hard

disks or SATA SSD, and optical drives).

Furthermore the C23-SATA is equipped with an

SIO, which provides legacy I/O ports, such as

serial COM ports, and PS/2 KB/MS. A secondary

Firmware Hub can be configured as alternate-

or backup-BIOS. Another option available is the

Trusted Platform Module according to TPM 1.2

for safety critical applications.

The C23-SATA will be attached on top of the

CPU carrier board, and typically shares its front

panel with the host carrier (usually 8HP front

panel width in total). Interconnection between

the C23-SATA I/O module and the CPU carrier

board is achieved by two expansion connectors,

which comprise the PCIe (PCI Express x 1) and

LPC (Low Pin Count) interfaces.

As an option, the C23-SATA can accommodate

a low profile industrial grade USB Flash disk

module (Silicon State Drive).

The on-board Audio Codec might be useful for

applications such as passenger information

systems.

C23-SATA on a CPU Carrier Board (8HP Assembly)

Technical Information C23-SATA • PCIe to SATA RAID Controller Mezzanine Card

The C23-SATA communicates by means of two

bottom mount expansion connectors with the

host CPU: P-PCIE (PCI Express x 1), and P-EXP

(multi-function I/F such as LPC, USB, SMB,

AC'97).

The PCI Express interface (connector P-PCIE)

requires a single lane (one of up to 4 PCIe lanes

provided by the CPU carrier board), which is

derived from the ICH (southbridge chip) on the

CPU carrier board. The PCIe lane is dedicated to

the SATA controller, which is the main

component of the C23-SATA.

Connector P-EXP combines several other

southbridge data channels: The LPC (Low Pin

Count) is a multiplexed ISA bus, e.g. enabling

the super-I/O (SIO) controller chip to emulate

the legacy I/O interfaces; among these are the

classic serial (COM) ports, AKA RS-232 / RS-485.

In addition, two USB channels are provided on

the P-EXP connector, in use for the optional on-

board USB SSD mezzanine module, and a type

A USB receptacle.

If audio support is required on the C23-SATA,

either an AC'97 audio codec (CCD-CALYPSO),

or HD Audio codec (CCG-RUMBA,

CCM-BOOGIE) can be stuffed, dependent from

the particular CPU carrier board in use.

The Trusted Platform Module is an optionally

available cryptographic chip, which provides a

comprehensive hardware and software solution

for safer computing. Conforming to the TPM1.2

standard of the TCG, the TPM is comprised of a

16-bit security controller and additional

hardware e.g. to generate 2048 bit RSA keys

and true random numbers, thus meeting the

highest industry rating for digital security.

The C23-SATA fits on the top side of the CPU

board, which is on the right side when viewing

the common front panel. A suitable backplane

provides its CPCI slots beginning with the CPU

carrier board (CPCI system slot) from right to

left. The CPCI enclosure must provide sufficient

mounting space to the right side for the

C23-SATA.

Tabla de contenidos

Otros manuales de Hardware de computadora de EKF

EKF

EKF SC4-CONCERTO Manual de usuario

EKF

EKF SC2-PRESTO CompactPCI Manual de usuario

EKF

EKF C40-SCFA Manual

EKF

EKF CompactPCI CC5-RAVE Manual de usuario

EKF

EKF SC9-TOCCATA Manual de usuario

EKF

EKF PCZ-NVM Manual

EKF

EKF PC4-PRESTO Manual de usuario

EKF

EKF C41-CFAST Manual

EKF

EKF PC6-TANGO Manual de usuario

EKF

EKF PC7-FESTIVAL Manual de usuario

EKF

EKF CompactPCI CCM-BOOGIE Manual de usuario

EKF

EKF SC3-LARGO Manual de usuario

EKF

EKF CompactPCI SC5-FESTIVAL Manual de usuario

EKF

EKF 82600 Manual de usuario

EKF

EKF PC3-ALLEGRO Manual de usuario

EKF

EKF SC2-PRESTO CompactPCI Manual de usuario

EKF

EKF PC1-62-GROOVE Manual de usuario

EKF

EKF SC1-ALLEGRO Manual de usuario

Manuales populares de Hardware de computadora de otras marcas

EMC2

EMC2 VNX Series Manual del propietario

Panasonic

Panasonic DV0PM20105 Manual de usuario

Mitsubishi Electric

Mitsubishi Electric Q81BD-J61BT11 Manual de usuario

Gigabyte

Gigabyte B660M DS3H AX DDR4 Manual de usuario

Raidon

Raidon iT2300 Manual de usuario

National Instruments

National Instruments PXI-8186 Manual de usuario

Hauppauge

Hauppauge WinTV-HVR-2250 Manual de usuario

Kontron

Kontron CP6002 Manual de usuario

Manhattan

Manhattan 702843 Manual de usuario

Aphex

Aphex 230 Manual de usuario

AMD

AMD Phenom II Manual operacional

Intel

Intel NUC 12 Pro Manual de usuario

dbx

dbx Zone Pro 1260 Manual de usuario

Galaxy

Galaxy GHDX2-2430S-24F4D Manual de usuario

Intel

Intel AXXRMFBU4 Manual de usuario

Kontron

Kontron DIMM-PC/MD Manual de usuario

ST X-NUCLEO-SAFEA1B Instrucciones de funcionamiento

STEINWAY LYNGDORF

STEINWAY LYNGDORF SP-1 Manual de usuario