Direct Healthcare Group 56-310 Manual de usuario

Bure Standard/S

Bure Low/S

User Manual

Technical Manual

Service Manual

DIRECTHEALTHCAREGROUP.COM Manual no: 802 rev. 1 210604

SWL: 150 kg/ 330 lbs

56-310

56-310-DIR

56-310-KD

56-310/100

56-310/75

56-310/75-B/0

56-310-B/0

56-310-B/1

56-311-PARSONS-KD

56-311

56-311-KD

56-311-PARSONS-KD

56-311/100

56-311/100-PU

56-311/75

56-311/75-B/0

56-311/75-B/1

56-311/75-PU

56-311/75-RS-KD

56-311-B/1

56-311-BRAKE/1-

RED

56-311-BRAKE/0-PU

56-311-PU

56-311-RED

56-311-RS

56-312

56-312-AUS

56-312-CAN

56-312-CAN-KD

56-312-KD

56-312-TK

56-312-UK

56-312-UK-KD

56-312-US

56-300

56-300/100

56-300/75

56-300/75-DIR

56-300/75-B/0

56-300/75-B/0-PU

56-300/75-B/1-PU

56-300-B/0

56-300-B/1

56-301

56-301-B/0

56-301-B/1

56-301-PU

56-301/100

56-301/100-RS

56-301/75

56-301/75-PU

56-312/100

56-312/100-UK

56-312/100-US

56-312/75

56-312/75-AUS

56-312L-AUS

56-312L-KD-AUS

56-312L-UK

56-312T

56-312T-B/0-PU

56-312T-BRAKE/0

56-312T-B/0-TKN_R

56-312T-PU

56-312T-TK

56-312T-US

56-312T/75

56-312T/75-PLUS-PU

56-312T/75-PU

56-312T/100

56-321

56-321/75

56-321/75-PU

56-321L-AUS

56-321L-UK

56-321-S

56-321-S/100

56-321-S/75

56-321-S/75-PU

56-321-S/75-UK

56-322

56-322/75

56-322-S

56-322-S-B/0

56-322-S/75

56-301/75-RS

56-302

56-302-AUS

56-302-US

56-302-W

56-302T/75-PU-AUS

56-302/100

56-302/100-US

56-302T

56-302T-FKN_R

56-302T/100

56-302T/75

56-302T/75-FKN_R

56-302T/75-PU

56-302T-PU

56-302T-TK

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

Contents

1. Intended Use 03

2. Contraindications, Precautions and Warnings 03

3. Raising/Lowering the Frame - Electric 04

4. Raising/Lowering the Frame - Gas 04

5. Adjusting the Handles 04

6. Left and Right Adjustment of Armrests 04

7. Locking Castors/Unlocking Castors 04

8. Control Box Wiring 05

9. Battery Charging 05

10. LED on Control Box and Battery 05

11. Maintanance 06

12. General Maintenance Advice & Cleaning 07

13. Technical Specifications 07

14. Recycling/Disposal 08

15. Warranty 08

16. Electrical System - Technical Data (T-motion/Linak) 09

17. Remote Control Plus 09

18. Parts List 10

19. Spare Parts 12

20. Accessories 13

21. Table of Symbols 13

Bure Standard

Bure S

Bure Low

Bure Low S

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

1. Intended Use

Walkers are indoor, movable and portable assistive aids, which together with approved accessories are

intended to be used for transfer from sitting to standing positions, and walking training. Walkers are to be used

by persons with reduced muscular strength, who shall be able to stand and perform simple leg movements.

Walkers are to be used for leaning on when walking and standing during early mobilization training. Walkers

and accessories are intended for indoor use only in Home Healthcare environment and Professional Healthcare

facility environment.

2. Contraindications, Precautions and Warnings

Contraindications

• The device may not be used by patients above the maximum weight indicated on the label of the device.

Precautions

• Check that the device is used on a dry and flat surface.

• Check the device is correctly mounted/assembled before its first use.

• Check the device after every folding/disassembly after any transport.

• Check height adjustment and leg spreading motions and inspect the actuators’ or gas pistons’ full ranges.

• Activate the brakes whenever the device is not in use.

• Check the function of the brakes before use.

• Inspect the device regularly to detect any signs of damage. If there are any visible signs of damage,

contact Direct Healthcare Group Customer Service.

• In case of an electrical model of the device, check that the hand control does not show signs of wear

before every use.

• Check that the hand control markings are in accordance with the lifting functions.

• Check the battery status of an electrically operated model, before using the device.

• It is important to never leave the user alone during the transfer.

• Warranty applies only if repairs or alterations are made by personnel who are authorized by Direct

Healthcare Group.

