DentalEZ RAMVAC Utility Manual de usuario

Master Control Panel

User Manual

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Table of Contents

Section I Introduction

Main Control Box.................................................................................................................... 2

Relay Box Connection (Single/Dual Vacuum Pump)........................................................... 3

Vacuum Pump Relay Box Wiring Schematic .......................................................................4

Master Water Control Valve Connection.............................................................................. 5

Air Compressor Remote Connections................................................................................. 6

Rocker Switch Installation....................................................................................................6

Section II Wiring Schematics

MP - 100 / 300 ........................................................................................................................ 7

MP - 400 ................................................................................................................................8

MP - 700 ................................................................................................................................9

MP - 900 ...............................................................................................................................10

MP - 1000................................................................................................................................11

MP - 1100................................................................................................................................12

MP - 2000 ..............................................................................................................................13

MP - 2200 ..............................................................................................................................14

Limited Warranty ...............................................................................................................15

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Master Control Panel User Manual

Section I Installation

All wiring between the main control box and equipment

should be Class B, low-voltage. In most cases, a conduit

is not required when using this type of wiring.

NOTICE

Before proceeding with any electrical installation,

comply with and maintain all applicable local electrical

codes(s) and regulations.

WARNING

Main Control Box

1. Position the main control mounting box so

that the master control panel switches are

easily visible and in a convenient location

(near the oice entrance/exit).

2. Once the main control mounting box is in posi-

tion, secure it using the brackets provided.

NOTE: To ensure proper installation of the nished

master control panel, the mud ange must be

recessed by dray wall thickness.

3. Install the main control box wires as follows:

a. Using a hammer and pliers, remove the

appropriate knock-out from the main

control mounting box.

b. Fit a nylon grommet in the knock-out.

(This protects the wires from chaing and

shorting out.)

c. Run the appropriate wires to their respec-

tive equipment location, then connect the

wires according to the instructions on the

following pages.

4. After all wiring connections are completed

correctly, position and secure the master

control panel to the main control box using

the screws provided.

Wiring Chart

Model No. No. of Wires Wire Under 500 Ft. Wire Over 500 Ft.

CV-101 3 18 AWG 16 AWG

CV-102 3 18 AWG 16 AWG

MC-201 6 18 AWG 16 AWG

MC-202 6 18 AWG 16 AWG

Air Compressor 3 18 AWG 16 AWG

MWCV Solenoid Valve 2 18 AWG 16 AWG

MWCV Transformer 2 18 AWG 16 AWG

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Section I Installation

All pumps ( single or dual) must have three, low-voltage

wires installed from the top of each relay box going to

the main control box in order to operate the master

control panel lighted ON / OFF switches.

NOTICE

Before proceeding with the single / dual vacuum pump

relay box connection, make sure the electrical power

supply to the vacuum pump is turned OFF.

WARNING

Relay Box Connection

Single/Dual Vacuum Pump

(All Panes, Except Turbine)

Before making any wiring connections to the main control

box, the vacuum unit should be completely installed.

CAUTION

NOTE: For dual vacuum pump relay box to the

main control box connection, Steps 1 through 8

listed below must be performed for each vacuum

pump. Refer to the vacuum pump relay box wiring

schematic on the next page.

NOTE: For vacuum pump relay boxes with factory

installed yellow, black and brown wires, it is not

necessary to perform Steps 1 through 8 below.

1. Loosen the top and bottom retainer screws

from the vacuum pump relay box and remove

the cover.

2. Remove the black strain relief grommet from

the top of the vacuum pump relay box.

3. Place the tap connector slot over the yellow

transformer wire, and insert the brown wire

into the end of the tap connector.

4. Squeeze the metal connector tight, and snap

the attached cover in place.

5. Route the brown wire out through the strain

relief grommet hole along with the yellow and

black wires.

6. Reinstall the strain relief grommet around the

yellow, black and brown wires.

7. Reinstall the relay box cover and tighten the

top and bottom retainer screws.

8. Run and connect the low-voltage wires to the

main control panel mounting box according to

the applicable wiring schematic in Section II,

Wiring Schematics.

