Curtis PCGT3 Manual de usuario

Service & Sales

1-800-421-6150 www.wilburcurtis.com

TROUBLESHOOTING GUIDE

G3 PRIMO CAPPUCCINO SYSTEMS

MODELS: PCGT3, PCGT4, PCGT5, PCGT6

Service & Sales

1-800-421-6150 www.wilburcurtis.com

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PART # DESCRIPTION

PCGT3 PARTS IDENTIFICATION

1. WC-37126 KIT, UCM BOARD & LABEL PCGT3

2. WC-5310 TUBING, 5/16” ID x 1/8” W SILICONE

3. WC-37054 SOCKET, GEAR

4. WC-37174 KIT, GEAR MOTOR & GEAR

5. WC-780 CONTROL, POWER MODULE CORK BREAK

6. WC-6193-0 HEAT SINK ASSEMBLY

7. WC-3739 WHIPPING MOTOR

8. CA-1095 CONNECTOR, ORIFICE WATER

9. CA-1011-05 BULKHEAD, WATER FITTING

10. WC-43791 RING, MOTOR SHAFT PLASTIC

11. CA-1005-03 STEAM TRAP

12. CA-1009-03 MIXING BOWL

13. CA-1006-06 CHAMBER, WHIPPER OFFSET PCGTs

14. CA-1037-3Y TUBE, EXTENSION YELLOW

PART # DESCRIPTION

15. WC-37118 KIT, WHIPPER PLATE (3/PKG)

16. CA-1024-05 PILLAR, LOCATION BLACK

17. CA-1008-07K KIT, PROPELLER WHIPPER 6/PKG OFFSET BLD

18. WC-37008 KIT, TANK LID ROUND

19. WC-5502-01 KIT, PROBE, ASSY WATER LEVEL W/HEX

FITTING, O-RING & NUT

20. WC-2627 BUSHING, CONICAL

21. WC-2630 BUSHING, CONICAL BLIND

22. WC-3734 KIT, DUMP VALVE 120V 12W

23. WC-904-04 HEATING ELEMENT 1600W 120V W/JMNUT

24. WC-1438-101 SENSOR, TEMPERATURE TANK

25. WC-523 THERMOSTAT, MNL RESET 120/240V 25A

26. WC-102 SWITCH, TOGGLE NON-LIT 25A 120/240VAC

27. WC-826L VALVE, INLET 1GPM 120V 10W

FRONT VIEW CHASSIS VIEW HEATING TANK VIEW

Service & Sales

1-800-421-6150 www.wilburcurtis.com

18. WC-37008 KIT, TANK LID ROUND

19. WC-5502-01 KIT, PROBE, ASSY WATER LEVEL W/HEX

FITTING, O-RING & NUT

20. WC-2627 BUSHING, CONICAL

21. WC-2630 BUSHING, CONICAL BLIND

22. WC-3734 KIT, DUMP VALVE 120V 12W

23. WC-904-04 HEATING ELEMENT 1600W 120V W/JMNUT

24. WC-1438-101 SENSOR, TEMPERATURE TANK

25. WC-523 THERMOSTAT, MNL RESET 120/240V 25A

26. WC-102 SWITCH, TOGGLE NON-LIT 25A 120/240VAC

27. WC-826L VALVE, INLET 1GPM 120V 10W

28. WC-37127 KIT, UCM BOARD & LABEL PCGT4

WC-37128 KIT, UCM BOARD & LABEL PCGT5

29. WC-39957 MEMBRANE CONTRL PANEL PCGT4/5

WC-39753 MEMBRANE CONTRL PANEL PCGT4/5 (OLD)