• Ensure that there are no obstacles or people in the way of the device, when moving.

• Handle batteries with care. Do not drop.

• Use only batteries and cables that are intended for the device as instructed by the manufacturer.

• Verify that potential accessories that might be used are properly attached to the device before use.

• Low speed is recommended when moving with the device.

• Take care not to drive the device over thresholds with high speed or force. Approach the threshold with

lower speed and communicate the coming threshold to the user.

• Keep the instructions for use together with the product so that it can be used as a reference if necessary.

Warnings

• The caregiver must be able to read and understand the Manual/IFU of the product.

• It is important to only use approved accessories as stated in the manual/IFU to prevent unintended

detachment of components and subsequently a fall that may lead to patient injury.

• Use careful and gentle maneuvers when moving the device.

• Perform maintenance/service of the device, according to the instructions in the manual/IFU, at least once

every 12 months.

• Accessories must be properly attached. They should be tested in relation to the user’s needs and

functional ability.

• Special care must be taken when using strong electrical power sources such as diathermy and the like

so that diathermy cables are not placed on or near the device. In case of doubt consult with a Direct

Healthcare Group representative.

• When lifting the device, only use the denoted handholds. At least two people are required for lifting the

device

• Do not leave a user or patient unattended when the device is being used.

• Never move the lift by pulling on the actuator or gas piston.

• The device must not be lowered into water.

• The device must not be left or stored in a damp or humid environment.

• The device must not be cleaned using steam.

• The device must not be charged in a wet room.

• The device must not be used outdoors, only indoors.

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

3. Raising/Lowering the Frame - Electric

Adjust the height with the aid of the remote control <UP> and <DOWN> arrows.

4. Raising/Lowering the Frame - Gas

Release the gas strut by moving the handle upward (the gas strut will raise the

Walker). Let go of the handle at the desired height (the gas strut a locked).

Release the gas strut by moving the handle upward. Use your body weight to

press the frame down. Let go of the handle at the desired height (the gas strut

will lock).

5. Adjusting the Handles

To adjust handles to the desired position; loosen screw, adjust handle, tighten

screw.

6. Left and Right Adjustment of Armrests

The handles are adjusted to the desired position by: Loosening the knob of the

handles adjustable locks.

7. Locking Castors/Unlocking Castors

Bure Double is fitted with braked casters with directional locking (green pedal).

Depress the foot brake to set it and lock the castor. To unlock, press down on the

protruding part of the brake. Locking affects rolling and swiveling.

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

Linak:

1. Battery terminal socket

2. Plug socket

(NOTE: Plugs must always be connected to the control box for IP classification to

be valid.)

3. Remote control socket

4. Socket for the raise/lower actuatork

9. Battery Charging

• Connect plug to 230V wall socket. Charging begins automatically and the

battery LED flashes green.

• Make sure the battery is fully charged before using for the first time. It takes

around 25 h to fully charge the battery.

• We recommend that the battery plug be removed from the control box if the

product will be out of use for an extended period (more than one week) or if

the battery is switched off by means of the ON/OFF switch. This eliminates

the risk of disabling the battery as the control box always uses a small

quantity of electricity even when the Walker is not in use.

10. LED on Control Box and Battery

Control box – green light when power is available from battery/mains socket.

Battery:

• The LED flashes green during charging.

• ON/OFF: To use the product, press ON.

• The green lamp will begin to flash.

• Use the OFF button (hold down for 5 s) to switch off the battery if the product

will not be used for an extended period.

• The LED will shows a constant green light when the battery is fully charged.

• When the battery is in normal state/in operation, the LED lashes green at

REGULAR intervals, namely 0.5 s ON, 4 s OFF.

• When the battery requires charging (remaining charge <25%) the LED will

flash orange/red at REGULAR intervals, namely 0.5 s ON, 4 s OFF.

NOTE: The battery has an in-built device that automatically switches it off when

remaining charge is <20%. The LED is then extinguished. The battery must now

be fully charged before the electronics can be used again.

8. Control Box Wiring

Remove the control box cover to make the connections as described below. Use

a screwdriver or similar; refer to the special labels on the control box.

T-motion:

NOTE: Make sure plugs are connected to the correct

sockets otherwise the actuators can be damaged.

1. Socket for the height adjustment actuator.

2. Socket for the width adjustment actuator.

3. Remote control socket.

4. Battery terminal socket.

5. Plug socket (NOTE: Plugs must ALWAYS be connected to the control box for

IP classification to be valid).

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

11. Maintenance

Recommended at least once per year

Check that Action

General

The Walker feels firm/free from play.

The Walker does not rattle during manoeuvres.

The Walker is level and all of its castors are in contact with the

floor.

