Delta RT Series Manual de usuario
Delta UPS - Amplon Family
The power behind competitiveness
www.deltapowersolutions.com
User Manual
RT Series, Single Phase
5/ 6/ 8/ 10kVA
RT Series, Three Phase
10/ 11/ 15/ 17/ 20kVA
Lithium-ion Battery Pack
AmplonRTseries 2
SAVE THIS MANUAL
Copyright © 2020 by Delta Electronics Inc. All Rights Reserved. All rights of this User Manual
(“Manual”), including but not limited to the contents, information, and figures are solely owned and
reserved by Delta Electronics Inc. (“Delta”). The Manual can only be applied to the operation or the
use of this product. Any disposition, duplication, dissemination, reproduction, modification,
translation, extraction, or usage of this Manual in whole or in part is prohibited without the prior
written permission of Delta. Given that Delta will continuously improve and develop the product,
changes may be made to the information in this Manual at any time without obligation to notify any
person of such revision or changes. Delta will make all possible efforts to secure the accuracy and
the integrity of this Manual. Delta disclaims any kinds or forms of warranty, guarantee, or
undertaking, either expressly or implicitly, including but not limited to the completeness,
faultlessness, accuracy, non-infringement, merchantability or fitness for a particular purpose of the
manual.
This manual contains important instructions and warnings that you should follow during the
installation, operation, storage and maintenance of this product. Failure to heed these
instructions and warnings will void the warranty.
3
Table of Contents
Chapter 1 : Product Introduction................................................................................................. 4
Chapter 2 : Important Safety Instructions ................................................................................... 6
2.1 Safety Instructions ....................................................................................................6
2.2 Standard Compliance ...............................................................................................7
2.3 Storage......................................................................................................................8
2.4 Recycling and Disposal.............................................................................................8
Chapter 3 : Package List ............................................................................................................ 9
Chapter 4 : Rear Panel ..............................................................................................................11
Chapter 5 : Installation Procedures .......................................................................................... 13
5.1 Rack Mounting ........................................................................................................13
5.2 Tower Mounting ......................................................................................................14
Chapter 6 : Connection............................................................................................................. 18
6.1 Connecting the Delta Lithium-ion Battery Pack (Model: RT-20K-LIB)
to its corresponding UPS ........................................................................................18
6.2 Connecting the Delta Lithium-ion Battery Pack (Model: RT-10K-LIB)
to its corresponding UPS ........................................................................................20
Chapter 7 : Battery Module Installation & Replacement........................................................... 21
Chapter 8 : Operation Procedures............................................................................................ 24
Chapter 9 : Maintenance .......................................................................................................... 25
Appendix 1 : Technical Specifications....................................................................................... 26
Appendix 2 : Warranty .............................................................................................................. 28
AmplonRTseries 4
Chapter 1 : Product Introduction
The Delta lithium-ion battery pack (hereafter referred to as ‘battery pack’) provides
DC power and maintains inverter’s operation of transferring DC-to-AC power to
supply stable power to the critical loads connected to the UPS when the main AC
source is abnormal. It must be operated in conjunction with a corresponding Delta
Amplon RT series UPS as shown in the table below. For its appearance and block
diagrams, please refer to the following figures.
Delta Lithium-ion
Battery Pack Model
Applicable to Delta
Amplon RT Series UPS Model
RT-20K-LIB RT-11K3P-LV, RT-15K3P,
RT-17K3P, RT-20K3P
RT-10K-LIB RT-5K1P, RT-6K1P, RT-8K1P,
RT-10K1P, RT-10K3P
(Figure 1-1: Front View of the Delta Lithium-ion Battery Pack)
(Figure 1-2: Block Diagram of RT-20K-LIB)
5
BM1
BM2
+
+
-
-
Breaker Connector
BMS
(Figure 1-3: Block Diagram of RT-10K-LIB)
AmplonRTseries 6
Chapter 2 : Important Safety Instructions
2.1 Safety Instructions
• Servicing of batteries and battery packs must be performed or supervised by
qualified service personnel knowledgeable in the batteries, battery packs
and the required precautions. Keep unauthorized personnel away from the
batteries and battery packs.
• A battery can present a risk of electric shock and high short-circuit current.
• To reduce the risk of fire or electric shock, install the battery pack in a
temperature and humidity controlled indoor area free of conductive
contaminants.
• Forbid opening or removing the cover of the battery pack to avoid high
voltage electric shock.