30. CA-1039 O-RING, DUMP VALVE

31. CA-1135 LATCH ASSY, DOOR

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PART # DESCRIPTION

PCGT4/5/6 PARTS IDENTIFICATION

1. WC-37126 KIT, UCM BOARD & LABEL PCGT3

2. WC-5310 TUBING, 5/16” ID x 1/8” W SILICONE

3. WC-37054 SOCKET, GEAR

4. WC-37174 KIT, GEAR MOTOR & GEAR

5. WC-780 CONTROL, POWER MODULE CORK BREAK

6. WC-6193-0 HEAT SINK ASSEMBLY

7. WC-3739 WHIPPING MOTOR

8. CA-1095 CONNECTOR, ORIFICE WATER

9. CA-1011-05 BULKHEAD, WATER FITTING

10. WC-43791 RING, MOTOR SHAFT PLASTIC

11. CA-1005-03 STEAM TRAP

12. CA-1009-03 MIXING BOWL

13. CA-1006-06 CHAMBER, WHIPPER OFFSET PCGTs

14. CA-1037-3Y TUBE, EXTENSION YELLOW

15. WC-37118 KIT, WHIPPER PLATE (3/PKG)

16. CA-1024-05 PILLAR, LOCATION BLACK

17. CA-1008-07K KIT, PROPELLER WHIPPER 6/PKG OFFSET BLD

PART # DESCRIPTION

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PARTS IMAGES

WC-37126

KIT, UCM BOARD & LABEL PCGT3

WC-37054

SOCKET, GEAR

WC-3734

TUBING, SILICONE

WC-37174

KIT, GEAR MOTOR & GEAR

WC-6193-0

HEAT SINK ASSEMBLY

WC-780

CONTROL, POWER MODULE

WC-3739

WHIPPING MOTOR

CA-1011-05

BULKHEAD, WATER FITTING

CA-1095

CONNECTOR, ORIFICE WATER

WC-43791

RING, MOTOR SHAFT PLASTIC

CA-1009-03

MIXING BOWL

CA-1005-03

STEAM TRAP

CA-1006-06

CHAMBER, WHIPPER OFFSET

WC-37118

KIT, WHIPPER PLATE

CA-1037-3Y

TUBE, EXTENSION YELLOW

Service & Sales

1-800-421-6150 www.wilburcurtis.com

PARTS IMAGES

CA-1024-05

PILLAR, LOCATION BLACK

WC-37008

KIT, TANK LID ROUND

CA-1008-07K

KIT, PROPELLER WHIPPER OFFSET

WC-5502-01

KIT, PROBE ASSY

WC-3734

KIT, DUMP VALVE

WC-2627

BUSHING, CONICAL

WC-904-04

HEATING ELEMENT

WC-523

THERMOSTAT, MNL RESET

WC-1438-101

SENSOR, TEMPERATURE TANK

WC-102

SWITCH, TOGGLE NON-LIT

WC-37127 / WC-37128

KIT, UCM BOARD & LABEL PCGT4/5

WC-826L

VALVE, INLET

WC-39957 / WC-39753 (OLD)

MEMBRANE, CONTROL PANEL PCGT4/5

CA-1135

LATCH ASSY, DOOR

CA-1039

O-RING, DUMP VALVE

WC-2630

BUSHING, CONICAL BLIND

Service & Sales

1-800-421-6150 www.wilburcurtis.com

Is the water level in the tank in contact with

the water level probe? If not, See TANK

FILLING ISSUES.

Yes:

No:

If the LCD does not read “Heating” verify cor-

rect Temperature programming, then replace

the Temperature Sensor.

Does the LCD read “Heating”?

Yes:

No:

No: Replace Reset Thermostat

Yes: Proceed to #5

Verify that there is 12 vac between pins 1 &

2 on the 14 pin connector at the UPM and

120 vac between pins 1 & 2 on the 12 pin

connector at the UPM.

No: Replace transformer.

Yes: Verify 5 vdc between pins 1 & 2 on the

4 pin connector at the Smart Card Module.

No: Replace UPM

Yes: Replace Smart Card Module

Verify that the panel breaker is turned on. If

okay, proceed STEP 2.

Verify that the voltage at the receptacle is

correct: L1-N = 120 vac, N-G = 0 vac. if

okay, proceed to STEP 3.

Verify that the toggle switch is turned on.

Verify 120 vac on both terminals.

No: Replace Toggle Switch

Yes: Proceed to STEP 4

Verify that there is 120 vac on both sides of

the Reset Thermostat, measuring between

L1-N.

TROUBLESHOOTING INSTRUCTIONS

POWER ISSUES

The LED light on the front door are not lit:

HEATING ISSUES

Verify 120 volts at the Heating Element. If

120 volts is present, replace the Heating

Element.

Verify 120 volts to the Triac Gate: If yes,

replace Triac. If no, replace UPM.

Not heating:

Overheating:

iIf the water in the tank is not in contact

with the probe – refer to tank lling issues.

The unit will not heat until the water in the

tank has contacted the probe.

Verify that resistance on temp Sensor reads

less than 10k ohm. Verify correct mounting

to tank. Replace sensor.

