Dell EMC Edge Gateway 3200 Manual de usuario

Dell EMC Edge Gateway 3200

Service Manual

Regulatory Model: EGW-3200

Regulatory Type: EGW-3200-NA

August 2022

Rev. A00

Notes, cautions, and warnings

NOTE: A NOTE indicates important information that helps you make better use of your product.

CAUTION: A CAUTION indicates either potential damage to hardware or loss of data and tells you how to avoid

the problem.

WARNING: A WARNING indicates a potential for property damage, personal injury, or death.

subsidiaries. Other trademarks may be trademarks of their respective owners.

Preface......................................................................................................................................... 4

Part I: Installation procedure for 4G and 5G LTE modules..............................................................5

Part II: Installation procedure for 2x RS-422/485 uFM module.................................................... 23

Part III: Installation procedure for 2x RS-232 uFM module...........................................................35

Part IV: Installation procedure for 2x GbE with PoE out...............................................................47

Part V: Installation procedure for 2x GbE LAN............................................................................. 62

Part VI: Installation procedure for 2x Canbus uFM module...........................................................76

Part VII: Installation procedure for 8x DI/O uFM module............................................................. 90

Contents

Contents 3

Table 1. Expansion modules overview

Module Interface details Reference link

M.2

WiFi Intel WiFi AX210 M.2 2230 https://www.intel.com/content/www/us/en/products/docs/

wireless/wi-fi-6e-ax210-module-brief.html

4G Sierra EM7565 M.2 3042 https://www.sierrawireless.com/iot-solutions/products/em7565/

5G Thales MV31-W M.2 3042 https://www.thalesgroup.com/en/markets/digital-identity-and-

security/iot/iot-connectivity/products/iot-products/mv31-w-ultra-

high

mPCIe

Isolated RS-422

and RS-485

EMP2-X4S2 https://www.innodisk.com/en/products/embedded-peripheral/

communication/emp2-x4s2

Isolated RS-232 EMP2-X2S1 https://www.innodisk.com/en/products/embedded-peripheral/

communication/emp2-x2s1

Isolated GbE

with PoE out

EMPL-G2P1 https://www.innodisk.com/en/products/embedded-peripheral/

communication/empl-g2p1

Isolated GbE

LAN

EMPL-G202 https://www.innodisk.com/en/products/embedded-peripheral/

communication/empl-g202

Isolated Canbus EMUC-B202 https://www.innodisk.com/en/products/embedded-peripheral/

communication/emuc-b202

I2C

Isolated DI/O Internal I2C wafer N/A

Preface

4 Preface

Installation procedure for 4G and 5G LTE

modules

About this task

Installation of the 4G/5G expansion module requires an additional heat sink to ensure performance.

Use the paddle-style antennas that are included with the expansion kit. The following figure shows the dimensions of the

antenna.

42.0±0.3

184.0±1.0

38.5±0.5

210.0±1.0

13.0±0.3

13.0 ±0.3

Figure 1. 4G/5G/LTE antenna (dimensions in mm)

Table 2. Expansion module packing list - 4G

Item Quantity Notes

Screw M2.5 x 6L 2 Torque required: 3.5 kgf.cm

Screw M3 x 4L 1 Torque required: 3.5 kgf.cm

Screw M2.5 x 2.5L 1 Torque required: 3.5 kgf.cm

Standoff M2.5 H3.2 1 Torque required: 4.5 kgf.cm

Bracket 1 -

4G M.2 1 -

SMA cable 3 -

Antenna 2 -

Installation procedure for 4G and 5G LTE modules 5

Table 2. Expansion module packing list - 4G (continued)