The Walker is not dirty

Clean with lukewarm soap solution or alcohol-based cleaning

agent (no petroleum products).

Armrest

Armrests are intact and clean.

Armrest widening is functional.

Clean; replace if damaged.

Fit lock screws/plates as required

Handle

Grips are not damaged/dirty.

Handle adjustment is functional.

Clean with lukewarm soap solution (no petroleum products).

Replace handle grips.

Fit lock screws/plates as required

Battery

Check that the charging cable is connected to the control box.

Check that the remote control is connected to the control box.

Check that connections are made according to the wiring

diagram.

Check that the battery, actuators and control box are not loose.

Fit new charging cable; this must always be connected to the

control box (IP65 protection).

Connect or fit new remote control as required.

Refer to the wiring diagram in the Technical manual.

Tighten; replace with new fasteners as required.

Height adjustment

Raising and lowering are functional.

The Walker feels stable at maximum settings.

There is no play between the vertical frame and bottom frame.

Height adjustment clamps lock.

The electric actuator fitting must be free from play.

Height adjustment via remote control is

functional. The electric actuator must run

smoothly at a constant speed.

Fit new guide sleeves (in frame) or end plugs (in chrome tubes) as

required.

Tighten all lock bolts.

Replace clamps.

Tighten the attachment fitting concerned; replace bolts/lock nuts

as necessary.

Check that the battery/remote control/ actuator are connected in

accordance with the wiring diagram. Charge the battery. Contact

customer services.

Frame parts

There is no mechanical damage.

There are no scratches.

End plugs/lower frame fitted

If damage is present, contact GATE’s customer services.

Touch up as necessary.

Fit new end plugs

Castors/brakes

Castors roll easily/tread not damaged.

The castors are firmly fastened to the lower frame.

Castor brakes functional on all castors.

Handbrake functional.

Clean or replace castors. NOTE: Castors are always fixed to the

lower frame with thread locker or lock

nuts. Do not dismantle the castors; replace the whole castor

assembly instead.

Tighten the castor bolt and fit locking nut or use thread locker

(depends on model).

Replace castor assembly.

Adjust the brake or fit new castors.

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

12. General Maintenance Advice & Cleaning

• Clean the Walker and its armrests clean as necessary - Wipe using a soap solution/surface disinfectant.

• The product may be cleaned in a tunnel washer or similar as electrical systems have IP65 protection.

However, the product is not corrosion proof which means washing by machine may reduce its lifetime.

• If the product is to be cleaned in a washing tunnel / washing cabin, use PU-cushions.

• Replace damaged parts immediately; must be done by experienced personnel.

• The product is only intended for indoor use.

13. Technical Specifications

Dimensions apply to Walkers with 125 mm castors.

Part No. Product Product

width

Max user

weight

Length Height Armrest/

internal

dimension

56-311 Standard GAS 78cm 150kg 80cm 90-129cmc 25-50cm

56-301 S GAS 66cm 150kg 79cm 90-129cm 30-45cm

56-322 Low GAS 78cm 150kg 80cm 75-95cm 25-50cm

56-322-S Low S GAS 66cm 150kg 79cm 75-95cm 30-45cm

56-312T Standard EL 78cm 150kg 80cm 90-130cm 25-50cm

56-302T S EL 66cm 150kg 79cm 90-130cm 30-45cm

56-321 Low EL 78cm 150kg 80cm 75-100cm 25-50cm

56-321-S Low S EL 66cm 150kg 79cm 75-100cm 30-45cm

Product weight:

Manual 15 kg, Gas 15 kg, Electric 21 kg

”LIFT” denotes suitable handhold for lifting the Walker.

NOTE: At least two people are required for lifting.

14. Recycling/Disposal

When the product is no longer usable it should be recycled in accordance with legislation and regulations

in the country concerned. All electrical parts including batteries must be removed and recycled as electrical

components. (Ask your local recycling station for further information about how the different materials in the

product (metals, plastics, electronics) should be recycled).

15. Warranty

We provide two years’ warranty for manufacturing faults (does not apply to wear parts).

