Delfin MISTRAL 501 WD Instrucciones de instalación

Equipment classification: Industrial vacuum cleaners

Operator’s and maintenance manual

Original and official manual

Rev. 11/12/2019

Read this manual carefully before using the vacuum cleaner

MISTRAL 501 WD

MISTRAL 802 WD

Introduction

The manual must be kept with the vacuum cleaner in case of resale!

2019

This manual provides all the information needed to use and service your vacuum cleaner. Good

operation and durability depend on proper maintenance and careful use.

Before leaving the factory, this particular model has undergone stringent tests to ensure utmost

reliability. Always check however to make sure the vacuum cleaner has not been damaged during

transport in such a way as to affect operation and safety.

This manual should be considered an integral part of the vacuum cleaner and must be kept

together with the unit until this is scrapped. In case of loss of or damage to the manual, ask

DELFIN

for a new copy.

The technical details contained in this manual are the property of

DELFIN

and should be deemed

of a confidential nature.

Even partial reproduction of the graphic project, the text and the illustrations is legally forbidden.

Some details shown in the illustrations in this manual may be different from those of your vacuum

cleaner. Some component parts may have been removed for greater clarity.

For easier reference, this manual is split into sections, identifiable by specific graphic symbols.

The subjects dealt with in this manual are those expressly required by "

Machine Directive

2006/42/CE

"and the technical details shown are those provided by the manufacturer at the time

of compilation. For ATEX Vacuums, the reference directive is the 2014/34/EU.

This manual must be kept in a place accessible to all the personnel charged with operating and

servicing the vacuum cleaner.

In case of any doubts, always immediately phone the

After-Sales Service

The competent Law Court for all disputes is that of TURIN (Italy).

TECHNICAL SERVICE

Our engineers are available to help you in case any problem occurs.

Please call +39 011. 800550

 
Contents 
 
 
Information section 
1 Identification of main parts...............................................................................................................- 1 - 
2 Accessories provided ........................................................................................................................ - 2 - 
3 Identification details of manufacturer........................................................................................... - 3 - 
4 Marking plate ....................................................................................................................................... - 3 - 
5 Intended uses..................................................................................................................................... - 4 - 
6 Allowed environmental conditions................................................................................................. - 4 - 
7 Storage.................................................................................................................................................. - 4 - 
8 Scrapping ............................................................................................................................................. - 4 - 
9 Technical details................................................................................................................................. - 5 - 
10 Handling.................................................................................................................................................- 7 - 
11 Warranty................................................................................................................................................ - 8 - 
Safety section
 
1 Safety details....................................................................................................................................... - 9 - 
2 Safety warnings................................................................................................................................ - 10 - 
3 Safety plates and symbols............................................................................................................. - 14 - 
4 Outstanding risks...............................................................................................................................- 15 - 
5 Applied directives..............................................................................................................................- 15 - 
Operation section
 
1 Installation...........................................................................................................................................- 16 - 
2 Description of controls.................................................................................................................... - 18 - 
3 Work cycle............................................................................................................................................- 19 - 
4 Emptying the container ...................................................................................................................- 21 - 
Maintenance section
 
1 Informative notes .............................................................................................................................- 23 - 
2 General safety warnings.................................................................................................................- 23 - 
3 Maintenance operations .................................................................................................................- 24 - 
4 Replacing the filters.........................................................................................................................- 25 - 
5 Troubleshooting................................................................................................................................- 28 - 
Spare parts section
 
1 Recommended spare parts............................................................................................................- 30 - 
 
 
 
 
 
 

Information Section

1.1 Identification of main parts

1)ON/OFF switch

2)Push handle

3)Release fastener

4)Vacuumed material container

5)Hose for liquids drain

6)Fixed wheels

7)Castors

8)Suction pipe coupling point

Information Section

1.2 Accessories provided

MTL501WD

FI.0171.0000

D360 H260 POLYESTER FILTER

(only spare parts)

FI.0310.0000

D360 100 MICRON PPL FILTER

(only spare parts)

OPTIONS:

X: Stainless Steel AISI 304 collection container

MTL802WD

FI.0136.0000

PPL FILTER D420 WD 300

MICRON

(only spare parts)

FI.0131.0000

NYLON FILTER

D420+RUBBER BAND

(only spare parts)

FI.0133.0000

POL.G D420 MTL WD FILTER

(only spare parts)

Remark: these filters must be checked every six months. In case they are worn it will be

necessary to replace them with new ones, to be requested as spare parts to

DELFIN S.r.l.

DELFIN

S.r.l. will accept no responsibility in case of use of

NON-ORIGINAL

filters.

Information Section

1.3 Identification details of manufacturer

Delfin S.r.l.

Strada della Merla, 49/a

10036 Settimo Torinese (TO) Italy

Tel. +39 011-8005500

Fax +39 011-8005506

www.delfinvacuums.it

delfin@delfinvacuums.it

1.4 Marking plate

In compliance with the

Machine Directive 2006/42/CE

on vacuum cleaners, the machine is fitted

with

plates.

When contacting the manufacturer or dealer, always quote the details shown on the vacuum

cleaner plate.

Information Section

1.5 Intended uses

These specific vacuum cleaner models have been designed, built and protected for vacuuming

dusts liquids and solid materials only, using special filters.

For ATEX vacuums, antistatic filters are used according to ATEX Directive 2014/34/EU.

Warning!

Always use specific filters for the type of dust or materials to be vacuumed.