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Master Control Panel User Manual

Section I Installation

Vacuum Pump Relay Box Wiring Schematic

WHITE BLUE

BROWN

BLACK

YELLOW

RED

BLUE

PURPLE

BLACK

BROWN LIGHT BLUE

GREEN

& YELLOW

BROWN

& WHITE

BROWN

BLACK

GREEN

& YELLOW

0123456

PN: 64529265_E

October, 2017

MOTOR

L2/N

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Section I Installation

(With 24-Volt Lighted Control Switch)

Master Water Control Valve Connection

To prevent any chance of electrical shock, always

disconnect power when indicated.

WARNING

When using low voltage to operate the master water

control valve (MWCV), a 115-volt electrical receptacle for

the MWCV "plug-in" transformer must be supplied.

NOTICE

1. Make sure all power is properly disconnected.

2. Remove the MWCV from the shipping contain-

er or locate a previously installed MWCV in the

oice.

3. Dismantle the coil assembly.

4. Replace the 115-volt coil with the 24-volt coil

included in the kit.

5. Connect the two low-voltage wires from the

transformer according to the applicable master

control panel wiring schematic in Section II.

Do not plug in the transformer until all electrical

connections are complete.

WARNING

6. Test the MWCV and transformer as follows:

a. Turn the light switch to the OFF position.

(The light should be o.)

b. Turn the light switch to the ON position.

(The light should be on.)

c. When the switch is activated, the MWCV

should make a clicking sound, which indi-

cates the valve is working properly.

d. If the light fails to come on, or if the MWCV

fails to function, check all connections

referring to the applicable master control

panel wiring schematic in Section II.

NOTE: If a light stays ON while the switch is

in the OFF position, simply reverse the wires

numbered 2 and 3 on the switch. The light

should then operate correctly.

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Master Control Panel User Manual

Section I Installation

Rocker Switch Installation

Air Compressor Remote Connection

To prevent any chance of electrical shock, always

disconnect power when indicated.

WARNING

Disconnect power to the air compressor.

2. Mount the compressor relay box near the

junction box on the air compressor.

3. Connect the power source supply lines to L1

and L2 on the compressor relay box for new

installation.

NOTE:

For existing installation, rst remove

the power source supply lines from the

junction box.

4. Connect conduit from the compressor relay

box to the junction box.

5. Connect the two lines from T1 and T2 to the

two compressor power lines in the junction

box.

6. Run and connect low-voltage wires to the

main control box according to the applicable

master control panel wiring schematic in

Section II.

When connecting a pump, replace the VAC switch

in the master control panel with the loose switch

supplied.

Refer to the schematic on the right for rocker

switch installation in the following panels:

PANEL PART #

MP - 300 64652017

MP - 1000 64568077

MP - 2000 64568110

MP - 2200 64568111

MP - 1000A 64568171

MP - 2000A 64568174

MP - 2200A 64568175

Connect to an S1 Electrols as follows:

Terminal #4 - connect to S1 terminal "G"

Terminal #3 - connect to S1 terminal "H"

Terminal #2 - connect to S1 terminal "F"

GHF

S1 Electrols Terminals

VAC Switch

S1 Electrols Terminals

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Section II Wiring Schematics

One Switch, Single Vacuum

MP - 100 / 300

Wall-Mounted Switches

Shown from

Back of Switch Plate Vacuum

Junction Box

Line Voltage

(To Source)

Load

(To Vacuum Pump)

Vacuum Pump

Relay Box

Brown

Yellow

Black

L2 T2

L1 T1

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Master Control Panel User Manual

MP - 400

Section II Wiring Schematics

Two Switch, Dual Vacuum

Wall-Mounted

Switches

Shown from

Back of

Switch Plate

Vacuum 1

Junction Box

Vacuum

Pump

Relay

Box

Brown

Yellow

Black

ON/OFF Switches

Mounted on Dual Cabinet

Vacuum 2

Brown

Yellow

Black

Line Voltage

(To Source)

Load

(To Vacuum

Pump)

L2 T2

Vacuum

Pump

Relay

Box

Line Voltage

(To Source)