• The risk of dangerous high voltage is possible when the batteries are still
connected to the UPS even though the UPS is disconnected from the mains.
Do not forget to disconnect the battery cable to completely cut off the battery
source.
• Only qualified service personnel can perform battery replacement. Before
battery replacement, please turn off the battery breaker. If replacing the
batteries without turning off the UPS, please make sure the UPS has
detected “Battery Disconnected” before turning on the battery breaker.
• Only use the same type of batteries from the same supplier. Never use old,
new and different Ah batteries at the same time.
• Do not reverse or short circuit the polarity + and – when connecting the
batteries because this will destroy the device and constitute a risk of electric
shock or fire.
• The external slits and openings in the battery pack are provided for
ventilation.
• To ensure reliable operation of the battery pack and to protect the battery
pack from overheating, these slits and openings must not be blocked or
covered. Do not insert any object into the slits and openings that may hinder
ventilation.
7
• Do not pour or splash any liquid on the battery pack.
• Do not insert any object into the battery pack.
• Do not place beverages or any liquid-containing vessels on or near the
battery pack.
• Do not dispose of the battery or batteries in a fire. The batteries may
explode.
• Do not open or mutilate the battery or batteries. The released electrolyte is
harmful to the skin and eyes and may be toxic.
• Observe the following before battery replacement:
1. Remove watches, rings, or other metal objects.
2. Use tools with insulated handles.
3. Wear rubber gloves and boots.
4. Do not lay tools or metal parts on the top of batteries.
5. Disconnect charging source prior to connecting or disconnecting battery
terminals.
•
The two symbols shown above indicate that there is high voltage circuit. Do
not open the cover(s) of the Delta lithium-ion battery pack.
• The operating temperature of the Delta lithium-ion battery pack is 0°C ~
45°C (32°F ~ 113°F).
2.2 Standard Compliance
• CE
• CAN/ UL1973
AmplonRTseries 8
2.3 Storage
• Prior to installation
If the Delta lithium-ion battery pack needs to be stored prior to installation, it
should be placed in a dry area. The allowable storage temperature and
relative humidity (non-condensing) are -15°C ~ +50°C (5°F ~ 122°F) and 5%
~ 95% respectively.
• After usage
Remove all connected devices from the Delta lithium-ion battery pack, and
store it in a dry and well-ventilated area at a temperature between -15°C and
+50°C (5°F ~ 122°F) and at a relative humidity (non-condensing) between
5% ~ 95%.
2.4 Recycling and Disposal
• Please follow the local government’s laws to handle and dispose of the
Delta lithium-ion battery pack.
9
Chapter 3 : Package List
The package contains the following items. Please check if any item is missing. If
there is anything missing, please contact the dealer immediately.
Model: RT-20K-LIB
No. Item Q’ty
1 Delta Lithium-ion Battery Pack 1 PC
2 User Manual 1 PC
3 RS-485 Cable 1 PC
4 Ear Bracket Kit 1 SET
5 Rear Panel for UPS 1 PC
6 Tower Stand Extender 4 PCS
7 Battery Cable 1 PC
AmplonRTseries 10
Model: RT-10K-LIB
No. Item Q’ty
1 Delta Lithium-ion Battery Pack 1 PC
2 User Manual 1 PC
3 RS-485 Cable 1 PC
4 Ear Bracket Kit 1 SET
5 Tower Stand Extender 4 PCS
6 Battery Cable 1 PC
7Grounding kit 1 SET
NOTE:
1. If there is any damage or anything missing, please immediately contact
the dealer from whom you purchased the unit.
2. If the battery pack needs to be returned, carefully repack the battery
pack and all of the accessories using the original packing materials that
came with the unit.
Otros manuales para RT Series
1
Este manual sirve para los siguientes modelos
2
Tabla de contenidos
Otros manuales de Paquete de baterías de Delta
Manuales populares de Paquete de baterías de otras marcas
IOGear
IOGear GBP24V Series Manual de usuario
Inventus Power
Inventus Power PROTRXion S-12V100-TRX-HD Manual de usuario
Clas Ohlson
Clas Ohlson PW-290A Manual de usuario
EINHELL
EINHELL MULTI-Ah Power X-Change Plus Manual de usuario
Samsung
Samsung EB-U3300 Manual de usuario
ECTIVE
ECTIVE LC Series Manual de usuario