Any other use is considered

IMPROPER

The vacuum cleaner is in any case intended for professional industrial use.

1.6 Allowed environmental conditions

To ensure the correct operation of the vacuum cleaner, this must be positioned protected against

atmospheric agents (rain, hail, snow, fog, dusts in suspension, etc.) with an environmental running

temperature between 5°C and 45°C and relative humidity not above 70%.

The work environment must be clean, well-enough lit and devoid of explosive atmosphere.

1.7 Storage

Remove the filter and clean it, empty the container (in case of Longopac vacuums: replace the

bag) and store the vacuum cleaner in a place protected against atmospheric agents with a

temperature between 0°C and 40°C. Cover with a nylon sheet to prevent accumulation of dust.

1.8 Scrapping

In case of scrapping, all the component parts of the vacuum cleaner will have to be disposed of

through adequate disposal channels in accordance with applicable legislation.

Before scrapping, all plastic and rubber parts will have to be separated from the electrical

material. Parts made of plastic, aluminium and steel only may be recycled if collected by special

centres.

Information Section

1.9 Technical details

Model

MTL501WD

115V

MTL501WD

2MOT

MTL802WD

115V

Power

1,15

2,3

Voltage

Volts

230

115

230

115

Frequency

50/60

Max.

vacuums

rate

H2O

2.500

2.250

2.300

2.500

2.250

Max. air

flow rate

m3/h

180

360

350

Noise level

(*)

(A)

Filter type

Polyester L

+ PPL

Polyester L

+ PPL

Polyester L

+ PPL

Polyester L

+ Nylon

Polyester L

+ Nylon

Filter

surface

cm2

8.000

Capacity

Suction

inlet

Dimensions

cm.

52 X 40 X 90

53 x 59 x 106

Information Section

(*) Noise level

Noise level readings were taken in accordance with the provisions of

Machine Directive

2006/42/CE

standards.

Sound tests performed on this specific vacuum cleaner model have been taken from a distance of

1 meter and from a height of 1,60 meters, showing an acoustic pressure no higher than the one

indicates in the table.

The vibrations transmitted by the machine are lower than 2,5 m2/s.

Attention!

Pursuant to articles L.D. 81/08, workers exposed to sound pressure levels above 85 dB (A) must

be protected by special individual protection devices.

It is therefore necessary, if such working conditions exist, to provide workers with such approved

individual protection devices and to inform them of the risks relating to noise exposure.

Information Section

1.10 Handling

The machine is supplied in a strong cardboard box secured with straps.

Transport the package using a fork-lift truck of adequate lifting capacity and make sure it is stable

and that weight is properly distributed on the forks.

Before starting to move, make sure the transit area is free and that there are no moving objects

on the packaging.

During movement, keep the load low for greater stability and safety.

When starting up the vacuum cleaner, move this by means of the wheels supplied.

The appliance must never be moved using fork-lift trucks or other equipment that lifts it off the

floor.

If for any reason the need arises to lift and transport the vacuum cleaner, this operation must be

performed under the responsibility of the user. The user is therefore invited to secure the load as

he best thinks fit to ensure the operation is performed in total safety.

(cm)

Weight

(package included )

MTL 501 WD

100

MTL 802 WD

160

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Aspiradora de Delfin

Delfin

Delfin DG 70 EXP Z22 Instrucciones de instalación

Delfin

Delfin D/G 1 Z22 Instrucciones de funcionamiento

Delfin

Delfin MTL202DS Instrucciones de instalación

Delfin

Delfin MTL300BLC2D2DB Instrucciones de instalación

Delfin

Delfin ESD.MTL-0468 Instrucciones de instalación

Delfin

Delfin MISTRAL 352 DS Instrucciones de instalación

Delfin

Delfin DG150 SE Instrucciones de instalación

Delfin

Delfin TP.CV-070 Instrucciones de instalación

Delfin

Delfin DM3 ENTRY-LEVEL Instrucciones de instalación

Delfin

Delfin HV102 Manual de usuario

Delfin

Delfin MTL501WD Instrucciones de instalación

Delfin

Delfin DM35 SGA Instrucciones de instalación

Delfin

Delfin DM32BL Instrucciones de instalación

Manuales populares de Aspiradora de otras marcas

Bissell

Bissell LittleGreen Proheat 1425 Series Manual de usuario

Panasonic

Panasonic MC-YL637S147-AE Manual de usuario

NEFF

NEFF N17XH10 0 Series Manual de usuario

LG A9 Series Manual de usuario

Oreck

Oreck Cordless Captura BK51700 Series Manual de usuario

Kogan

Kogan KAVACROBVWA Manual de usuario

Kränzle

Kränzle VENTOS 50 ID Guía del usuario

EVVO

EVVO Ai35 Manual de usuario

DeWalt

DeWalt DWH200D Manual de usuario

Pontec

Pontec Pondomatic Vacuum Cleaner Manual de usuario

Cleanmaxx

Cleanmaxx PC-P007E Manual de usuario

Exido

Exido 240-114 Manual de usuario

RIDGID

RIDGID WD1685AU0 Manual de usuario

Ezviz

Ezviz RE4P Manual de usuario

STG global

STG global TANVAC HDV3000 Manual de usuario

Shark

Shark ROTATOR PRO COMPLETE NV550 Series Manual de usuario

Factory

Factory M3340 Manual de usuario

Shop-Vac

Shop-Vac VN92 SERIES Manual de usuario