Load

(To Vacuum

Pump)

L2 T2

OFF

L1 T1

Vacuum Unit Panel Mounted Switches

(Same Connection as Back View)

OFF

Vacuum Pump

Relay Box

Black

Yellow

Brown ON

OFF

Black

Yellow

Brown NOTE:

Using the circuit depicted in the dia-

gram above, either switch will turn the vac-

uum pumps on. To wire pumps so that either

switch will turn the vacuum pumps o, use

the circuit shown in the diagram to the left.

www.DentalEZ.com 866-DTE-INFO (opt 4)

www.DentalEZ.com

Section II Wiring Schematics

One Switch, Air Compressor

MP - 700

Wall-Mounted Switches

Shown from

Back of Switch Plate Air Compressor

Junction Box

Line Voltage

(To Source)

Load

(To Air Compressor)

Compressor

Relay Box

Brown

Yellow

Black

L2 T2 Black

Red

L1 T1

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Equipo dental de DentalEZ

DentalEZ

DentalEZ Heritage CORE Chair Manual de usuario

DentalEZ

DentalEZ StarDental Titan 3 Five Star Manual de usuario

DentalEZ

DentalEZ Aeras Star 500 Elite Handpice Manual de usuario

DentalEZ

DentalEZ aXcs Operatory Light Manual de usuario

DentalEZ

DentalEZ AERAS Star Manual de usuario

DentalEZ

DentalEZ aXcs Basic-Duo Manual de usuario

DentalEZ

DentalEZ aXcs Magellan Manual de usuario

DentalEZ

DentalEZ StarDental Titan 3 257506 Manual de usuario

DentalEZ

DentalEZ StarDental Blis-sonic K Manual de usuario

DentalEZ

DentalEZ StarDental PROPHY STAR 3 Manual de usuario

DentalEZ

DentalEZ Star Titan Low-Speed Manual de usuario

DentalEZ

DentalEZ Heritage CORE Delivery Unit Manual de usuario

DentalEZ

DentalEZ everLight EVLCE Manual de usuario

DentalEZ

DentalEZ Star TITAN 3 5K MOTOR Manual de usuario

DentalEZ

DentalEZ Aeras Ramvac C3 Manual de usuario

DentalEZ

DentalEZ Star Manual de usuario

DentalEZ

DentalEZ Aeras 400 Flex Manual de usuario

DentalEZ

DentalEZ Heritage Simplicity LED Light Manual de usuario

DentalEZ

DentalEZ Forest Manual de usuario

DentalEZ

DentalEZ Aeras Ramvac RV4-12 Manual de usuario

DentalEZ

DentalEZ Star TITAN 3 Manual de usuario

DentalEZ

DentalEZ Forest Manual de usuario

DentalEZ

DentalEZ TruSim Manual de usuario

DentalEZ

DentalEZ Star Manual de usuario

Manuales populares de Equipo dental de otras marcas

Vatech

Vatech EzRay Air VEX-P300 Manual de usuario

KaVo

KaVo GENTLEpower LUX Contra-angle 25 LP Manual de usuario

DENTSPLY

DENTSPLY SmartLite Focus Manual de usuario

LM ProPower CombiLED Manual de usuario

Owandy Radiology

Owandy Radiology RX-AC Manual de usuario

mectron

mectron Piezosurgery Manual de usuario

Belmont

Belmont CREDIA G1 Manual de usuario

Planmeca

Planmeca Sovereign Classic Manual de usuario

Bego

Bego Fornax T Manual de usuario

Renfert

Renfert SYMPRO Guía rápida

Ateco

Ateco AT-301 Manual de usuario

Nevadent

Nevadent NZPS 3 A1 Manual de usuario

Muss Dental

Muss Dental MA 50 Manual técnico

Diplomat

Diplomat Comfort Series Manual de usuario

Dentatus

Dentatus Nyström Manual de usuario

OMS

OMS DUKE EASY Manual

OMS

OMS LINEA PATAVIUM Manual

BRYANT DENTAL

BRYANT DENTAL Ignis Gesture A-494322 Manual de usuario