For further information or enquiries please contact:

Direct Healthcare Group Sverige AB

Torshamnsgatan 35,

SE-164 40 Kista, Sweden

Tel: +46 (0)8-557 62 200

info.se@directhealthcaregroup.com

www.directhealthcaregroup.com

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

2a 2b

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

16. Electrical System - Technical Data (T-motion/Linak)

Actuator Lift Widening Lift Widening

Producer TiMotion TiMotion Linak Linak

Voltage 12V 24V 24 V 24 V

Push 2000N/1500N 1000N 1000N/1500N/2000N 1200 N

Pull 2000N/1500N 1000N 1000N/1500N/2000N 1200 N

Self-locking push 1000N 1000N 7A 3 A

Current 6.6 (+/-1,0)A 2.6 (+/-0,4)A 7A ut/7 A in 3A ut/3 A in

Colour Black Aluminium White White

Stroke 400mm 55mm 400 mm 55 mm

Mounting dim 605mm 167mm 606+/-2 mm 165 +/- 2 mm

Encapsulation IP66 IP66 IPX6 IPX6

IEC60601-1 3rd revision

Control box + Battery

Producer T-Motion Linak

Voltage 24V 230V/24V

Capacity 2.0AH 2,25 Ah

Encapsulation IP66 IPX6

Colour Black White

Electrical safety Class II Class II (Dubbel insulated)

IEC60601-1 3rd revision

17. Remote Control Plus

**1. Service indicator – flashes red after 11 months’ operation.

Constant light (red) after 12 months’ operation. The indicator is a reminder to review the maintenance

instruction (see Instructions for Use/Technical Manual. This should be done at least once every 12 months.

Reset: hold down buttons <2a> + <2b> for at least 30 seconds.

**The indicator will go out around 30 seconds after the remote control is

activated (battery conservation function).

BURE STANDARD/S/LOW/LOW S

DIRECTHEALTHCAREGROUP.COM

18. Parts List

Armrest

Knob

Plastic washer

Washer, black

Protective cover

Bolts

Handle & grip

Clamp

Knob

Wheel frame

End bushing

Wheel

Bolt

Washer

Nut

Serrated washer

3Upper frame 8Locking handle,

height adjustment

Chromium-plated tube

Attachment bolt (2 pcs)

Serrated washer

End bushing

Gas strut

Handle

Arm/housing

Bolt, washer (2 pcs), nut

(attachment at bottom and top)

Frame

Sleeve guide

10 A

Battery shelf & attachment bolts

Battery & nut/ bolt (for

attachment to battery shelf)

Control box (Linak/TiMotion)

Remote control (Linak/TiMotion)

Actuator (Linak/TiMotion)

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Ayuda a la movilidad de Direct Healthcare Group

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic WalkingBelt 6041 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic HygieneLBSling Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic ThoraxSling Manual de usuario

Direct Healthcare Group

Direct Healthcare Group Bure XL Manual de usuario

Direct Healthcare Group

Direct Healthcare Group Bure Rise & Go Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic EasyGlide 5050 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic BasicSling Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic ReTurn7600 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic HighBackSling Manual de usuario

Direct Healthcare Group

Direct Healthcare Group Bure XL Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic FootStool 8090 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic MiniLift160EE Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic ReTurnBelt Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic Rowalker400 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic Rowalker400 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic Bure Rise and Go DB Manual de usuario

Direct Healthcare Group

Direct Healthcare Group SystemRoMedic ReturnBelt 6031 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group GATE Bure Double 2.0 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group Bure Rise & Go DB Manual de usuario

Direct Healthcare Group

Direct Healthcare Group GATE Bure Double 2.0 Manual de usuario

Direct Healthcare Group

Direct Healthcare Group GATE Bure Ortho Manual de usuario

Direct Healthcare Group

Direct Healthcare Group Bure Ortho Manual de usuario

Direct Healthcare Group

Direct Healthcare Group kirton Florien Elite Manual de usuario

Direct Healthcare Group

Direct Healthcare Group GATE Bure Double 2.0 Manual de usuario

Manuales populares de Ayuda a la movilidad de otras marcas

Alber

Alber Scalamobil iQ Manual de usuario

Ferno

Ferno CCT-PX Manual de usuario

HEPRO

HEPRO Gripo Manual de usuario

Otto Bock

Otto Bock Pheon 3R62 Manual de usuario

NRS Healthcare

NRS Healthcare M11090 Manual de usuario

Medline

Medline MDS86835DSHEC Guía de instalación

Guldmann

Guldmann Twin Turner II Manual de usuario

Drive

Drive ROOMBA Manual de usuario

Gate

Gate Balder Manual de usuario

Decon wheel

Decon wheel TNS Notos Manual de usuario

ExoAtlet

ExoAtlet ExoAtlet-II Manual de usuario

Invacare

Invacare Storm Series Manual de instrucciones

Rhythm Healthcare

Rhythm Healthcare B3800F Manual de usuario

AMF-BRUNS

AMF-BRUNS PROTEKTOR Manual de usuario

Drive DeVilbiss Healthcare

Drive DeVilbiss Healthcare OTTER Manual de usuario

Rhythm Healthcare

Rhythm Healthcare C500U Manual de usuario

Lumex

Lumex RJ4200A Manual de usuario

Rebotec

Rebotec Jumbo Manual de usuario