Cretors Nacho Alto Manual de usuario

176 MITTEL DRIVE, WOOD DALE, IL 60191

Model Nacho Alto

Warmer and Display Cabinets Manual

120 Volt, Single Phase, 60 Hz (-A)

230 Volt, Single Phase, 50 Hz (-E)

READ and UNDERSTAND these operating and safety

instructions before operating this Cretors machine

NACHO ALTO 6 13

TABLE OF CONTENTS

I. Safety Alert Symbol...............................................................................................3

II. Safety First ..............................................................................................................3

III. Introduction............................................................................................................3

IV. Purpose of Manual ................................................................................................4

V. Product Identification...........................................................................................4

VI. Principles of Display Cabinet Operation ...........................................................4

VII. Control Switch .......................................................................................................4

VIII. Installation Instructions........................................................................................4

IX. Operating Instructions..........................................................................................5

X. Sanitation Instructions..........................................................................................5

XI. Service Instructions ...............................................................................................6

Troubleshooting.....................................................................................................6

NACHO ALTO 6 13

I. SAFETY ALERT SYMBOL

The symbol shown is used to call your attention to instructions concerning your personal safety

and the safety of others. Watch for this symbol. It points out important safety precautions. It

means ATTENTION! Become Alert! Your personal safety is involved! Read the message that

follows and be alert to the risk of personal injury or death.

II. SAFETY FIRST

The information in this manual is essential for the safe installation and

operation of your Cretors machine. The manual must be read and

understood before installing, and operating the equipment, or equivalent

training must be provided.

The employer shall instruct each employee in the recognition and avoidance

of unsafe conditions, as well as, the regulations applicable to his work

environment and to control or eliminate any hazards or other exposure to

illness or injury. Ref.: 29 CFR 1926.20 (b)(4)(a)(2)

It is understood that safety rules within individual companies vary. If a conflict

exists between the safety procedures contained in this manual and the rules of a

using company, the more stringent rule should take precedence.

III. INTRODUCTION

This manual is filled with time-saving and money-saving information regarding your Cretors

machine. There is nothing more important than the safety aids and warnings that are throughout

this document. The Safety Alert Symbol is used to identify topics of primary safety concern

wherever they appear.

If, after reviewing this manual, anything is unclear or technical problems are encountered, contact

the distributor from whom you purchased your machine for assistance. If there are any additional

questions, feel free to contact our Customer Service Department at the address and/or phone

number listed on the last page of this manual. Always have the model and serial number of your

machine available to assist in obtaining the correct information.

NACHO ALTO 6 13

IV. PURPOSE OF MANUAL

This instruction manual is intended to familiarize owners with the operation and safety

procedures associated with your Cretors machine.

It is important that this manual be kept available to operating personnel.

V. PRODUCT IDENTIFICATION

CRETORS POPCORN AND NACHO DISPLAY CABINET

MODEL

NAAON-X/NAECN-X –WARMER/DISPLAY CABINET

Electrical:

120 Volt, 60 Cycle, 555 Watts

230 Volt, 50 Cycle, 555 Watts

VI. PRINCIPLES OF DISPLAY CABINET OPERATION

Theory and Observations of Display Cabinet Operation

The Display/Warmer Cabinets hold nacho chips, popcorn, or other snacks to maximize the sell

ability of snacks. Load and un-load product through the large door on the unit’s front. The

unit features a corrosion-resistant design and tempered glass for easy cleaning; the surface will

not scratch or discolor. The unit’s doors are easily-removable, for cleaning. Rubber feet

prevent skidding on counter top surfaces. The cabinet is provided with forced hot air to keep

product warm and lighted cabinet and sign for enhanced merchandizing.

VII. CONTROL SWITCH

MAIN POWER SWITCH -Controls light and cabinet heat.

VIII. INSTALLATION INSTRUCTIONS

1. Location

Choose a location for your Cretors Display/Warming Cabinet to maximize the ease of

operation and maintenance procedures. Check your local building and fire codes for

location restrictions.

2. Power Supply

Check the nameplate to determine the required power supply.

NACHO ALTO 6 13

Connect your cabinet only to the correct power source.

Make certain the main power switch on the cabinet is in the 'OFF' position when

plugging into power source.

3. Install the racks

Install the clips in all four corners at the same height, as desired. The unit is provided with

six (6) racks and twenty-four (24) clips which can be installed to accommodate different size

packaging and for optimal merchandizing. Rack supports snap into place.

IX. OPERATING INSTRUCTIONS

Do not attempt to operate your Cretors Display Cabinet until you have read and

understood this manual. Failure to do so may result in serious injury or death.

Do not attempt to operate your Cretors machine unless the installation instructions

have been strictly adhered to. Failure to do so may result in serious injury or death.

Operate your display cabinet only if it is in sanitary condition (SANITATION

INSTRUCTIONS). Failure to do so may result in illness to your customers.

1. Turn on rocker switch to turn on light, blower and heat.

2. Load unit with product. Do not overfill the cabinet.

3. Dispense product through the front door. If machine is ordered as pass thru, the unit

can be loaded and unloaded from either side.

X. SANITATION INSTRUCTIONS

Be certain the machine is turned off and the power is unplugged before sanitizing this

machine, unless a specific cleaning procedure requires power to the machine. Failure

to do so could result in serious injury or death.

Do not clean heated surfaces until they have been given sufficient time to cool.