Check Triac for continuity between A1 &

A2. If continuity is present, replace Triac. If

there is no continuity, replace the UPM.

Service & Sales

1-800-421-6150 www.wilburcurtis.com

Is the water turned on?

Yes:

No:

Yes:

No:

TROUBLESHOOTING INSTRUCTIONS - continued

DISPENSING ISSUES

TANK FILLING ISSUES

Overlling:Not lling:

Powder not being dispensed on any

selection:

Verify that the wiring to the Auger Motors is

correct. If the wiring is correct and unbroken,

replace the UCM UCM (shorted wash button) or

Membrane Control Panel (PCGT 4/5/6).

Powder not being dispensed from a single

selection:

Verify that the canister has sufcient product.

Verify that the Auger Motor has 120 volts.

If yes, replace the Auger Motor. If the Auger

Motor does not have 120 Volts, replace the UPM.

Not dispensing water on any selection:

Refer to TANK FILLING ISSUES.

Verify 120 volts at inlet valve coil

Replace Inlet Valve

Remove Orange wire from the Water

Level Probe. Does the Tank Fill?

Replace Water Level Probe.

Replace UPM

Does the tank continue to ll after the toggle

switch has been turned off ?

Yes:

No:

Yes:

No:

Replace Water Inlet Valve.

Remove the Orange wire from the Wa-

ter Level Probe and connect it to ground.

Does the tank stop lling?

Replace the Water Level Probe

Replace the UPM

Whipper Motor not running:

Verify that the propeller and chamber are

assembled correctly (not binding).

Verify that the Whipper Motor has 120 volts. If

yes, replace the whipper motor. If the Whipper

Motor does not have 120 volts, verify that the

wiring is correct and unbroken. If so, replace

the UPM.

iIf the Dispense valve on the same selection

is operating, the UPM does not need to be

replaced. The Whipper Motor and Dispense

valve are powered together by the UPM.

APR/2014 M47_TS_WC_PCGT_revNC

Wilbur Curs Co., Inc.

6913 Acco Street, Montebello CA 90640

Customer Service: 800.421.6150 | 323.837.2300

csrassistance@wilburcurs.com

Tech Support: 800.995.0417

www.wilburcurs.com

Otros manuales para PCGT3

Este manual sirve para los siguientes modelos

Tabla de contenidos

Otros manuales de Dispensador de bebidas de Curtis

Curtis

Curtis Chill-X Manual de usuario

Curtis

Curtis PCGT4 Manual de usuario

Curtis

Curtis Chill-X CFBX2 Manual de usuario

Curtis

Curtis TCC2S Manual de usuario

Curtis

Curtis C-5HS Manual de usuario

Curtis

Curtis TCO-419 Manual de usuario

Curtis

Curtis TCC2N Manual de usuario

Curtis

Curtis CFB1 Manual de usuario

Curtis

Curtis TXSG0101S600 Manual de usuario

Curtis

Curtis CFB2 Manual de usuario

Curtis

Curtis FRP500 Manual de operación

Manuales populares de Dispensador de bebidas de otras marcas

PEGAS

PEGAS Evolution Manual de usuario

Ugolini

Ugolini MT micro Manual de usuario

Bunn

Bunn SLCA-7 Instrucciones de instalación

Gekkeikan

Gekkeikan Sake Machine Manual de usuario

Olympia

Olympia DH709 Manual de usuario

Marco

Marco ECOSMART PB10 Manual de usuario

Marvel

Marvel ML24BN Series Manual

Cecilware

Cecilware 2K-GB-LD Manual

Sure Vend

Sure Vend 673 Manual de usuario

Cornelius

Cornelius 2 Flavor Post-Mix Cold Coffee Dispenser Quest... Manual de usuario

Nostalgia Electrics

Nostalgia Electrics KEG7000SS Manual de usuario

Bunn

Bunn LCR-3 HV Guía de solución de problemas

Servend

Servend SV-200 Manual de usuario

EdgeStar

EdgeStar VBR440 Manual de usuario

Cornelius

Cornelius A.B.S. Unit Manual de usuario

CDS AUTOMATEN

CDS AUTOMATEN ML-16C2-C Manual de usuario

Siemens

Siemens GA 3000 Manual de instrucciones y seguridad

Cornelius

Cornelius FCB V4 Especificaciones