Edelbrock 5721 Manual de usuario

Brochure #63-5721

Catalog #5721

Rev. 12/07 - AJ/mc Page 1 of 1

EDELBROCK CAT-BACK EXHAUST SYSTEM

For 2007-2008 Toyota FJ Cruiser 2WD & 4WD

Catalog #5721

INSTALLATION INSTRUCTIONS

Please study these instructions carefully before installing your new Edelbrock Cat-Back Exhaust System. If you have any

questions, please contact our Technical Hotline at: 1-800-416-8628 , 7am - 5pm, Monday-Friday, Pacific Standard

Time or e-mail us at [email protected].

Suggested Tools for Installation:

❑3/8" ratchet and metric sockets ❑14mm, 15mm, and 17mm Wrenches

❑Jack and jackstands ❑Liquid penetrant and rubber lubricant

DISASSEMBLY

1. Raise and support vehicle.

2. Remove factory exhaust system from the flange

located behind the catalytic converter.

ASSEMBLY

1. Disconnect the fuel vapor return line from the vapor

canister located just above the rear-end housing. Place

the heat shield sleeve over return line and reconnect it

to the canister. NOTE: Since fuel lines contain harmful

vapors, this procedure should be done in a well

ventilated area clear of any open flames or extreme

heat. Safety glasses should also be worn when

performing this action.

2. Using the supplied 10mm bolts, lock washers, and flat

washers from the kit, install the I-pipe assembly #25-

3285 placing the hangers in the rubber isolators.

3. Using a 2-1/2” band clamp and hanger clamp assembly

#23-4107 from the kit, install muffler #25-55742.

NOTE: Only snug all clamps at this time for adjusment

later.

4. Install overaxle pipe assembly #25-3286.

WARNING!!!

Exhaust gas contains carbon monoxide, a deadly

invisible gas. Correct any leaks before driving!

IMPORTANT NOTE:

Proper installation is the responsibility of the installer. Improper installation will void warranty and may

result in poor performance and engine or vehicle damage.

KIT CONTENTS

Catalog #5716

Qty.Part # Description

❑1 25-3285 I-Pipe Assembly

❑1 25-3286 Overaxle Assembly

❑1 25-3298 Tailpipe Assembly

❑1 25-5582 Tailpipe Tip (Polished)

❑1 22-5721 Installation Kit

❑1 25-55742 Muffler

5. Using a 2-1/2” band clamp, install tailpipe assembly

#25-3298 placing the hanger in the rubber isolator.

6. Using a 2-1/2” band clamp, install tailpipe tip #25-

5582.

7. Working from the front of the system to the rear, adjust,

align, and tighten all the band clamps. Give adequate

clearance for fuel lines, brake lines, electrical wiring,

and the spare tire.

Edelbrock Corporation, 2700 California St., Torrance, CA 90503

Tech Line: (800) 416-8628 Office: (310) 781-2222

E-Mail: [email protected]

Tabla de contenidos

Otros manuales de Pieza de automóvil de Edelbrock

Edelbrock

Edelbrock 68642 Manual de usuario

Edelbrock

Edelbrock 25-4066 Manual de usuario

Edelbrock

Edelbrock 2838 Manual de usuario

Edelbrock

Edelbrock 6567 Manual de usuario

Edelbrock

Edelbrock 66013 Manual de usuario

Edelbrock

Edelbrock 3844 (65mm) Manual de usuario

Edelbrock

Edelbrock 5652 Manual de usuario

Edelbrock

Edelbrock 70024 Manual de usuario

Edelbrock

Edelbrock Chevrolet 5783 Manual de usuario

Edelbrock

Edelbrock THUNDER SERIES AVS 1803 Manual de usuario

Edelbrock

Edelbrock 17934 Manual de usuario

Edelbrock

Edelbrock 5220 Manual de usuario

Edelbrock

Edelbrock 66042 Manual de usuario

Edelbrock

Edelbrock 3627 Manual de usuario

Edelbrock

Edelbrock 5747 Manual de usuario

Edelbrock

Edelbrock 8125 Manual de usuario

Edelbrock

Edelbrock 33503 Manual de usuario

Edelbrock

Edelbrock Chevrolet/GMC Trucks 454 SS Manual de usuario

Edelbrock

Edelbrock 8147 Manual del propietario

Edelbrock

Edelbrock 65272 Manual de usuario

Edelbrock

Edelbrock 71001 Manual de usuario

Edelbrock

Edelbrock 5728 Manual de usuario

Edelbrock

Edelbrock 7129 Manual de usuario

Edelbrock

Edelbrock Torker-Plus 265-400 Manual de usuario

Manuales populares de Pieza de automóvil de otras marcas

Dakota Digital

Dakota Digital 650277 Manual de usuario

bosal

bosal 037031 Manual de usuario

Vintage Air

Vintage Air 571063 Manual de usuario

GFB

GFB EX38 Manual de usuario

bosal

bosal 028091 Manual de usuario

Dodge

Dodge 8W-43 Guía de inicio rápido

ICI

ICI Magnum FBM10DGN Manual de usuario

Volant Perfomance

Volant Perfomance 19435 Manual de usuario

BENDIX

BENDIX GEN 4 GEN 5 ABS Manual de usuario

Vintage Air

Vintage Air 571065 Manual de usuario

Rugged Ridge

Rugged Ridge 11503.13 Manual de usuario

BENDIX

BENDIX CYCLONE DURADRAIN TRAILER WATER Manual de usuario

Porsche

Porsche 968 - ASSEMBLY INSPECTION PROCEDURE AND MAINTENANCE... Guía

Sumitomo

Sumitomo FINE CYCLO FC-A 15 G Manual de usuario

Toshiba

Toshiba 48-1250 A Manual de usuario

aldes

aldes EHT2 Manual de usuario

Go Rhino

Go Rhino 24371T Manual de usuario

BBK

BBK 18950 Manual de usuario