Failure to do so may result in serious burns or scalds.

Do not immerse the cabinet in water. This will damage the electrical components, and

may cause short circuits, resulting in an electrical shock hazard if power is applied.

NACHO ALTO 6 13

1. After unit has been allowed to cool and has been unplugged, remove any excess

product remaining in the bottom.

2. Clean all surfaces with a non-abrasive food safe cleaner.

This appliance should not be cleaned with a water jet.

XI. SERVICE INSTRUCTIONS

Only a qualified person should perform the following diagnostic checks, and, if

necessary, corresponding adjustments and repairs. Many of the following procedures

may present an electrical shock hazard and can cause serious injury or death.

Perform work only on de-energized circuits. Failure to do so may lead to electrical

shock resulting in personal injury or death.

A. Parts

When ordering parts, refer to the recommend spare parts list included with this manual or

wiring diagram. Always supply the serial number and model number of your machine.

B. Check Unit Periodically

Periodically check electrical switch and cord for signs of wear. Check all screws and rivets

for tightness.

C. To Access Electrical Components

To access all electrical components, unplug power cord from outlet, and then lay unit on its

side and remove the four screws from the bottom cover, exposing heating element, switch,

and wiring. THIS UNIT IS NOT FUSED.

D. Troubleshooting

PROBLEM

POSSIBLE CAUSE

ACTION

Unit will not heat.

Machine unplugged or not

switched on.

Plug unit in. Turn on power.

Loose connection to heat

element or failure.

Blower unplugged or blocked

Thermostat failed

Repair connection or replace

element

Check for any blockage and

clear

Replace thermostat

NACHO ALTO 6 13

This manual is filled with timesaving and money-saving information regarding your Cretors

Display Cabinet. There is nothing, however, more important than the safety aids and warnings

found throughout this document.

If you have any questions, feel free to contact our Customer Service Department at 800-840-6166.

Additional copies of this manual can be obtained from Customer Service.

Cretors warranties this machine to be free of defects in parts, materials, and workmanship for one

year. Please complete and return the registration card to activate your warranty. If you have

questions concerning the warranty, please contact Customer Service at 800-840-6166.

CUSTOMER SERVICE HOURS:

Our office hours are 8:30 a.m. to 5 p.m. (U.S. Central Time) Monday through Friday. An answering

machine is in use all other times.

SHIPPING POLICY:

We make every effort to ship approved orders on the requested ship date. If a delay in shipment is

necessary, you will be notified. Pallet quantities vary by product. Please inquire when placing

order. Most of our products are shippable by UPS.

DAMAGE OR SHORTAGE POLICY:

We recommend that you do not sign the delivery receipt until after inspecting the product(s).

Claims can be filed if a shortage is observed, but only when it has been noted on the delivery

receipt.

C. CRETORS AND COMPANY

3243 N. CALIFORNIA AVENUE

CHICAGO, IL 60618

PHONE (773) 588-1690, (800) 228-1885, FAX (773) 588-2171

WEB SITE: http://www.cretors.com Email: po[email protected]om

Cretors joins the information age! Check out our links http://www.twitter.com

http://www.facebook.com/pages/Chicago-IL/C-Cretors-Co/90143449620

NACHO ALTO 6 13

RECOMMEND SPARE PARTS LIST

PART DESCRIPTION

PART NUMBER

DOOR HINGE

16938-LH or -RH

LIGHT STRIP

18410-ASSY

DOOR

16924-L or -R

KNOB

1292

MAGNET

19122

FAN

16996-A/ -E

HEAT ELEMENT

16997-A/ -E

RACK SUPPORT CLIPS

16807

RACKS

16904

C. CRETORS AND COMPANY

176 MITTEL DRIVE

WOOD DALE, IL 60191

PHONE (773) 588-1690, (800) 228-1885, FAX (847) 616-6970

WEB SITE: http://www.flo-thru.com Email: [email protected]

Email: postmaster@cretors.com

Tabla de contenidos

Otros manuales de Vitrina de Cretors

Cretors

Cretors TW Manual de usuario

Cretors

Cretors 1100 Manual de usuario

Cretors

Cretors 1101 Manual de usuario

Manuales populares de Vitrina de otras marcas

Hatco

Hatco FLAV-R-SAVOR FSCD Series Manual de usuario

Bonnet Neve

Bonnet Neve SKYLIGHT Manual de usuario

True

True TCGD-50 Manual de usuario

Tecnodom

Tecnodom EVO SELF Instrucciones de funcionamiento

Delfield

Delfield F15SC48N Manual de usuario

saro

saro FIONA Manual de usuario

Hendi

Hendi 233962 Manual de usuario

Hoshizaki

Hoshizaki HNC-120BE-L-BLH Manual de usuario

Nordcap

Nordcap GENIUS 2 H145-L70 Manual de usuario

Omcan

Omcan RS-CN-0140-D Manual de usuario

Tecnodom

Tecnodom M Series Instrucciones de funcionamiento

freor

freor MERCURY Manual de usuario

Costan

Costan WHALE 2000 G LG300 Manual de usuario

Costan

Costan IMPALA Manual de usuario

True Manufacturing Company

True Manufacturing Company TCGD-50 Manual de usuario

Bartscher

Bartscher 100L Manual de usuario

Steelcase

Steelcase Opus Manual de usuario

Hatco

Hatco Glo-Ray GRHD-2P Guía de aplicación