Item Quantity Notes

4G label 1 -

4G heat sink 1 -

Thermal pad 1 -

Table 3. Expansion module packing list - 5G

Item Quantity Notes

Screw M2.5 x 6L 2 Torque required: 3.5 kgf.cm

Screw M3 x 4L 1 Torque required: 3.5 kgf.cm

Screw M2.5 x 2.5L 1 Torque required: 3.5 kgf.cm

Standoff M2.5 H3.2 1 Torque required: 4.5 kgf.cm

Bracket 1 -

5G M.2 1 -

SMA cable 4 -

Antenna 4 -

5G label 1 -

5G heat sink 1 -

Thermal pad 1 -

Steps

1. Remove the five screws from the rear panel using a #2 screwdriver.

Figure 2. Rear panel screw locations

2. Remove the rear panel.

6Installation procedure for 4G and 5G LTE modules

Figure 3. Remove rear panel

3. Remove the four screws from the top panel using a #2 screwdriver, then open the top panel.

Figure 4. Top panel screws removed

Installation procedure for 4G and 5G LTE modules 7

Figure 5. Open top panel

4. Replace the long, narrow thermal pad, as shown in the following figure.

Figure 6. Thermal pad replacement

5. Disconnect cables from the inside of the top panel. This includes disconnecting the switch cable and power cable from their

wire mounts, and disconnecting the switch cable and power cable connectors.

8Installation procedure for 4G and 5G LTE modules

Figure 7. Switch cable wire mount

Figure 8. Switch cable connector and power cable wire mount

Installation procedure for 4G and 5G LTE modules 9

Figure 9. Power cable connector

6. Remove the four rubber inserts from the antenna holes, then assemble the four antenna connectors using an 8 mm hex

socket.

10 Installation procedure for 4G and 5G LTE modules

Tabla de contenidos

Otros manuales de Puerta de Dell

Dell

Dell EMC Edge Gateway 5200 Manual de usuario

Dell

Dell iDRAC 8 Manual de usuario

Dell

Dell Edge 3000 Series Manual de usuario

Dell

Dell PowerConnect J-SRX100SU Manual de usuario

Dell

Dell Edge Gateway 3003 Manual de usuario

Dell

Dell EMC Edge Gateway 5200 Manual de usuario

Dell

Dell Edge Gateway 5000 Series Manual de usuario

Dell

Dell 5000 Series Manual de usuario

Dell

Dell N03G Manual de usuario

Dell

Dell Edge Gateway 3000 Series Manual de usuario

Dell

Dell Edge Gateway 3001 Manual de usuario

Dell

Dell PowerConnect J-Series Manual de usuario

Dell

Dell Edge 5100 Series Manual de usuario

Dell

Dell 5000 Series Manual de usuario

Dell

Dell Edge 5000 Series Manual de usuario

Dell

Dell Edge Gateway 5000 Series Manual de usuario

Dell

Dell Edge Gateway 3000 Series Manual de usuario

Dell

Dell EGW-3200 Manual de usuario

Dell

Dell Edge Gateway 3001 Manual de usuario

Dell

Dell SonicWall SRA 4200 Manual de servicio

Dell

Dell Edge 3000 Series Manual de usuario

Dell

Dell Edge Gateway 5000 Series Manual de usuario

Dell

Dell J-SRX210B Manual de usuario

Dell

Dell Edge 3000 Series Manual de usuario

Manuales populares de Puerta de otras marcas

LST

LST M500RFE-AS Manual de usuario

Kinnex

Kinnex Media Gateway Manual de usuario

2N Telekomunikace

2N Telekomunikace 2N StarGate Manual de usuario

Mitsubishi Heavy Industries

Mitsubishi Heavy Industries Superlink SC-WBGW256 Manual de usuario

ZyXEL Communications

ZyXEL Communications ZYWALL2 ET 2WE Manual de usuario

Telsey

Telsey CPVA 500 - SIP Manual de usuario

RTA

RTA 460A-NNA4 Hoja de especificaciones

Shaw

Shaw Gateway HDPVR Manual de usuario

ABB

ABB VSN900 Guía de inicio rápido

Commander

Commander Pulse Manual de usuario

2N Telekomunikace

2N Telekomunikace ATEUS EasyGate 501309E Manual de usuario

NETGEAR

NETGEAR C6300BD Manual de usuario

Amit

Amit CDW531AM Manual de usuario

HMS

HMS Netbiter EasyConnect EC150 Manual de usuario

Huawei

Huawei EchoLife HG620 Manual de usuario

AT&T

AT&T U-verse 3801 Manual de uso y cuidado

Logic IO

Logic IO RTCU MX2 turbo Manual de usuario

Suttle

Suttle MediaMAX MXM-521 Manual de usuario