Definox Sorio Basic 1EV Manual de usuario

NI-267 index 1 June 2021

Cam

INSTALLATION GUIDE

Sorio® Basic 1EV control unit

www.definox.com

DEFINOX SAS

3 Rue des Papetiers - Z.A.C. de Tabari 2

44190 Clisson - France



+33 (0)2 28 03 98 50



+33 (0)2 28 03 88 00

E-Mail: [email protected]



Recommendations

IMPORTANT

For any intervention or configuration change, see the

maintenance manual (NM-278) available on the website:

http://www.definox.com/

AIR QUALITY

•Dry and filtered air at 10µm (DIN ISO 8573-1)

•Operating pressure: 5 to 7 bars

ELECTRIC

M16 x 1.5 cable gland

Digital terminal block version:

•Operating voltage:

Digital : 24 VDC only _ +/- 5%.

•Conductor section: 0.5mm² recommended and 0.75mm²

max.

•Ø cable : 4 to 10 mm.

IMPORTANT

For disassembly and handling of the unit, provide a minimum

clearance of 50 mm above the cover.



Locking and unlocking the cover

Cover locked

Cover unlocked

•Turn the cover counterclockwise to bring the fin to the

stop, then remove the cover by pulling it up.



Mounting the cam

•Screw the cam and tighten with a tool according to the table (tightening torque: ≥2N.m or 20Kgf.cm).

Reference

Cam

Visual

Tools

7162010

Allen spanner 2.5

≥2 Nm

7162011

Allen spanner 2.5

≥2 Nm

7162012

M10

Open

end spanner 17

7162013

M12

Open

end spanner 17

7162014

M16

Open

end spanner 17

7162138

M6 Female

Allen spanner 2.5

≥2 Nm

7162189

M5 Female

Allen spanner 2.5

≥2 Nm



Assembling the actuator base

•Position the base by aligning the indexing pin to the 1/8

Gas hole.

•

Screw in the two non-detachable CHC screws [A] to fix

the base on the actuator and tighten them (tightening

torque: ≥1N.m or 10Kgf.cm).

Indexing pin

1/8 Gas Hole

NI-267 index 1 June 2021



Assembly Cable / Cable gland



Reassembling the cover

•Position the cover in the notch on the base. Fin in the alignment above.

•Press the cover onto the base.

•

Lock by turning the cover clockwise until the fins of the cover and the base are aligned.



Pneumatic connexion



Sorio® Basic 1EV unit



EV: Solenoid valve

1: Actuator air inlet

E: Exhaust

P: Air pressure

ACT: Exhaust (actuator Normally Closed)

Or Air inlet (actuator Normally Open)

Cover fin

Base fin

Cover fin

Sensor

High Position

Sensor

Low Position

Terminal

block 1EV

N.C

•Apply pressure to the channel [P].

•For an actuator operating as N.C. (Normally closed),

connect the actuator to the channel [1] of the box as

shown opposite.

ACT

N.O

•Apply pressure to the channel [P].

•For an actuator operating as N.O. (Normally open),

connect the channel [ACT] to the channel [1] of the

box and put a pierced plug on the actuator as shown

opposite.

•

Unscrew the nut [B] from the cable gland [C].

•

Pass the connection cable inside the nut, then the cable gland to connect it to

the terminal block [D].

•

Tighten the nut [B].

•

Connect the connections to the terminal block

Pierced

plug

ACT

Otros manuales de Unidad de control de Definox

Definox

Definox DCX3 Manual de operación y mantenimiento

Definox

Definox DCX3 Manual de operación y mantenimiento

Definox

Definox DCX3 Manual de usuario

Definox

Definox VEOX PMO Manual de operación y mantenimiento

Definox

Definox Sorio Basic 3EV Manual de usuario

Definox

Definox VEOX SP 3 BODY Manual de operación y mantenimiento

Definox

Definox DPX1EBC Manual de operación y mantenimiento

Definox

Definox DPAX Manual de usuario

Definox

Definox DPX EBC Manual de usuario

Definox

Definox DCX3 Manual de usuario

Definox

Definox DCX4 HP Manual de usuario

Definox

Definox DCX3 Manual de operación y mantenimiento

Definox

Definox VDCI-MC PFA Manual de usuario

Definox

Definox Sorio Manual de operación y mantenimiento

Definox

Definox DPAX GEN 2 Manual de usuario

Definox

Definox DCX3 Instrucciones de funcionamiento y mantenimiento

Definox

Definox ICS Manual de operación y mantenimiento

Definox

Definox VDCI-MC-FC Manual de operación y mantenimiento

Manuales populares de Unidad de control de otras marcas

Festo

Festo Compact Performance CP-FB6-E Manual de lista de piezas

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Manual de usuario

JS Automation

JS Automation MPC3034A Manual de usuario

JAUDT

JAUDT SW GII 6406 Series Guía rápida

Spektrum

Spektrum Air Module System Manual de usuario

BOC Edwards

BOC Edwards Q Series Manual de usuario

KHADAS

KHADAS BT Magic Manual de usuario

Etherma

Etherma eNEXHO-IL Manual de usuario

PMFoundations

PMFoundations Attenuverter Manual de usuario

GEA

GEA VARIVENT Manual de usuario

Walther Systemtechnik

Walther Systemtechnik VMS-05 Manual de usuario

Altronix

Altronix LINQ8PD Instrucciones de montaje

Eaton

Eaton Powerware Series Manual de usuario

WAGO

WAGO 750-407/040-000 Manual de usuario

Sony

Sony CCU-590 Manual de usuario

Graco

Graco 25D614 Manual de usuario

Task Force Tips

Task Force Tips YE-RF-900 Manual de programación

Shini

Shini SPV-U Series Manual de usuario